2011 Hyundai Sonata fuel system problems

Filed Jul 21, 2026 · Airbags, Fuel system · CA

I purchased fgis car from a used car dealership, for over $6,000.00 , which is not a ton of money, but plenty enough to not have instant issues. Since my purchase in june 30, 2026, i have already had all of these issues occur. There is white smoke coming from the left tail pipe, it is sluggish when you push on the gas, there is black soot constantly on my rims that is extreamly hard to remove, the high pressure fuel pump jas failed, I can tell because the oil is higher then it was when o had the oil freshly changed, and it smells of gasoline.inside the oil. The exhaust has stron smell of gasoline. My steering wheel has a loud clinking noise everytime I go over a speed bump on pull into my driveway. Just so many items consistently needing repair or replacement, even though I just had the fuel system cleaned, the oil changed, and filters, and.oil filter too. I checked to see if any of my issues are covered by a recall warranty, because they all are recalled items for my car year, make, and model, but apparently Hyunfai is only covering these dangerous recall items for ul to 10 years. These items shkuld be covered longer, because my carfax states that at least one of these recalled items had already been changed in 2018, and is already broken again!! Hyundai should have covered these extreamly high wear out car parts for a longer period of time, or for the life of the vehicle, if every 5 years your replacing a $1000.00 part, not including labor, like the (HPFP) I was quoted by auto zone for over that price point!! "Ridiculous"! Another item is the air bag cover on the driver side windows area, of the body frame it is loose and keeps un-clipping, i am afraid that it is going to possibly just go off and kill me or something!! Very disappointed right now, that i cannot get any of these recalled items replaced by the manufacturer!!

Filed Apr 8, 2026 · Electrical, Fuel system · 167,000 miles · NC

The contact owns a 2011 Hyundai Sonata. The contact stated that the vehicle stalled while driving at various speeds on four occasions. During the first occasion, the vehicle was towed to the residence. The vehicle was then towed to an independent mechanic, where it was diagnosed, and it was determined that the low-pressure fuel pump needed to be replaced. The vehicle was repaired, but approximately a year later, the failure recurred. The vehicle was then towed to an independent mechanic, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired, and the contact was advised to contact a dealer for assistance. The vehicle was then towed to a dealer, where it was diagnosed and it was determined that the high-pressure fuel pump and electrical wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 167,000.

Filed Jan 8, 2026 · Fuel system · FL

The contact owns a 2011 Hyundai Sonata. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended, and the contact noticed a strong fuel odor coming from underneath the hood. Upon inspecting underneath the hood, the contact noticed a leak. An independent mechanic diagnosed the vehicle and determined that the fuel line was leaking. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was contacted, but only the automated system was available. The failure mileage was unknown.

Filed Oct 2, 2025 · Engine, Fuel system · MD

The affected component is the engine/rod bearing (Theta II 2.4L). My 2011 Hyundai Sonata stalled and the engine locked up twice in live traffic (March 2025 and July 2025). The vehicle is available for inspection if needed. This created a serious safety risk to me and others on the road, as the stall occurred on [XXX] at highway speeds. This failure could have been catastrophic had it happened on the DC/Baltimore Beltway or another high-traffic roadway. Hyundai’s system shows Recall 132 was marked complete at very low mileage (around 32,000 miles), but my vehicle later developed oil consumption and stalling consistent with rod bearing failure. Capitol Heights Hyundai noted a warranty pre-authorization (PA) in March 2025 and told me Hyundai needed my mailing address “for the claim,” but later said it was a typo and that no record exists. The dealership charged me for a diagnostic but did not inspect the vehicle for rod bearing failure, despite symptoms consistent with Recall 132. Annapolis Hyundai, where the car was purchased as a CPO, has admitted they have no documentation that Recall 132 was ever performed (no repair order, mileage, or technician notes). Yet Hyundai’s system shows Recall 132 marked “complete.” Without proof that the KSDS software or bearing inspection was done, I belive this recall should be considered open. Hyundai Consumer Affairs has stated that I must pay for towing and diagnosis before they will investigate, with possible reimbursement later. This conflicts with federal law (49 U.S.C. § 30120), which requires recall diagnosis and repair at no cost to the consumer. Prior to the failures, my vehicle had a history of oil consumption and “no oil on dipstick” findings, which are known precursors to rod bearing failure. No warning lamps appeared before the stalls. I am requesting the federal safety agency’s assistance in requiring Hyundai to provide documentation or reopen Recall 132 and perform a no-cost inspection/repair to ensure this vehicle is safe to operate INFORMATION REDACTED PURSUANT TO THE FREEDOM OF

Filed Sep 17, 2025 · Fuel system · CA

1. The car began to randomly stall and stop running. This happened while driving and it was extremely dangerous. Typically, the engine would restart after at least waiting 15 minutes. Any attempt to start the car before that time would fail. 2. When the stalls happened, the car acted as if it had run out of gas. The engine would simply stop running WITHOUT WARNING, at intersections, on city streets, and on the freeway at high speed. It did not matter how full the gas tank was. 3. My brother and I diagnosed the problem as intermittent loss of fuel pressure. 4. My brother and I replaced the FACTORY fuel pump, and to hour horror, when we unplugged the electrical connection/plug, one of the pins from the fuel pump came out with the plug/connector. 5. We inspected the fuel pump and discovered that parts of the electrical plug INSIDE THE FUEL TANK had become burned and melted. See Image SANY0135.JPG === This is a SAFETY DEFECT - either the internal fuel pump electrical connections were faulty from the factory or the problem developed over time. There have been other recalls for this model of car for random engine stalls but this is a NEW and DIFFERENT cause. A dealer with a relatively inexpensive Infrared camera could likely spot this problem with minimal vehicle disassembly. There was clearly a LOT of heat concentrated in the area of the electrical connection to the fuel pump. We hope this report triggers a recall and prevents extremely dangerous random loss of engine power events, fires, or worse. Please recall all the vehicles that used that fuel pump for inspection before there is a disaster.

Filed Apr 18, 2025 · Engine, Fuel system · MN

I had bought this car off Facebook marketplace after confirming with my dad that it was a good car, when I had finally saved enough. After I took it home the check engine light had come on not too long after, the engine stalls when turning the key, pressing on the brake helps start the engine. Turns out the car was a salvage title and my dad didn’t know that and I didn’t know what that was.

Filed Dec 7, 2024 · Fuel system · WA

I tried pumping gas and the car would not let me pump the gas into the car. I had to hold the the gas pump hose and pull the trigger myself to pump the gas, which would still make the clicking stop noise that stops the pumping of the gas. Then when I started driving, the check engine light came on. Went O'Reilly to test the check engine light code and it popped up with a P0449 code for the evaporative emissions (EVAP) vent control valve.

Filed Nov 14, 2024 · Engine, Fuel system · UT

My car will randomly shut off while I’m driving. My seatbelt comes undone My door has opened while I was driving down the highway.

Filed Sep 19, 2024 · Electrical, Engine · NV · fire

Car spontaneously caught fire while turned on. First smoke started coming from under the hood. Within three - five minutes, the car erupted in flames followed by a minor explosion that burned more than half of the car causing a total loss.

Filed Mar 25, 2024 · Engine, Fuel system · 150,000 miles · OK

The contact owns a 2011 Hyundai Sonata. The contact was informed of the federal safety agency Campaign Number: 15V568000 (Engine), and the vehicle was taken to the dealer for the recall repair; however, the dealer informed the contact that the knock sensor detection system (KSDS) software update and the recall repair had already been performed on the vehicle. The contact stated that a failure related to the recall recurred while driving. The contact stated while driving approximately 60 MPH, the vehicle stalled. No warning light was illuminated. The contact was able to get the vehicle to the shoulder of the highway. The vehicle was towed to the residence, where the contact was able to drive the vehicle again; however, the failure recurred several times. The vehicle was taken to the dealer, where it was diagnosed with a fuel pump failure, and an oil leak. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 150,000.