2022 Hyundai Tucson fuel system problems

Filed Sep 28, 2026 · Fuel system · IN

My car suddenly broke down on the side of a busy highway halfway through my workday. When attempting to restart it, all warning lights came on on the dashboard and I could see white smoke coming out of the exhaust pipe while the car shook. I had it towed to the nearest Hyundai dealership and they confirmed it was broken fuel injector(s). I do not have the broken piece to show as it is with the dealership. It has not been examined by police or insurance. No warning lights came on until after the car had suddenly slowed to a stop and I attempted to restart it.

Filed Sep 10, 2026 · Engine, Fuel system · GA

Vehicle Fuel Injector code P053F84 Reading on 9/9/26, this is the second time vehicle was taken to the dealership for the exact same problem, the idle button in orange, and displayed, first visit while vehicle within warranty limits technician stated couldn't find anything wrong, now vehicle is out of warranty and dealership wants $1300 to fix the same issue.also the Engine was hesitating at each occurrence.

Filed Aug 29, 2026 · Engine, Fuel system · TX

In April 2026 (29,805 miles) I was on an interstate underpass U-turn and when I went to accelerate from the U-turn, the vehicle “revved”, had difficulty accelerating, and appeared to not go into the next gear for a roughly 10 seconds, meaning I was unable to accelerate and get out of the way from oncoming traffic. Traffic slowed and the vehicle suddenly returned to normal (no warning lights appeared) and I drove home cautiously with hazards on. When attempting to leave less than 45 minutes later, the vehicle started, then as I placed it into drive, it began lunging and the check engine light appeared. Because it was running rough and kept lunging, I parked and had it towed to the dealership. The DTC code listed was PO30300 (DTC system powertrain and subsystem EMS). Per the dealership, fuel injector #3 was bad and needed to be replaced. When I picked up the vehicle, notes stated “ GDI FUEL INJCTR REPL (ALL4)”. I picked up the vehicle after the repair. In August 2026 (30,923 miles), with less than 1,000 miles driven since repair, I started the vehicle and it immediately “died”. I restarted it and the check engine light came on and it began lunging out of my driveway. I also had difficulty getting the vehicle to brake and almost hit our community entrance/exit gate. A notification appeared on my infotainment system stating: “A possible condition with your Engine Control System has been detected. A full system check is recommended to be done soon. Please contact your local dealership to schedule an appointment”. The DTC codes listed on the Hyundai app were: PO30020, PO30040, PO30010, PO30000, and PO19185, P217700. (DTC system powertrain and subsystem EMS). I had the vehicle towed to the dealership. They didn’t have a loaner vehicle and I canceled my trip. Later, I was notified that “a hose was disconnected and was allowing air to enter the engine”. He stated, “we flushed it out and everything is working now”. I was told I could come pick it up before they closed.

Filed Aug 26, 2026 · Fuel system · TN

Fuel injector went bad causing vehicle engine to misfire and shake rapidly. Check engine light is on. The vehicle only has 40,000 miles on it. Seems to be a very common concern for this make and model and roughly the same years. Will not accelerate instantly and will surge a bit when it does. Will still shake when the vehicle is idle.

Filed Aug 3, 2026 · Fuel system · AZ

While driving the car stalled and then the engine shutdown, caused by a misfired fuel injector. Myself and the passengers in the car were minorly safe, as this incident occurred while driving through the Yellowstone National park; having to pull over on the side of the road with no shoulder. The Woody Smith Hyundai Dealership in Idaho Falls confirmed that the feul injectors had misfired, and then replaced them. Prior to the failure, there was no warning until the car was actively stalling and failing (battery light and check engine light came on).

Filed Jun 27, 2026 · Fuel system · IA

I became aware of a Technical Service Bulletin that Hyundai published in Jan 2025 acknowledging that many vehicles (of which mine is one) have a faulty fuel injector and it will fail. Hyundai elected to not issue a recall on this issue so the public has no idea they are driving vehicles that are just awaiting for a malfunction in their engine. It appears the reason Hyundai is doing this is because fuel injectors are only covered on the manufacturer’s limited 5-year 60,000-mile warranty so they are hoping the faulty injectors last long enough to get beyond that point and customers don’t know the injectors were even faulty to begin with (because TSBs are not public knowledge). Hyundai can then charge for full repairs and omit admittance that the injectors were faulty and blame it on wear and tear. Mine failed beyond 60,000 miles and I am in this predicament. I imagine most customers with 2022 vehicles have not driven as much as me and haven’t had this come up. It seemed like something I should inform someone about. Do with this what you wish

Filed Jun 13, 2026 · Acceleration, Brakes · SC · crash

On 3 occasions over my 18-month ownership of this certified pre-owned Hyundai 2022 Tucson, the vehicle surged suddenly forward WITH BRAKE APPLIED at creeping (parking) speeds of 3-4 mph. No warning lamps were observed. On the most recent (3rd) occasion, a crash over a sidewalk and into a storefront caused $10,000 damage. No pedestrians were harmed, no airbags deployed and neither passenger was harmed. The service department is "unable to duplicate" the surging behavior and declares the car mechanically "safe to drive."

Filed Jun 2, 2026 · Fuel system · 50,000 miles · TN

The contact owns a 2022 Hyundai Tucson. The contact stated that the fuel door had failed to open intermittently. The contact stated that the failure had progressively worsened, causing the contact to seek assistance to open the fuel door. The vehicle was taken to the dealer where it was being repaired. The manufacturer was not contacted. The failure mileage was approximately 50,000.

Filed May 22, 2026 · Engine, Fuel system · GA

Multiple DTC codes on car at 25,120 miles,32,344, 34,324, 47,484, 51,853, 53,521, Consistent Fuel Injector failing under warranty, prior to 60,000 miles and not replaced correctly, as I have had to see dealership 4 times for ineffective fuel injector replacement and consistent problem. First DTC code reading @ 25,120 miles as stated on DTC coding Reports through Hyundai/Bluelink app. SEVERE Fuel leak into interior cabin and Fuel failure due to Powertrain/Injector Issues from 25,120 miles, and many more mileage as seen above. AUTO start does not work, Catalytic Converter is in need of replacement as codes read DTC code past readings and Engine Failure: P04567A, P030300, P022200,P012300,P210013,P042033,P042033 With FUEL INJECTOR/Powertrain Error. Caused car to engine fail in middle of driving!! *SAFETY CONCERN. I Have started multiple cases with Hyundai Motor America, and they had done nothing to report the problem or keep car for further testing and safety priority. Car is brand new, has about 66,800 miles on it now, had to replace all FUEL INJECTORS, FUEL RAIL, and now needing to replace Catalytic Converter due to Hyundai not covering issue that was consistent with Fuel Injector and initial GAS leak into Cabin. I had to visit the doctor many times due to GAS FUMES. 2025-2026-DTC codes stated under individual mechanic, and within my Hyundai Blue Link app as reading multiple DTC codes that Hyundai Refused to cover or fix initially. (Wrights Car Care, Atlanta, GA) stated that car is not safe to drive and is FIRE HAZARD (Technical Bulletin Alert) for Catalytic Converter is now pending and previously read as powertrain issue.

Filed Apr 20, 2026 · Engine, Fuel system · CA

1st Incident: Merging on to the freeway car started to stall but was able to safely make it off the freeway at next exit. Less than 2 miles was unable to accelerate to properly merge on freeway. A slow merge & slow driving on to a freeway is extremely dangerous. 2nd Incident: 6 months later, Nov. 2023. Driving about 65-70 MPH on the freeway with my son, the car started to stall again. I was able to safely move from the 2nd lane, to the shoulder. Waited over 2 hours in the dark for AAA to safely move us. 1st time documented issues with Hyundai dealership. Fuel injector was main issue and was replaced. No check eng light. 3rd Incident: May 2024 was driving about 75MPH in the fast lane when the car stalled. I was unable to move fully out of the lane as the car just died. I was half in the shoulder and the fast lane. I was crying with fear while I had to wait for CHP to move me. Multiple times feared other cars would hit me at 80MPH+ while I waited 30mins+ for CHP to stop traffic and move me to the shoulder. Took the car to the dealership for the second time to be "fixed" for the same issue as Nov. 2023. Fuel injector, and catalytic converter were "replaced". This now being the second time for the fuel injector issue. No check eng light. 4th Incident: April 2026 driving on a school night home from dinner with my son at about 9:45pm. It was raining and was traveling at about 55MPH on the highway. Car started to stall/ shut down again. Was able to go about15MPH to a safe spot and waited for assistance late at night. This happened on a highway where people tend to drive recklessly and try to pass other vehicles which causes a lot of head on collisions, [XXX] . Vehicle was towed to Hyundai dealership for the 3rd time & 3rd time documented for the fuel injector and 2nd for the catalytic converter. The vehicle's main purpose is to safely transport and I've had nothing but nightmares and put in extremely dangerous situations with my son. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B