2020 Hyundai Sonata body problems

Filed Oct 16, 2026 · Body · FL

Upon arriving home I noticed that the paint was missing from the back passenger side & when I left the parking lot before heading home there was no paint missing.

Filed Jul 30, 2026 · Body, Fuel system · FL

Car was taken to dealership for inspection. Upon inspection, it was determined that the fuel tank had expanded and pushed towards the heat shield, and expanded upward pushing up the back seats of vehicle. It was determined to not safe to drive. Manufacturer contacted me and offered a buyback. Upon their offer of a buyback, it was determined that I would owe the manufacturer approximately $2,000. I have requested that they fix it, and they have refused to give me the paperwork I requested about the car's condition and fixability. I am in the process of negotiating and am filing this complaint for the record.

Filed Jun 22, 2026 · Body, Fuel system · 89,000 miles · AZ

The contact owns a 2020 Hyundai Sonata. The contact stated that while driving at an undisclosed speed with the family inside the vehicle, a strong gasoline odor was inside the cabin of the vehicle. The contact stated that the fuel gauge was lowering quickly. Upon exiting the vehicle, the contact became aware of gasoline gushing heavily out of the vehicle onto the ground. Two months prior to the failure, the vehicle was taken to an authorized dealer due to an abnormal sound coming from the rear of the vehicle. The contact received notification of the federal safety agency Campaign Number: 25V796000 (Fuel System, Gasoline); however, the recall repair was not performed because the part for the recall repair was not yet available. The vehicle was towed to a dealer where it was determined that the gas valve was not properly fixed. The abnormal sound in the rear of the vehicle was due to the fuel expansion, which caused the tank to rupture and melt. The melting caused the fuel pump to expand and melt, causing structural damage to the body of the vehicle. The structural expansion caused the rear passenger seats to raise up. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 89,000.

Filed Feb 16, 2026 · Body · NY

White pain is pealing off and it’s pretty bad especially when going through car wash

Filed Dec 19, 2025 · Body · CA

I own a 2020 Hyundai Sonata with factory-applied paint. The vehicle developed paint peeling/clear-coat failure on the driver-side rear quarter panel without any prior damage, accident, or repainting. The paint began separating from the body, exposing the underlying surface. I brought the vehicle to an authorized Hyundai dealer. The dealer acknowledged a paint adhesion failure and submitted the issue to Hyundai. Hyundai declined to fully cover the repair, stating the model year was not included in their paint warranty extension, even though similar peeling paint defects have been acknowledged and covered by Hyundai on earlier Sonata model years. The dealer ultimately repainted both rear panels due to the nature of the failure, but Hyundai required me to pay approximately 20% of the repair cost as a goodwill arrangement. I was not offered a full repaint or full reimbursement. I have also observed early signs of potential paint adhesion issues around the rear window frame, raising concern that the defect may progress to other areas of the vehicle. This appears to be a manufacturing paint adhesion defect rather than normal wear, and similar issues have been widely reported on Hyundai vehicles. I am reporting this issue to document a recurring paint adhesion defect on the 2020 Hyundai Sonata and to assist in identifying a potential pattern affecting additional vehicles.

Filed Sep 3, 2025 · Body, Fuel system · NJ

In early May 2025 while driving around 40mph, I heard a very loud pop which startled me. Pulled over and looked back and noticed my backseats were push up out of place. I attempted to put the seat back into place but it wouldn’t fit into the latch anymore. The framing underneath the seats looked pretty damaged so I took it to a local mechanic. After doing some research, he found information for a check valve/fuel tank recall (Service Campaign 9B1) and then advised me to go a Hyundai dealership. I attempted to take it to the dealership, whom sent me away after I advised them of what happened. I came back the next day asking them to take a look at while informing them about the recall that could be related. Later that evening, they called and said the issue was directly related to the recall and the repairs would be covered. My car was in their possession for from 5.12.25 to 7.25.25 without any updates or instructions on what is happening. I was told they’re waiting to hear back from Hyundai Manufacturer on how to proceed. They returned my car to me on 7.25.25 stating everything was repaired. On 7.31.25 they called me back stating my tank needs to be replaced and bring the car back asap. My car was again being repaired and was returned to me on 8.25.25. Now my vehicle will not start randomly sometimes. At this point, I’m under the impression my vehicle is no longer safe as all the issues I’ve been facing are fuel related.

Filed Mar 28, 2025 · Body, Fuel system · CA

Service Campaign 9B1 That my gas tank has explanded/exploded due to the issue noted in the subject line. As you can see the whole bottom of the backseats have been raised up imcluding the part that connects to the gas tank itself. My car is immobilized and not drivable during this time. What is the next step to take?

Filed Mar 8, 2025 · Body, Fuel system · VA

I took my car in for a standard oil change and tune up. They found out that the fuel tank had expanded to the point where it caused significant damage to the metal frame. The Hyundai dealership sent it to the local body shop for an estimate for the frame, they sent it back because the dealership hadn't removed the gas tank, then the dealership sent it back to the body shop. It's been 3+ weeks, my car is still in the shop, and I haven't received any indication of whether my car is able to be fixed. The dashboard never displayed any warning messages and there were no symptoms of the problem. I had no idea the gas tank had expanded and could've caused an explosion or fire.

Filed Aug 21, 2024 · Body · 47,000 miles · FL

The contact owns a 2020 Hyundai Sonata. The contact stated that upon exiting the vehicle during a rainstorm, she became aware that water had filled the interior of the rear driver's side door panel, which began to leak when the door was open. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine how the water was entering the door panel. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 47,000.

Filed Jun 27, 2024 · Body, Fuel system · LA

I was on my way back home from Alexandria LA on [XXX] when I heard like the sound of an blow out tire but wasn’t happen to look in back of car and seen back seat was blown off the area of the car and proceeded to see that the gas tank was expanded like you would see a balloon and the me car started running funny and. Then a service code comes across the screen of the radio po45100 , so I pull over and look beneath the car and see that the gas tank is so expanded it’s now pressing against the exhaust pipe. So I turned car off and here we are now I’m without a car due to this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)