2019 Hyundai Santa Fe: engine failure

Filed Sep 2, 2026 · Engine, Fuel system · VA

Update Re: ODI Complaint Number: 11759237 Subsequent Actions and Manufacturer Refusal to Remediate Safety Defect: ​Following the [XXX], acute safety incident—where the vehicle lost motive power and entered severe limp mode on [XXX] immediately upon release from Sheehy Hyundai of Chantilly—the vehicle remained in dealer custody for 11 days (August 20–August 31, 2026). ​Failure to Diagnose Core Defect: Despite recurring total power loss, active diagnostic trouble code P00AF00 (Turbocharger Boost Control Module Performance), and four consecutive turbocharger destructions within 20,000 miles, the authorized dealership refused to conduct internal engine diagnostics, drop the oil pan, inspect the oil filter, or perform borescope checks. ​Physical Contamination Documented: On August 29, 2026, an on-site physical inspection confirmed sparkling metallic particulate suspended in the engine oil on the dipstick and substantial oil blow-by/intrusion into the turbocharger air intake line. ​Formal Denial of Safety/Warranty Coverage: On August 31, 2026, dealership management and Hyundai Motor America (Consumer Affairs Case #[XXX]) formally denied warranty assistance and refused engine teardown under the Theta II Lifetime Engine Warranty Settlement. Coverage was declined citing "outside influence" due to an aftermarket turbocharger assembly, while Hyundai refused to investigate the underlying engine failure contaminating and destroying the forced-induction system. ​Evidence Preservation: On August 31, 2026, the vehicle was towed to an independent facility to mitigate road hazards, conduct teardown diagnostics, and preserve the engine oil/filter for ISO-accredited spectrographic laboratory analysis. ​The manufacturer released an unsafe vehicle into traffic on August 20, 2026, and subsequently refused to investigate or remedy a documented internal engine failure that creates sudden, recurring loss of motive power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 22, 2026 · Transmission · NY

Transmission was replaced under warranty by Hyundai in Nov 2024. Engine was replaced at 100600 miles in Nov 2025. Issues with the transmission were happening at that time but ignored by dealership as issues related to failing engine. Our mechanic confirmed in April that transmission was failing and told us to go to Hyundai. We went to dealer in April 2026. They confirmed transmission needed to be replaced. They were going to contact Hyundai USA. We received no updates despite many calls to the dealer. We had to call Hyundai USA directly. They opened a case. Dealer finally called and took car in and requested good faith repair by Hyundai USA. Hyundai USA responded 2 weeks later and is not covering anything. They replaced our transmission in Nov 2024 with a refurbished transmission that they NO LONGER MAKE. Clearly due to the fact that the refurbished part doesn’t work. They now want me to pay $8000 to repair transmission. My car has been maintained on schedule by my mechanic. All paperwork available. I have had Toyotas, Hondas and chevys that have lasted close to 20 years. This has been a horribly disappointing experience. And I now need to buy a new car for my 17 year old instead of handing down. I will NEVER buy another Hyundai. I want everyone to be aware of my experience. Disgusting customer service by Hyundai USA.

Filed Jul 12, 2026 · Engine, Fuel system · GA

COMPLAINT SUMMARY: [XXX] / ENGINE THERMAL FIRE RISK / WARRANTY DECEPTION My 2019 Hyundai Santa Fe (2.4L GDI Engine) is experiencing severe powertrain degradation under the known Theta II engine defect class-action framework. On November 7, 2025, the vehicle logged a Permanent Diagnostic Trouble Code (DTC) P1326 via an independent scan, indicating catastrophic internal rod bearing wear. On XXX, the vehicle was brought to Hyundai of Milledgeville for safety recall verification. Instead of executing the mandatory corporate-directed Bearing Clearance Test (BCT) to replace the failing engine block, the service department committed technical campaign malpractice. The technician forced the 9C2 ECU Software Update directly over the locked mechanical fault to suppress the dashboard warning lights and alter the vehicle's ROM ID parameter limits. When caught via a photograph of their active GDS diagnostic tablet showing 7 historical system faults, the service manager provided a truncated printed report hiding Page 1 and omitting the critical P1326 powertrain code count to evade a warranty engine replacement. Due to these unmitigated delays, the vehicle has suffered severe consequential safety damage. The advanced engine degradation and oil consumption have flooded the exhaust system, melting the catalytic converter substrate and triggering a new DTC P042000 (Catalyst Efficiency) fault immediately after the dealer visit. The extreme engine vibrations have also damaged the transmission's torque converter clutch (DTC P074100). The dealership refused a service loaner and knowingly sent a disabled consumer and an elderly passenger away in an active, failing vehicle that presents a sudden stall-on-highway hazard and a severe thermal exhaust fire risk under extreme summer heat conditions. Hyundai Motor America Corporate has failed to provide emergency towing or alternative mobility accommodations despite a registered corporate case file. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

Filed Jan 22, 2026 · Engine, Fuel system · MD

My Hyundai Santa Fe 2019 Limited is burning oil. It started after the Turbo broke in October 2024. The turbo began leaking oil and then died. I took it to the dealership as it is still under warranty and they replaced the turbo. As a result, I have had issues ever since and now my car burns oil at a fast rate. In between oil changes I need to put oil in the engine to avoid it being drained. I am able to go about 3k miles on Synthetic oil and by 2.5-3k it is almost empty. It has been doing this now since 2024. I just had my 90k mile check up complete and with that I got an oil change. This was done in November 2024. Syntehtic oil was used. On January 16, as I was driving my car mileage decreased, the car began to shake and the engine light came on. I was able to safely stop and have the car towed. It was found that after driving just 2k miles the oil had completely burned off. I currently have an appointment at the dealer for them to run diagnostics on why it is burning. I saw there was a class action lawsuit against other Hyundai's doing the same thing and as a result Hyundai has to replace the engine. I also have read numerous forums where everyone is reporting the same thing with this particular model of it burning oil. I wanted to report this in case there were other owners of the same car experiencing the same thing.

Filed Jan 21, 2026 · Engine, Transmission · CA

Complaint: Safety Defect - Engine Failure Risk (Stalling/Fire) My 2019 Hyundai Santa Fe has the defective Theta II 2.0L Turbo engine (G4KH), subject of class action In re: Hyundai and Kia Engine Litigation and multiple TSBs. The engine has a known manufacturing defect causing premature connecting rod bearing failure, leading to catastrophic engine seizure. SAFETY CONSEQUENCE: This defect presents a clear, unreasonable safety risk: Sudden Stalling: Engine can seize without warning while driving, causing loss of propulsion and power steering/brakes, leading to a crash. Engine Fire: Failed engines can leak oil onto hot components, causing fires. MANUFACTURER'S INADEQUATE REMEDY: Hyundai's "Knock Sensor Detection System" software update (Campaign 966) only attempts to detect failure moments before it happens. It does NOT fix the underlying mechanical defect. The engine remains a ticking time bomb. PERSONAL EXPERIENCE: My vehicle has suffered multiple related failures (turbocharger, fuel injectors) costing over $5,700, confirming the powertrain's deterioration. I fear driving it, especially with my teenage daughter. The defect is well-known, yet Hyundai's settlements fail to protect subsequent owners like myself, leaving unsafe vehicles on the road. REQUEST: I urge the federal safety agency to investigate the ongoing safety risk these engines pose to all owners, compel Hyundai to issue a true safety recall for a permanent repair (e.g., engine long-block replacement), and mandate clear disclosure of this defect to all used car buyers.

Filed Jan 17, 2026 · Engine, Steering · WA

internal mechanical failure of the piston rings and cylinder walls. Misfire on Cylinder #2. Further testing revealed that Cylinder #2 is at 80 PSI, which is significantly below the manufacturer's specification. A subsequent leak-down test showed a 90% loss of pressure with air escaping through the oil filler hole. The issue stated above can cause severe mechanical failure of piston rings and cylinder walls can absolutely lead to connecting rod bearing problems by creating excessive debris, poor lubrication, abnormal piston motion, and increased stress, causing premature wear, overheating, and eventual bearing failure, often resulting in catastrophic engine knocking and damage. Diagnostics completed by Hyundai dealer and stated an engine replacement. Vehicle became difficult to steer and then warning lamp came on. Vehicle was difficult to turn left and right and almost caused a collision.

Filed Jan 13, 2026 · Engine · PA

On my 2019 Sante Fe 2.0T, I started having oil consumption/engine issues after 85, 000 miles. Under warranty, I had several minor repairs made over the last year (since 87,000 miles) at the dealership. In September 2025, at 97, 500 miles, I had it into the dealership complaining of burning oil and excessive consumptions in between oil changes. They AGAIN made a few minor repairs, I signed a one-owner warranty form since it was prior to 100,000, and they said come back if I experience further issues. On December 21, at 9pm at night, I broke down on the side of the PA turnpike. My engine light came on after my car started shaking vigorously, and wouldn't accelerate beyond 30mph. Being a Sunday night, I called the dealership in the morning- I was told no appointments for 3 weeks. Took it to a mechanic- where they diagnosed engine failure- hole in intake vale and floating valve not seated. Towed to dealership where it was INITIALLY diagnosed spark plugs and engine coil. Once a mentioned I had a prior diagnosis and pictures, Hyundai did bioscope- found burnt valve and now need all new intake values and part of the engine rebuilt. Hyundai wants me to pay for repairs. I don't think I should have to pay a dime- I've been complaining for over 15,000 miles BEFORE my warranty expired. And now, at 102, 000 miles, the engines blown?? This is a known manufacturer defect with the Theta II engines, and the pistons. I would expect Hyundai at the VERY LEAST to cover the cost of the repairs. Quite frankly, they should replace my engine with a new one, since replacing valves wont solve the pistons and burning excessive oil anyways. I have all documentation of repairs at the dealerships, email correspondence sent between the dealership's service advisors and myself, as well as my routine oil changes.

Filed Jan 4, 2026 · Engine · CA

After several oil changes and going from ever 5000 miles to every 3000 miles for oil changes to the need to add additional oil before hitting 3000 for being low on oil. Was told this vehicle just burned oil often and nothing really i was able to do. Check engine light turned on. Car stalled, shook and even turned off after being idle too long. Diagnostic found a leak in a cylinder and no combustion in engine. Out of warranty coverage. No warning lamps came on prior. Was on the freeway when light came on luckily was able to pull over safely. Seen many other cars with similar year, make model and engine had similar issues with oil consumption leading to the need of a full engine replacement. Further reading into issue showed several class actions and recalls to similar situation.

Filed Dec 13, 2025 · Engine · CA

Vehicle is consuming oil at an exceptionally fast rate. In October 2025, when taken in for an oil change and my complaint of a burning smell upon quick acceleration, the technician documented no oil was found on the dipstick. Just a month later, in November 2025, the oil level was already extremely low, the vehicle was taken back to the dealer, and an oil consumption test is currently being administered. The vehicle is scheduled for an engine replacement in January 2026 after the consumption test is concluded.

Filed Nov 25, 2025 · Brakes, Driver assistance · WA

Overly excessive oil consumption 2 Quarts every 3 or 4 days.no leaks. Engine gets so hot I don't have to turn on heater In winter. On going issue since 100,000 miles. EBS light stays on electronic parking brake switch does not work. Parking brake will randomly engage after vehicle is turned off. Dealership cannot duplicate issue. If cruse control is turned on the vehicles warning lights all of them will suddenly illuminate and the vehicle shuts off. alternator and battery replaced. Have not used cruse control since. Airbags never inflated in a front end crash at 45mph Most recently I started experiencing I intermittent trouble staring the car. Then one day it didn't start at all and smoke was coming from under the hood. Towed to mechanic , starter burnt up 155,000. $ 900 to replace then a couple days later I lost power on the freeway and the car started jerking and vibrating. Stopped Vehicle cut off and would not start. After 1hr I started and limped home. Vibration under 2000 RPMs and when stopped. Knocking noise under hood. Brand new spark plugs. Mechanic stated Cylinder 3;missfire was identified as a hole in a valve due to weak material now I have to replace engine. Oil consumption and excessive friction and heat is to blame. My car has been cared for like a baby it's all I have. I should not have to be responsible for this very cheaply made engine that was doomed to fail.

Filed Feb 5, 2025 · Engine, Transmission · 87,000 miles · OH

The contact owns a 2019 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle lost motive power while depressing the accelerator pedal, with the check engine warning light illuminated. The vehicle was taken to a dealer and the turbo was replaced. The contact stated that months later, the vehicle hesitated and jerked while depressing the accelerator pedal with the check engine warning light illuminated. The vehicle was taken back to the dealer where a part on the transmission was replaced; however, the failure returned, and the check engine warning light illuminated. The vehicle was taken back to the dealer and the contact was informed that the transmission needed to be replaced. The contact took the vehicle to an independent mechanic and had the transmission replaced. The contact stated that months later, the vehicle began to sputter with an abnormal knocking sound coming from the vehicle. The check engine warning light returned, and the vehicle was taken to the nearest dealer. The vehicle was diagnosed with engine failure. The vehicle was not repaired and remained with the dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 87,000.

Filed Jul 7, 2023 · Engine · AL

Engine Failure. Engine stalls during deceleration. If it doesn’t stall while braking, it immediately stalls around 5 mph when I come to a stop sign or red light. Vehicle start/stop button will not work to start the vehicle back up. It is to sit for 10-20 minutes and then it will start. If I don’t let it sit, it gives me a message on the dash that the vehicle is already on/running even though it is not. I have done regular maintenance and have had it serviced 4 times for the same issues. It has 126,000 on it. The dealership said it was the oxygen sensors and spark plugs. We had those fixed and the problem continued. The dealership is now wanting me to pay $11,000 for a used motor to be installed. Check engine light keeps repeating oxygen sensor malfunction. This has been happening since July of 2022.