2022 to hyundai tuscon now with the third cylinder misfire due to faulty fuel injector. This can be inspected upon request. Upon second occurrence, requested all cylinders be replaced and advised could not do this under warranty. Second filing to the federal safety agency. This incident put myself and other drivers at risk. I was driving on a highway and the cylinder misfire occurred resulting in check engine light and vehicle going into limp mode and inability to drive more than 30-40 mph. The entire vehicle violently shakes and loses power with this misfire. In the previous occurrences , could not accelerate beyond 20 mph. I could have been rear ended or caused a serious accident on the highway as a result of Hyundai faulty fuel injectors and cylinder misfires. My vehicle has now been seen 3x for the same issue and replaced by dealer. There were no warning signs prior to the failure of the fuel injector resulting in cylinder misfire and loss of power and inability to accelerate. This is a very dangerous faulty component of this year make and model- it is a known issue. Still no recall. I have a "new" car that puts me in danger every 4-6 months when I lose power in my vehicle with no warning or cause except from faulty parts. This faulty part is going to cause serious injuries/accidents if it is not addressed.
2022 Hyundai Tucson engine complaints
Page 3 of 5: complaints 41 to 70 of 116, newest first, as owners wrote them.
Within the first year of purchase, my power train system has beeb throwing codes. I took it to the dealership where they assured me nothing was wrong. My fuel injectors then gave out. The dealership replaced them and told me “yes these things are faulty and we see it a lot”. After replacing it, they did not seal the fuel injectors, causing gas to gush out and set my car to smoke. I was ill from inhaling gas fumes for days. They took accountability and said that the injectors were defective in the vehicles and that they would once again fix it. I am not experiencing further engine issues which they do not know how to diagnose. My car is a 2022 purchase from the lot. The engine is defective and Hyundai is negligent. They admitted they were aware of the injector issue but didn’t do much to correct this. After corrected, they almost had my car set on fire from fuel pouring on the engine.
While on a trip my wife started out leaving the hotel as normal. After a minute of so, we lost the ability to accelerate as if the Tuscon was not responding to the gas pedal. We were lucky we were in town so we pulled into a gas station and turned off the truck. I thought it might be bad gas so we filled the tank with hi-test and turned off several features that are related to speed control (like tracking the speed limit etc.) I have noticed at the same time we lost the ISG system (Idle stop and Go). The indication in the owner's manual points to a battery function that detects the battery is fully charged. I used a voltmeter and the battery reads 12.5v and is charging at 14v. See today's recall for Hyundai vehicles, I think the problem involves a lot more vehicles. If you check the Hyundai forum, there are a lot of complaints on Tucson as well. I hope you take this into consideration when looking into this intergrated charging control issue.
The contact owns a 2022 Hyundai Tucson. The contact stated while driving at various speeds, the vehicle intermittently went into LIMP Mode with several unknown messages displayed on the instrument panel. The contact stated that the failure occurred for approximately 15-20 seconds before the vehicle resumed normal operation. The vehicle was taken to the dealer, but the failure could not be duplicated. The vehicle was not diagnosed. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 32,000.
The vehicle experienced a malfunction in the ignition or fuel delivery system, specifically a misfire detected in cylinder 2 (DTC P030200). This component has been documented by the manufacturer’s vehicle service center as an issue and may be available for inspection upon request. The misfire caused reduced engine power and hesitation during acceleration, posing a safety risk, particularly while merging onto highways or attempting to pass other vehicles. The issue has been reviewed and addressed by the manufacturer dealer service center twice (presently going in for a third time); however, the problem returned each time after a few weeks, with less than approximately 5,000 additional miles driven. The vehicle has not been inspected by police, insurance representatives, or other parties. The "Check Engine" warning lamp illuminated when the failure occurred, accompanied by symptoms of rough idling and reduced performance.
Check engine light and error message popped up on screen "A possible condition with your Engine Control System has been detected. A full system check is recommended to be done when convenient. Please contact your local dealership to schedule an appointment." Roughly 46500 miles. Contacted BlueLink and they could not help because dealerships were already closed.
While driving the car the engine died, locking up both the gas and brake pedals. The car had to come to a stop on its own, my wife could not depress the gas or brake to stop the car. She was going through an intersection and narrowly avoided a major accident! The battery light came on, the check engine light and the car started to fill up with a smell of burning plastic and gas. When trying to turn the car back on after turning it off it would start with a major shake and bang then turn back off. All warning lights stayed on. Battery was fully charged still. Autobody shop found engine issues in their pre scan before sending it to Hyundai to warranty it as it only has 6,626 miles and is 2 years old. There was a warning of low battery while we were on vacation and the car was sitting for a few days. And a sluggish start when it sat for few days like the battery was low, but it wasn’t based on the volt meter.
I had 2 fuel injectors fail on my car within a 3 week period. The car is only 2.5 yrs old and has 48,500mi on it Both instances where when I was on a highway. I had the 1st fuel injector fail on [XXX] and then the 2nd one failed about 3 weeks later on [XXX]. When the 2nd fuel injector failed, I was barely able to drive the car to a safe place to get it towed. I spoke with a Hyundai Corp case worker and I asked why they didn't just replace the remaining 2 fuel injectors. Her response was that they don't replace them when they fail. I now have a 2 year old car that I am afraid to drive because I never know where or when It will leave me stranded. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle suddenly unable to accelerate. Engine shuddered & produced a burning smell until we could safely pull over. Towed to dealership where diagnostics showed faulty fuel injector & they replaced 1 GDI fuel injector per TSB 23-FL-002H-1.
I had my gps on and it completely stopped working sending me in circles and the voice directing completely stopped. Very dangerous it had me making U-turns at dangerous intersections. I stopped several times put address in again. This has happened several times and it is very dangerous. Also this address is a known gps address not some obscure destination ´ Next twice I have pushed the start button with my foot on the brake and the car would not start. Third try it started.
Car lost power as I was entering fast traffic area. Acceleration became unresponsive and vehicle came to halt. Would not move there after. Had it occurred a few seconds later I would’ve found myself unable to accelerate in an acceleration lane, or shortly after merging potentially causing injury to myself and others. After getting the issue diagnosed by Hyundai it is apparently a faulty fuel injectors. Researching online, this appears to be a known problem for the 2022 Hyundai Tucson with many claiming they were left stranded on highways, at intersections and during snow fall. In general this issue makes owners fearful to drive their cars. Apparently, this may be caused by a bad batch of injectors but to my knowledge Hyundai only replaces known bad injectors instead of replacing all injectors from the faulty batch. Due to this many experience multiple failures in short periods in short periods of time, increasing risk of safety incidents. My vehicle’s failed at approximately 22k miles but others have reported failures much sooner.
2022 Hyundai Tucson with repeated check engine light and vehicle losing power. Vehicle losing power and inability to exceed speeds of 15 mph with vehicle shaking, knocking, and pedals shaking. No warning that this was going to occur until vehicle becomes unsafe to drive. This has happened twice and one of which was on a high way which created an incredibly unsafe situation. First time diagnostic code was P0303 which was a cylinder 3 misfire and second time - less than 4 months later- diagnostic code was a P0302 cylinder 2 misfire. Hyundai only repairs one injector at a time; refusing to do all 4 despite being a heavily documented issue on this make/model. This would be able to be confirmed by request. This was also confirmed both times by two separate independent service centers. Vehicle has about 25,000 miles on it and has had 3 check engine lights over the past 3 years of owning- it was bought new. The first time was 2 days of owning and it was a bad IAT that resulted in engine stalling once again. All 3 times the car was unable to be driven and created substantial safety concerns with inability to drive.
The contact owns a 2022 Hyundai Tucson. The contact stated that while his daughter was driving approximately 65 MPH, the check engine warning light illuminated and the vehicle began to vibrate, lose motive power, and then stalled. The vehicle was towed to the local dealer who diagnosed that cylinder #4 fuel injector had failed. The fuel injector was replaced; however, the same failure occurred with fuel injector #3. The vehicle was not yet repaired. The manufacturer was not yet contacted. The failure mileage was 34,219.
On 5/27/24, my check engine light came on and the vehicle stayed to shimmy and shake each time I would press on the gas. Had the vehicle towed to the dealer for the #4 fuel injector assembly to be replaced. The same thing happened on 7/16/24 while traveling out of state. I was traveling on a highway and had to keep my emergency flashers on as I tried to coax the car to the next exit. Couldn't go above 25-30 mph. Had vehicle towed to a dealer for the #2 fuel injector assembly to be replaced. Now I am again without a vehicle because on 7/26/24, the same thing happened and I was told it is the #1 fuel injector. I was told by 2 different dealers that this is a known Hyundai Tucson issue but they are only allowed to replace what is coming up with an error code. They are not permitted to change all of the assemblies at one time, even though it would save them and Hyundai Corporate quite a bit of money in the long term. They've now paid to tow my car 3 times, paid workers 3 times the amount of money to replace what could've and should've been done the first time. The dealer was going to try to get the #3 assembly replaced now but there is no guarantee. I'm afraid that I'll have to be back there in another week or two for the last one. This is a serious issue that is not being addressed.
14202 miles on this car with regular oil changes by dealership. Engine is KNOCKING and needs a whole new engine. No warning, no lights, no codes. Is not able to be driven. Had my whole family in the car
I was merging on the highway when the car bucked and the check engine light came on. I couldn’t drive over 20 mph without the car shaking. I pulled over and had the car towed. The issue was a faulty fuel injector. It was replaced under warranty. I am worried reading online about this problem happening again. My family has owned 4 Hyundais and I’m starting to loose faith in their reliability. This really needs to be recalled.
Fuel injector went out in the middle of highway and vehicle had to be towed after vehicle starting shaking and couldn't drive above 25 miles per hour. This is a known issue by Hyundai in 2022 Hyundai Tucson.
Fuel injector failure on 02/2024. Fuel injector failure on 06/2024. Both times car lost power and started shaking. Hyundai service center will only replace one at a time. Car only has 28k miles.
Fuel injector failure on 02/2024. Fuel injector failure on 06/2024. Both times car lost power and started shaking. Hyundai service center will only replace one at a time. Car only has 28k miles.
We fist noticed a problem with the car having a hard time accelerating and a hard shift at 25-35 mph back at the end of November. We then got a check engine light that came on that said P013A00 Powertrain. We brought it to the dealership the first week of December and were told that the transmission just needed an update. Upon taking the car home it was better for about a week then the issue came back sporadically. Then on March 20th my wife was driving the car and it would not accelerate past 35 mph while getting onto the interstate. Cars were going by her at 70+MPH as she sat there helplessly pressing the accelerator. Eventually she got the car up to 50 mph but it would not go any faster. We brought it into the dealership that day and once again they said the transmission needed an update. I then contacted Hyundai corporate and submitted a complaint and they started a case for the issue. After the second time at the dealership the car was ok for a week and then started with the same issues. After taking it to several other dealerships they all tell me that it’s a transmission issue that they don’t know how to fix but they change what they say once Hyundai corporate talks with them. Presently the car will have very high RPM and jump forward almost colliding with cars in front. It will also not accelerate such as the peddle is on the floor and the RPMs are high but the car will barely move until it shifts gears and jumps forward.
Ignition coil failure while driving. Loss of power, jerking performance, almost to point of stalling. No check engine lights until failure. Confirmed with scanner what computer was registering. I’ve seen other posts online of this happening.
I was driving on the highway when the engine would not accelerate. I was stuck in a high speed lane and drivers were on my rear bumper. I could not move over and felt helpless. I pulled off at the next exit and the vehicle was sputtering. I made it home at reduced speed. The vehicle would not start the next morning. I had it towed to the nearest dealership. I was contacted days later and informed that the is a bulletin about power loss due to faulty fuel injectors. Many complaint sites are full of the same problems. I now feel unsafe driving the vehicle on trips. I don't want to get stuck in the middle of nowhere. I am a female senior citizen.
the federal safety agency Complaint On Sunday, March 10th 2024 our 2022 Hyundai Tucson with 2.5L engine started missing in one of the cylinders. It did not disable the vehicle and it ran like that for several blocks until we could pullover to safety. At this time there were no warning lights of any kind. It wasn’t until I turned the car off, checked the oil (which was good), started the car again and did a lap around the parking lot that the check engine light came on. So there were no warnings. We dropped the car off at our local Hyundai service center that night so it could be checked first thing the next day. It turned out that it was a bad spark plug and injector. At that point it was no big deal. We chalked it up to a fluke. We received the car back on Thursday, March 14th with the explanation of what happened and that it was replaced under warranty. There were NO RECOMMENDATIONS made upon pick up. Exactly 2 weeks later on Thursday, March 28th, the car lost all power while traveling 60mph in the middle lane of the interstate. Again, there were no warning or diagnostic lights coming on. It was pure luck that there was minimal traffic and other drivers were paying attention as the car came to a complete stop in the middle of the highway in order to be restarted and it refused to accelerate above 20mph in order to limp to the shoulder and get to safety. Over an hour later and stopping and starting the car in a parking lot, the check engine light finally came on. The engine was running worse this time. The car had to be towed this time to the service center. After being checked out it was another spark plug and a fouled fuel injector. Researching online showed that this is a very common issue with Hyundai fuel injectors between 12,000 and 25,000 miles. There are currently no technical service bulletins or recalls warning owners of this common failure and potentially losing power traveling at high speeds. Research showed there have been 3 collisions caused by this exact issue to date.
In December, while parking in garage, the vehicle suddenly accelerated causing considerable property damage Yesterday, Feb 26,2024 this happened again while parking. The car suddenly accelerated while parking, jumping over the parking curb and into the corner of a building causing major damage to the vehicle. No airbag deployment or forward collision warning in either case
This is the third time I had issues with my 2022 Hyundai Tucson losing power, being unable to accelerate, and/or completely losing power and stopping. I already created an NHSTA report/complaint when the first incident occurred 11 months ago (the federal safety agency ID Number: 11507213). Since then, the issue occurred twice (has 33,000 miles & always maintained). I am a professional female in [XXX] . The 2nd time was at night [XXX]; I was on my way to a program for work, car decelerated. I could navigate, with great distress and frustration to a side street where the car shut off completely. I contacted my husband, my supervisor (who delayed the program start for a few minutes, then began without me), Hyundai Blue Link and AAA. My supervisor sent someone to pick me up so I could be present at the program and make my presentation. A colleague returned me to my failed vehicle. I called AAA for an update on the tow, which I was told would not be for another several hours after midnight. My colleague drove me home (16.5 miles one way: my husband was even further away) as I would have again been alone in my vehicle at night (without heat). This third time (Jan 2024), I used the climate start for at least 12 minutes before driving. The car never gained acceleration above 19 mph, occurring immediately. I thought it was just a cold engine that would dissipate as I drove, but it didn't. Since I could not get the engine to accelerate, I could not get heat. It was as though the engine was draining all the functions of the vehicle. There were no cars in front of me, but several drivers behind me were very angry; amazingly, no accident occurred. Finally drove to dealer, called Uber, and was late to work again! Purchased my Tucson after engine issues with my Hyundai Sante Fe. Both purchased new with many extended warranties, assuming I'd have a safe and reliable vehicle. Car still at dealer (10 days). Is Hyundai ignoring safety and significant hazards over sales and profits? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FO
Spring and Summer 2023: Multiple safety sensor malfunctions during highway rides pose a risk. The official dealership reset the system, but issues have persisted over the last few months. August 9, 2023: Sudden and intense shaking, poor driving performance. The vehicle was serviced at the official dealership (LITHIA Hyundai of New Port Richey #396). Replaced Parts: QQH Injector Assembly Fuel QQH Pipe-High Pressure Combustion Seal Ring K Bolt Gasket-Port Gasket-PCV FKM Washer-Injector Bracket x 2 September 25, 2023: Recurrence of shaking and jerking while driving on the highway. The vehicle was dropped off at the same official dealership. Replaced Parts: Spark Plugs Combustion Seal Ring QQH Pipe-High Pressure QQH Injector Assembly Fuel December 19th, 2023: The same issue appeared yesterday. The vehicle was dropped off for repair at the official dealership (LITHIA Hyundai of New Port Richey #396). Ongoing concerns and recurrent problems warrant further investigation and resolution. Dealership Information: LITHIA Hyundai of New Port Richey #396 Address: 3936 US Hwy 19, New Port Richey, FL 34652 Phone: (727) 203-7300
While driving uphill, the car lost power, beginning to spurt and stalling. Then the car was not able to accelerate while car kept spurting and stopping. It was a dangerous situation as this happened while we were driving, in the middle of the road, while going uphill. Thankfully it was at night and there were no cars behind us but if there was we would have clashed into it. Towed the vehicle to the dealership and was informed that the same year TUCSON came in the night before with similar problems. It appears that there is a pattern to this safety concern. Please take action before someone gets hurt. Car shutting off like this while driving poses safety concerns for drivers and all the people around it. Even with fix, I don't feel safe driving unless I see actions taken by Hyundai to solve this apparent issue with powertrain/engine.
My wife was with my Aunt and driving at 70mph on PGBT highway and instant the check engine light come on and the car started smelling of burnt equipment and stalled. The cabin was filled with white smoke and the windows jammed as well. The car was stalled in the middle of the highway with traffic zooming past and severing to save us. This car put my family is a life threatening situation and I want that to be recorded. We use this vehicle for our family trips and it haunts me to think what it can do to my wife and kids. I have started a formal complaint with Hyundai corporate and the complaint number is [XXX]. Also the car is with Hyundai Dealership at Address: 1301 N Central Expy, McKinney, TX 75070 (469) 525-4300) and I am yet to receive a diagnosis from them on what actually happened to the vehicle. Cops were called at the scene but a formal police report was not given. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
System Failed: Shut off in traffic. Vehicle can be inspected upon request. Safety risk: Potential for collision. Input from Dealership: Dealerships error code/diagnostic code was P213800. Reset system and recharge battery. Warning lights came on at the same time as the car shut down. One month prior check engine light came on, but car was operating normally. Dealership ran diagnostic test which did not indicate any issues. The suggestion was to tighten the gas cap.
This car has 36,000 miles, purchased new and serviced on schedule. The car is at the dealer for the third time since purchase. The first was a fuel injector issue/drivetrain error. The second time was a bad spark plug. The most current issue is another fuel injector. People on the internet have reported similar problems. The dealership has directed us to come get the car, which is unacceptable, because this is an engine error. I spoke to Hyundai Customer Car and they directed me to rent a car at my own cost and to not drive the car.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Hyundai Tucson?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history