2023 Hyundai Santa Fe fuel system problems

Filed Aug 10, 2026 · Fuel system, Transmission · NC

This complaint concerns a serious, unresolved powertrain/propulsion safety defect in my 2023 Hyundai Santa Fe. While traveling approximately 70 mph, the vehicle suddenly lost propulsion and would not accelerate normally while surrounded by highway traffic.MOST IMPORTANTLY, THERE WAS NO WARNING OR ADVANCE INDICATION. No warning lights, messages, or symptoms appeared before the loss of propulsion. I had no opportunity to anticipate the failure or prepare to safely exit traffic. This placed me and other motorists at immediate risk of a serious or potentially fatal collision.A Hyundai dealership inspected the vehicle and documented DTC P284001, Shift Fork D Position Fault. Despite this documented fault, the underlying safety issue remains unresolved. Hyundai has not identified a permanent correction or established that the vehicle is safe to operate.There has not been another incident because I will not risk another sudden loss of propulsion by driving the vehicle. The absence of another failure does NOT mean the problem is resolved. The vehicle remains available for inspection.I have repeatedly sought assistance from Hyundai and the dealership without a meaningful resolution. Newer information regarding a possible computer reset/relearn procedure has also been presented, but the dealership refuses to perform it.I reviewed the federal safety agency complaints for 2023 Santa Fe vehicles and found multiple reports describing similar safety symptoms, including sudden loss of propulsion, inability to accelerate, abnormal transmission shifting, and loss of speed. This raises serious concern that this may not be an isolated failure.A vehicle that can unexpectedly lose propulsion at highway speed WITHOUT ANY WARNING creates an extreme crash risk. I respectfully request that the federal safety agency review the similar complaints, investigate whether a broader transmission/powertrain safety defect exists, and determine whether corrective action is necessary before this results in serious injury or death.

Filed Jun 8, 2026 · Engine, Fuel system · 35,652 miles · VA

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving and decelerating to approximately 10 MPH onto an exit ramp, the vehicle suddenly stalled and failed to restart. The contact noticed that there was blue smoke coming from the exhaust pipes, and several unknown warning lights and messages illuminated, including the Check Engine warning light. The vehicle was towed to the local dealer, who diagnosed that a fuel injector had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not yet contacted. The failure mileage was 35,652.

Filed Mar 30, 2026 · Acceleration, Fuel system · NC

On March 4, 2026, at approximately 7:30 AM EST, while driving my 2023 Hyundai Santa Fe Limited on [XXX] , the vehicle experienced a sudden loss of propulsion while traveling at approximately 70 mph (posted speed limit). The vehicle would not accelerate or maintain speed and would not move forward when placed in drive, indicating a failure within the powertrain/transmission system. The vehicle is currently located at a Hyundai dealership and is available for inspection upon request. This incident created a significant safety risk, as I was traveling at highway speed in active traffic when the vehicle unexpectedly lost the ability to move under its own power. This placed me at risk of being rear-ended and made it difficult to safely maneuver out of traffic. The vehicle was inspected by a Hyundai dealership. Diagnostic trouble code P284001 (Shift Fork “D” Position) was identified, and I was informed the failure is transmission-related. The condition was reproduced by placing the vehicle in drive, at which point the vehicle would not move. The vehicle has been inspected by the dealership. The manufacturer has been notified but has not physically inspected the vehicle. No police or insurance inspection was involved. There were no warning lights, messages, or prior symptoms before the failure. The issue occurred suddenly without any indication of a problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 15, 2026 · Fuel system · TN

While driving on the interstate at 70mph the vehicle’s fuel injectors failed causing the vehicle to lose power suddenly.

Filed Jan 6, 2026 · Fuel system · FL

Fuel injectors are bad. The car misfires, I smell gas, runs rough. They fixed one the second week of December 2025. I had the same symptoms when my light came on again on December 23,2025, they said they couldn’t find anything and gave me the car back. On January 3, my engine light came on again, I had warnings sent to my email and phone app about potential engine failures they said today ( 1/6/26) that it was another fuel injector and was told they would not replace the rest until they went out. When I asked them how safe I would be on an upcoming trip, I was told to just check the car every day before I go!

Filed Aug 6, 2025 · Fuel system, Transmission · FL

From a complete stop when pressing the accelerator, the vehicle does nothing. This can last 1 second or in longer episodes it can last 4-5 seconds. No lights on the dash. It’s random and happens sporadically. But when it’s bad, you have enough lag to count to 5 and turn on the hazards

Filed Aug 5, 2025 · Acceleration, Fuel system · AZ

At 22000 miles wheel speed sensor went out, all control system shut down and car became unstable. At 44000 miles fuel injector went out, was driving on freeway and car started shaking and losing power, then in parking lot would not start at all, had to be towed to dealer. This is way to many breakdowns for a car with such low mileage.

Filed Feb 24, 2025 · Driver assistance, Fuel system · NY · crash · fire · 2 injuries

The accelerator stuck and the vehicle crashed. The vehicle is totaled. It happened [XXX]. No one has yet inspected the vehicle. I notified Hyundai about 5 days ago. The phone number of the towing company is 516 433 1011. The following link is a YouTube video of the accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 4, 2024 · Engine, Fuel system · GA

First- it has been reported to dealer at least twice when car was in for other service. They said they could not reproduce. When speeding back up from a stop on near stop, especially in a right turn, the engine will not accelerate. After a second or two it finally takes off. During this time, I fear getting hit by another vehicle, either from behind or to the side. It is very scary and puts me and my passengers at great risk! There was no warning indication at all. The date mentioned was the most recent time, but the issue has been happening since the car was brand new. Again, NO help from the dealer.

Filed Jul 6, 2024 · Engine, Fuel system · CO

There is an extreme amount of hesitation/delay from when you depress the accelerator and when the vehicle accelerates. I have had multiple incidences (both from a complete stop and while already moving) where I depress the accelerator and there is a concerning amount of lag time before the vehicle initiates movement. This has almost led to multiple accidents. This defect happens in all drive modes. This issue appears to have gotten worse over the time we have owned the vehicle. We did not notice this issue earlier on. We bought the vehicle brand new in Dec. 23.