2017 Hyundai Tucson fuel system problems

Filed Nov 4, 2026 · Engine, Fuel system · FL

While driving down the highway, the check engine light started to flash. Once the car was turned off and back on again, it shook violently. It was hard to keep it in the lane and I was worried it would cause an accident. It was driven off the highway while constantly shaking. Once it sat off for roughly 30 minutes, it would turn on, but wouldn't turn over and drive. It was towed to a dealership where it was diagnosed, though I was never given anything past a verbal "it stopped compressing". It turns on and over, but makes a grinding noise. It will die and turn off the engine after roughly 45 minutes. This had never happened before. *I've been told a few different things by people who hear about the problem, but I've never received a real diagnosis by the Hyundai dealership it is located at. It has always had a oil consumption problem, adding roughly one quart of oil every 800-1000 miles. It has had oil changes every 5,000 miles. It also had a hard time when cold-started accelerating, but would work fine once heated up. It is available for inspection upon request.

Filed Oct 30, 2026 · Fuel system, Steering · CA

The issues is the engine shuts off at idle or in motion. Sometimes hard to start but it cranks over well. Then when it restarts after a shut down, three lights stay on some traction control, the steering and a picture of a car downhill with a clock or engine RPM light. No check engine light on. Then recently the tachometer doesn’t work after a shutdown then restart. But when you turn off the engine with ignition, then restart the third time. The lights all go off then the RPM gauge works. But the whole time the engine runs great. When I check ECM all is good no Fault codes, I monitor fuel pressure the low psi is 40 the high side is 999 psi. Is this a common issue with these cars?

Filed Jul 19, 2026 · Engine, Fuel system · CO

The Core Symptoms: "The high-pressure fuel pump is leaking internally. Raw gasoline is flooding into the engine oil crankcase, causing severe fuel dilution. The engine air filter is physically soaked in raw fuel and smells strongly of gasoline." My engine is always extremely hot after I have only went 15 mins away from home. Sometimes takes over two hours to cool down. The Safety Risk: "When attempting to accelerate, the vehicle experiences severe fuel starvation, causing the engine to bog down and act like it is going to stall in the middle of traffic, creating a severe crash hazard. Additionally, there is a loud 'popping' sound/mini-backfire upon turning the vehicle off due to unburnt fuel vapors, presenting a high risk of an underhood engine fire. I have only 83,000 miles on my car.

Filed Jun 25, 2026 · Engine, Fuel system · IN

#1. This vehicle uses a lot of oil !!! It burns through it like crazy I have to check the oil every other day. #2. When I come to a stop while driving and give it gas to take off IT WONT GO !!!!! It hesitates and when it does go it LUNGES FORWARD!! This is a huge manufacturer problem not a buyer problem. The engine is junk.! 3. I’ve called numerous places to get help. This car needs to be recalled. This is a huge safety violation. It doesn’t wanna go when you give it gas and when it does, it lunges forward that can cause a huge accident on the highways. This car was made in China. It is junk. I’ve called to get help with this issue and no one wants to help. Nobody returns my calls and I’ll Hyundai wants to do is it even more money out of me when this isn’t my fault the car is junk. For safety concerns I would like someone to call me at [XXX]. This car needs to be recalled and my daughter has one. It’s doing the same thing except hers is a lot worse. Hers is further advance where it’s actually stalling in the middle of the road while driving huge safety violation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 4, 2026 · Acceleration, Engine · GA

My 2017 Hyundai Tucson is experiencing dangerous, sudden engine stalling, which are symptoms directly matching Service Campaign T1B. These critical safety issues surfaced following a total engine replacement in June 2025. Despite the vehicle being within the 12-month/12,000 mile workmanship warranty, the dealership is refusing to honor this coverage or offer goodwill assistance. My claim is based on a documented pattern of physical and technical negligence: - Failure to Update Software: The dealership failed to perform the mandatory ECM/TCM software integration (Campaign T1B) during engine swap, which is required to prevent the exact stalling I am now experiencing. - Dismissal of Warning Lights (Code P0456): One day after the engine replacement was “completed,” I returned to the dealership because the Check Engine Light illuminated with Code P0456. This was dismissed by the service provider without a proper diagnostic resolution, despite being a direct indicator of improper vacuum line reconnection during the engine installation. - Mechanical Negligence (Coolant Leak): Post-engine swap, the vehicle developed a coolant leak, which was a direct result of improper reassembly. Additional proof of the lack of due diligence during the repair. The lack of follow-through, combined with the dismissal of a life-safety defect and poor physical workmanship, suggests a total failure in the case management process. I am urgently requesting assistance to resolve this hazardous situation.

Filed Mar 30, 2026 · Engine, Fuel system · 68,000 miles · NC

The contact owns a 2017 Hyundai Tucson. The contact stated that the vehicle was consuming an excessive amount of engine oil. There was an abnormal knocking sound coming from the vehicle. There was no warning light illuminated. Due to the failure, the vehicle was towed to a dealer, and the excessive oil consumption was confirmed. The contact was informed that the vehicle was included in the federal safety agency Campaign Number: 21V727000 (Engine), and the engine was replaced. The vehicle was repaired, and a family member retrieved the vehicle and drove it to the residence without failure. Several days later, the family member started the vehicle, and fuel started pouring out from underneath the vehicle. Due to the failure, the vehicle was towed back to the dealer and was diagnosed the vehicle with an O-ring failure inside the fuel injectors. The dealer repaired the O-ring, and the contact picked up the vehicle from the dealer. Soon after retrieving the vehicle, fuel started pouring out from under the vehicle at start-up. The vehicle was towed back to the dealer and remained with the dealer. The manufacturer was notified of the failure, and a claim was filed. The vehicle was not repaired. The failure mileage was approximately 68,000.

Filed Mar 18, 2026 · Engine, Fuel system · GA

This car has major oil consumption that affects the engine and catalytic converter. This can cause engine damage and stalls in driving that affect safety on the roads because the car doesn't accelerate properly. There were no warning signals to indicate this being a problem with the car, especially at purchase. This car will get an oil change and in less than a week, the oil is gone and bone dry.

Filed Mar 7, 2026 · Engine, Fuel system · SC

While driving on the interstate at highway speed, my 2017 Hyundai Tucson lost power without any warning lights or prior symptoms. The vehicle experienced an immediate loss of propulsion while I was traveling in traffic, creating a dangerous situation because surrounding vehicles were also moving at highway speed & I had to quicky maneuver the vehicle to the shoulder with no power. The vehicle had approximately 73,861 miles at the time of the failure. After the incident, the vehicle was taken to a Hyundai dealership and diagnosed with a burned exhaust valve requiring replacement of the cylinder head & valve. The estimated cost of repair provided by the dealership was approximately 7550. The vehicle had no prior warning lights or symptoms before the sudden loss of power. A sudden engine failure resulting in loss of propulsion at highway speed presents a serious safety risk to both the driver and surrounding traffic. This was an extremely dangerous failure.

Filed Feb 6, 2026 · Engine, Fuel system · IN

Car engine seized and lost ALL power going 60mph down the highway at night with my child in the back seat. I have poured quarts and quarts of oil in this vehicle because it burns oil at an alarming rate until it eventually runs dry and the engine seizes. This is extremely dangerous and luckily my child and I were able to drift to the side of the road without harm and injury. Very discouraging that there are thousands of these cars and engines on the road that can literally seize up at any minute. Maintenance was performed and kept up with. The Oil pressure light had been flashing when the vehicle turned but was flashing even when oil had just been changed. These engines are dangerous and have people in a financial hard spot. I still owe $16k on a car I can no longer drive and that Hyundai is saying due to owner maintenance will not get an engine replacement. The Facebook group Hyundai Oil Consumption test has thousands of people dealing with the same exact issue on these cars and engines.

Filed Nov 11, 2025 · Engine, Fuel system · IN

I know there is a re-call for my vehicles engine and year with model. I am having serious issues with my vehicle related to the recalls for the same year and model. I feel unsafe driving my vehicle and now I do not know what to do.