My 2017 Hyundai Sonata Hybrid suffered a sudden and dangerous engine failure matching the exact conditions of the federal safety agency Safety Recall 209 (Hyundai Campaign 209) for premature connecting rod bearing wear. The vehicle entered Limp Mode due to diagnostic trouble code P1326. The mandatory Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the failure. The vehicle is currently located at Hyundai of [XXX], where dealership technicians confirmed that the engine is completely failed and requires replacement. However, the dealership and manufacturer are actively refusing to perform the mandatory safety recall remedy, instructing me to pick up the un-repaired, hazardous vehicle. They are citing the vehicle's salvage title as the sole reason for denial. Under federal the federal safety agency regulations, a manufacturer cannot deny a safety recall remedy based on a salvage or branded title status unless the vehicle cannot be physically or safely repaired. This engine defect poses a documented fire and stalling hazard. I am filing this immediate complaint because Hyundai is violating federal recall mandates by attempting to discharge a vehicle with an open, dangerous safety hazard without completing the legally required remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2017 Hyundai Sonata Hybrid engine problems
50 complaints (62% of all complaints for this car). Typical mileage when it fails: 80,000. 1 crash reported.
- owner complaints
- 50
- of this car's complaints
- 62%
- typical mileage
- 80,000
- crashes
- 1
- recalls
- 1
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
Hyundai Sonata Hybrid engine problems in other years
Specific symptoms reported on the 2017 Hyundai Sonata Hybrid engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Check engine light 20Knocking 15Loss of power 14Stalling 10Engine failure 8
Related recalls
Engine
- What is wrong
- Hyundai Motor America (Hyundai) is recalling certain 2017 Tucson and Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which can result in engine damage.
- Risk
- A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
- Remedy
- Dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. Owners were notified of the defect on November 16, 2021. Owner notification letters were mailed January 15, 2022. Owners may contact Hyundai customer service at 1‑855‑371‑9460. Hyundai's number for this recall is 209.
Recall number 21V727000 · Recall details
Related investigations
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V‑568, 17V‑226, 20V‑746, and 21V‑727; and Kia recalls 17V‑224, 19V‑120, 20V‑750, and 21V‑844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V‑877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines.  The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS.  It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to
EA21003
What 2017 Hyundai Sonata Hybrid owners say
Most recent owner complaints, unedited.
The contact owns a 2017 Hyundai Sonata. The contact stated that the vehicle experienced excessive oil consumption with an abnormal burning odor. The vehicle was taken to a dealer, and an oil consumption test was performed. The contact was informed that the vehicle passed the inspection. While driving later, the vehicle stalled and was taken back to the dealer, where it was determined that the vehicle was consuming an excessive amount of engine oil, and several DTC including the Knock Sensor Detection System (KSDS) were found. The contact stated that while driving or reversing at various speeds, the vehicle shuddered, made abnormal rattling sounds, entered HEV Lock Mode, and the vehicle stalled. The vehicle occasionally came to a complete stop in the middle of the road and had to be pushed out of the roadway. On other occasions, the driver was able to pull over to the side of the road. The vehicle failed to restart and was towed after stalling. The contact stated that the check engine warning light was illuminated before the vehicle entered HEV Lock Mode, with several unknown warning lights illuminated. The vehicle was towed to the dealer, where several tests, including bearing clearance tests and unknown repairs, were performed; however, the failure persisted. During the final service visit, the dealer diagnosed the vehicle with engine wear and tear and fractured pistons. The dealer determined that the engine needed to be replaced; however, the service manager informed the contact that there was no guarantee that replacing the engine or catalytic converter would resolve the failure due to severe engine damage. The vehicle was not repaired. The manufacturer was notified of the failure and offered loaner vehicle assistance on several occasions; however, coverage for the engine replacement was denied. The failure mileage was approximately 110,000.
The Hybrid Electric Vehicle (HEV) system in my 2017 Hyundai Sonata Hybrid Limited malfunctioned. On three separate occasions, the HEV warning light illuminated while I was driving on the highway, followed by a sudden loss of power. The vehicle stalled and stopped running, leaving it inoperable. The incidents occurred in approximately August 2022, November 2023, and February 2026. The vehicle is available for inspection upon request. Each incident occurred while driving on a highway. The vehicle suddenly lost power and stalled in moving traffic, creating a significant safety hazard. I was forced to attempt to move the vehicle out of active traffic lanes while other vehicles were traveling at highway speeds. The unexpected loss of propulsion increased the risk of a crash, serious injury, or death to myself, my passengers, and other motorists. The vehicle was taken to a Hyundai dealership after each incident. However, the dealership did not provide an explanation for the HEV warning light, loss of power, or stalling condition. To my knowledge, no permanent repair was identified, and the problem recurred on multiple occasions. The vehicle was inspected by a Hyundai dealership following each towing event. The vehicle was towed after each incident because it was not safe to drive. To my knowledge, Hyundai did not provide a definitive cause for the failures. The vehicle has not been inspected by police or insurance representatives in connection with
2/25/2026 vehicle was put in service for a safety warranty recall. 2/26/2026 Hyundai approved the replacement of the engine, but there were costs involved that I was responsible for (approx. $800). 3/9/2026 I was informed by Hyundai the vehicle was complete, and would now last "for another 200,000 miles". I picked up the vehicle and only drove 5+ miles from the dealership when the vehicle’s motor completely shut down, putting me in a VERY UNSAFE driving condition, almost causing a serious accident. Vehicle was returned to Hyundai the same day and I was informed they were still figuring out the failure and to be patient. 3/11/2026 Hyundai informed the vehicle would now need a new catalytic converter and O2 sensor, and that it would all be covered under warranty. On 3/12/2026 Hyundai informed me that they would not fully cover the cost of the new parts and I ended up paying another $1300. 3/19/2026 Hyundai notified me that the vehicle service was complete, and the vehicle was ready for pick-up. I picked up the vehicle that day and again only drove 5+ miles when the vehicle repeated the same failure with the motor completely shutting down and again putting me in a VERY UNSAFE driving condition and almost causing a serious accident. Vehicle returned to Hyundai the same day. 3/23/2026 was told I would receive update once technician gets to the vehicle. 3/26/2026 informed that the vehicles Brake Booster Actuator needed replaced, and I have to cover the almost $4000 to replace this part and later informed Dealerships GM was covering cost. 4/8/2026 vehicle being worked on and completed by the end of that day. 4/9/2026 vehicle failed a 3rd time with same codes and limp mode. Tech line stating to replace EGR valve and Intake Manifold. 4/13/2026 informed that Hyundai refused to pay total amount, but were going to re-submit to not be completely out of pocket. 4/15/2026 vehicle has now been in Service for 7 weeks for a Safety Warranty recall.
The engine shut off on the highway on two different days. Vehicle was going between 65 and 70 mph. The vehicle engine shut down and all the warning lights came on. Every one. The vehicle still moved but nothing inside worked, it ran on battery mode for the 17 miles to the dealership with a maximum speed of 60 mph. The risk was the immediate unresponsiveness of the vehicle and the sudden and immediate reduction in speed and power. It presented itself twice in about 2,000 miles. The dealership charged a 491$ diagnostic and found all the warnings and reset it, not reason for it happening and sent me on my way. Then it happened again. Brought back to the dealership and they tried to say they did another diagnostic and called the tech helpline. It took hours and they still don’t have a definitive answer, wanted to try almost 2k in repairs to see if it would fix the issue without any guarantees it would. Warning lights, all of them came on, cruise control, abs, engine light blinking, steering, literally everything and messages started running through the information center.
The contact owns a 2017 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, the contact noticed an abnormal ticking sound coming from the engine. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with engine failure due to the rod bearings failure. The dealer determined that the engine needed to be replaced and informed the contact that the repair was not covered under an unknown recall due to the mileage. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 183,000.
FAIL/MALFUNCTION 3/18/25: Internal engine failure diagnosed by local Avondale, AZ Hyundai dealership service - rod bearing failure suspected. Vehicle currently undergoing Bearing Clearance Test to affirm this or any connecting rod issues, with possible need for total engine replacement. When googling "Hyundai Sonata hybrid 2017 internal engine failure," masses of reports generate from consumers with this model, complaining of same defect, as do numerous recalls for such defects that have been mandated for the model with range of years including 2017.Yet when searching with my VIN, it says no recalls have been mandated, in spite of the undeniable, widespread identical defect. Available for inspection. SAFETY RISK: Driving on the freeway in city traffic at 70-75mph, the engine completely stopped and all dash lights lit up at once. Vehicle had to be coasted to shoulder to wait for roadside assistance. Extremely hazardous to us in vehicle and to all around us with sudden, dramatic speed change in moving, constant freeway traffic. First time: Our usual mechanics at Pep Boys did diagnostic but found nothing, the vehicle drove normally for them, yet they did our regular tune-up, oil change, etc. Two weeks later, the same event happened on freeway, identical to first time. We were very lucky that no crashes happened either time. Pep Boys advised that Hyundai investigate the issue. PRIOR SYMPTOMS: No warning lights or sounds presented until the events themselves, when the entire dash lit up. However, in the couple of months before, there were occasional, slight hesitation moments in the motion while driving at any speed. CONCERNS: 1) It seems Hyundai is on track to want to charge me for an entire engine replacement, or for whatever engine repairs they deem, e.g. connecting rods, for manufacturing defects that they are entirely responsible for, 2) no recall seems to be mandated YET for this VIN batch, and 3) too many consumers are in danger - physically and financially.
The contact's son owns a 2017 Hyundai Sonata Hybrid. The contact stated that while her son was driving at an undisclosed speed, he smelled a burning odor on the interior of the vehicle, after which he heard an abnormal sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to the dealer to be diagnosed; however, the contact was not aware of the diagnostic report. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 21V727000 (Engine); the VIN was included, and parts were available. The contact also stated that the vehicle had a Salvage Title. The manufacturer was not notified of the failure. The failure mileage was 66,000.
The vehicle had a recall to replace the motor for bearing failure. They replaced my motor at 101,000 miles. The second motor than failed for the exact recall of bearing failure at 65,000 miles on the new motor. They told me that since I had already have done the recall and my car was now out of warranty that I would have to pay 10% of the repair bill for another motor. This second motor should have been included in that recall.
Engine oil misfire also noted as a recall on the 2016 model and repeatedly mentioned on line as an error in the 2017 model now reaching simlar mileages. Dealer is refusing to acknowledge it as a problem and says the engine light si not recording the error and yet an outside analysis says its error 0302!! The same as the 2016 recall notice. The 2017's should be recalled for the same fix
Questions about the 2017 Hyundai Sonata Hybrid engine
Does the 2017 Hyundai Sonata Hybrid have engine problems?
Owners have filed 50 complaints about the engine of the 2017 Hyundai Sonata Hybrid, 62% of all its complaints, more than any other problem.
At what mileage do 2017 Hyundai Sonata Hybrid engine problems start?
The typical (median) mileage in owner complaints is 80,000 miles.
Was there a recall on the 2017 Hyundai Sonata Hybrid engine?
Yes, 1 recall: 21V727000. Check your VIN to see if your car still needs the free repair.
What year does the Hyundai Sonata Hybrid have bad engine?
The Hyundai Sonata Hybrid model years with the most engine complaints are 2016 (76 complaints), 2012 (71 complaints) and 2017 (50 complaints).
Other 2017 Hyundai Sonata Hybrid problems
Electrical 18Transmission 10Fuel system 8Steering 8Brakes 5Acceleration 3Driver assistance 3Lights 3Locks 2Airbags 1Body 1Seat belts 1Visibility 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Hyundai Sonata Hybrid?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history