2022 Hyundai Tucson: stuck in gear or won't shift

Filed Oct 16, 2025 · FL

Car goes into limp mode and will not accelerate over 25 mph. This has happened 5 times while driving in traffic. It is very unsafe and could be the cause of an accident. Fortunately we found a place to pull off the road, wait a while, and restart the car.

Filed Aug 1, 2025 · Electrical, Transmission · OK

The vehicle is currently in the shop due to safety concerns involving malfunctioning exterior lighting and a serious incident of the vehicle entering limp mode. 1) With automatic headlights activated, all exterior lights shut off while driving at night, posing a significant safety risk. 2) During daylight hours, the automatic headlight system inconsistently toggles between different lamp settings, switching off and on erratically. 3) While attempting to turn left during morning rush hour traffic (on a 40 mph road where vehicles often travel 50+ mph), the vehicle entered limp mode upon acceleration. It bogged down in the middle of both lanes, unable to exceed 13 mph, placing me in a highly dangerous position. After pulling over and leaving the vehicle off for 5 minutes, the issue temporarily resolved upon restart. 4) The vehicle is stored in a garage, and following the limp mode incident, I received repeated “door unlocked” notifications every 30 minutes from 2:30 AM to 5:30 AM, though the vehicle had not been accessed. These issues are of serious concern and appear comparable to conditions outlined in Recall #149 and Recall #236, both of which address similar malfunctions related to exterior lighting and powertrain performance. VIN# currently is not within the recalls.

Filed Apr 22, 2025 · Fuel system · NY

My 2022 Hyundai Tuscon is in the shop for a SECOND time due to a bad fuel injector. The first time was 4 months ago. My vehicle's check engine light went on and it went into "limp mode" on a major roadway. (I take all major highways to work.) A vehicle going into "limp mode" on a highway is super dangerous. My check engine light went on once again, and I brought it into the dealership service center. I left it there for 36 hours, only to learn that they did not have the parts on site to do the repairs. I have to bring it BACK for another 24-36 hours for the repair to be completed on a SECOND bad fuel injector. How Hyundai hasn't issued a recall for the fuel injectors yet is appalling.

Filed Feb 14, 2025 · Engine, Fuel system · PA

2022 to hyundai tuscon now with the third cylinder misfire due to faulty fuel injector. This can be inspected upon request. Upon second occurrence, requested all cylinders be replaced and advised could not do this under warranty. Second filing to the federal safety agency. This incident put myself and other drivers at risk. I was driving on a highway and the cylinder misfire occurred resulting in check engine light and vehicle going into limp mode and inability to drive more than 30-40 mph. The entire vehicle violently shakes and loses power with this misfire. In the previous occurrences , could not accelerate beyond 20 mph. I could have been rear ended or caused a serious accident on the highway as a result of Hyundai faulty fuel injectors and cylinder misfires. My vehicle has now been seen 3x for the same issue and replaced by dealer. There were no warning signs prior to the failure of the fuel injector resulting in cylinder misfire and loss of power and inability to accelerate. This is a very dangerous faulty component of this year make and model- it is a known issue. Still no recall. I have a "new" car that puts me in danger every 4-6 months when I lose power in my vehicle with no warning or cause except from faulty parts. This faulty part is going to cause serious injuries/accidents if it is not addressed.

Filed Nov 18, 2024 · Electrical, Engine · 32,000 miles · NC

The contact owns a 2022 Hyundai Tucson. The contact stated while driving at various speeds, the vehicle intermittently went into LIMP Mode with several unknown messages displayed on the instrument panel. The contact stated that the failure occurred for approximately 15-20 seconds before the vehicle resumed normal operation. The vehicle was taken to the dealer, but the failure could not be duplicated. The vehicle was not diagnosed. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 32,000.

Filed Aug 7, 2024 · Fuel system · WI

Fuel injectors have failed three times now. Each time they have replaced a single injector and told me the issue is fixed. Once one is fixed, the other goes shortly after. The vehicle enters limp mode with a check engine light, making it extremely dangerous to try and drive the vehicle, especially on entering the highways. The problem has been confirmed by the dealership, and TSB 23-FL-002H-1 shows they are aware of the issue. I have not had it inspected by the manufacturer (other than technicians at the dealership) or any other entity. This issue has happened twice this year, once in March, and this July as well.

Filed Oct 27, 2022 · Fuel system · GA

With approximately 6552 miles on the car, 7 months after I bought it new, the Vehicle sputtered and shut off. The GDI pump was replaced. It has not runnright since. It sputters, it does not respond appropriately when the accelerator is pressed, it went into limp mode and would not go more than 35 mph. It did not throw and engine code when this happened. This is a huge problem in itself. I could be out of oil and it potentially will not throw a code or warning. When the dealer had it for 45 days they drove it approximately 100 mile and could not duplicate. It is a serious danger to my life and I refuse to drive it. I had it towed and it now sits in my driveway will the lemon law case is processing

Filed Jul 15, 2021 · Transmission · IN

Purchased a new 2022 SUV Tucson on 5/22/21. While driving on a busy street 6/7/21 during work traffic the vehicle just cut off without warning. With horns blaring I managed to coast to the right blocking traffic leaving one lane open for moving traffic. Vehicle after a couple of tries would start but would not move when gear was placed in Drive or Reverse. Hyundai Roadside Assistance notified vehicle towed to closest Hyundai Dealership. This was dangerous vehicles were almost running into the back of my SUV while abruptly stopping. I exited the vehicle while waiting for the tow truck in fear of vehicle being hit placing myself and others at risk of an accident. Informed by Asst. Service Manager at Hyundai Dealership that no one was trained to work on the 2022 TUCSONs at the Dealership. As a Public Safety measure at least some employees at each dealership should be trained to work on all newly released vehicles before they are placed on the market. Notified on June 15, 2021 that the vehicle has a limp mode/ limp node problem. June 16, 2021 I was informed by Hyundai dealership that the 22 TUCSON has a mechanical defect, transmission fluid was leaking which now the Transmission needs to be replaced. The newly purchased vehicle currently has only around 370 miles on it. I thought vehicles go through an inspection before leaving factory and after they reach the dealership before being sold. This I consider to be another safety issue anything can happen during transport. A repurchase/buyback from Hyundai wasn't approved. The vehicle is available for inspection upon request. Vehicle is ready and will be picked up from the dealership requesting an invoice of the repair work completed for viewing. This vehicle could have caused a catastrophic deadly occurrence