There is a recall for 2016 Velosters that is for the engine rods failing. The 2015 to 2016 Hyundai Veloster has been recalled for connecting-rod bearings in the engine that could wear out prematurely and damage the engine1. The 2016 Hyundai Veloster has had several engine-related issues, including excessive oil consumption, going into limp mode, hesitating at acceleration, knocking sound in the engine, poor acceleration, stalling, failure in the timing chain tensioner, rough idling, and oil leaks. Which is exactly what is happening to my car currently. Told me I was not eligible. But I'm not understanding why.
2016 Hyundai Veloster engine complaints
Page 3 of 6: complaints 41 to 70 of 142, newest first, as owners wrote them.
Cylinder one lost compression. My mechanic pulled the engine apart and found the valve broke, a piece of the valve broke off. Compression test was only at 30 lb. in cylinder one. cylinder two had 120 lb., cylinder three had 130 lb., cylinder 4 had 149 lb. This Car had oil changes done every 3k to 4k miles with full synthetic. Never raced and always driven properly. 121k miles and the engine was basically done. Having the entire engine rebuilt for 5k$ now. I was having to add about a quart of oil every 500 miles before the valve broke.
02/??/22 immediately after purchase, the vehicle’s alternator died and had to be replaced. 12/06/22 catalytic converter blew with no warning while driving. Car was towed to mechanic. 12/07/22 repairs were approved, costing $1,748.66. Shop informed us this repair was due to a recall (campaign 22-01-023H-2) From 12/22 through 07-23 I opened many cases with Hyundai, who closed cases without explanation. During this time I am required to refill vehicle’s oil every month to stop engine knocking and prevent break down. 06/23 I was finally able to set an appointment to start the first step of the recall. 07/10/23 I arrived for my appointment to start oil monitoring, but was told to reschedule and come back later. 07/19/23 I arrived for my rescheduled appointment. Dealer made me pay for oil that was used and instructed me to return in 1,000 miles. After 1,000 miles I returned and left my car at the dealer for a few days. When I returned Hyundai staff told me the recall was “only for the original owner.” I was also told the recall was “already fixed” and there was “nothing wrong” with the car. I self advocated, stating again that the oil was depleting rapidly and what I had gone through. Staff told me to “drive the car until it breaks down, then Hyundai will cover the costs of repair.” I mentioned how that is unsafe, but was sent away. 11/24/23 vehicle completely broke down out of state in a dark and unfamiliar area at nighttime. Vehicle was towed, requiring engine repairs. 11/27/23 I opened a case with Hyundai regarding these issues. A few weeks later I was told the case was closed since they “had to believe the dealer and not the client.” 02/05/24 alternator died, vehicle required a tow to the mechanic. 02/06/24 repairs were approved for almost $1,000. I do not feel safe driving this vehicle as it is unreliable, breaks down without warning lights- which only appear after break down, and the manufacturer refuses to take accountability for these issues.
The contact owns a 2016 Hyundai Veloster. The contact stated while driving at approximately 30 MPH, there was an abnormal sound coming from the engine compartment. The contact stated no warning light was illuminated. The contact was able to drive the vehicle to the residence. The contact stated that while driving onto the driveway at the residence, the vehicle was vibrating violently and then stalled. The contact turned off and later attempted to restart the vehicle however, the vehicle started momentarily and then stalled. The contact stated there was cloud of smoke coming from the exhaust. The contact stated that prior to the engine failure, he became aware that the vehicle was consuming approximately 1 quart of engine oil every two weeks. The vehicle was not taken to a dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to the federal safety agency Campaign Number: 20V746000 (Engine). The manufacturer was not informed of the failure. The failure mileage was approximately 129,000.
The contact owns a 2016 Hyundai Veloster. The contact stated that while his son was driving at an undisclosed speed, he heard an abnormal knocking sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the connecting rod bearings. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 20V746000 (Engine) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 130,000.
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, the engine made knocking sounds. Additionally, the vehicle hesitated to accelerate while driving. The TPMS warning light was illuminated. The vehicle was taken to the dealer, where Service Campaign 993 (Inspect & Anti-Theft Software Upgrade) was performed, and the engine was replaced. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 73,200.
On 11/21/2023, I took my vehicle to Musser's Automotive in Tipp City, Ohio & I was informed of an Internal Oil Consumption & recommendation for warranty coverage.
After previous complaint I filed, my engine continued to decline. Began burning a quart of oil approximately every 240 miles and has now almost completely lost power. It will not go above 25 miles per hour. I can not drive it anywhere except within two miles of my house where the speed limit is 25mph. EXCEEDINGLY DANGEROUS! It will die while driving and crank right back up but then die again. As contained in my previous complaint - Check engine light has been flashing since last December, Oil light comes on approximately every 240 miles. Other model years of this car have been recalled due to oil issues - but not this one. Yes the engine has been inspected and everyone agrees the engine is bad but Hyundai refuses to do anything about it due to the car not being included in the previous recall years. PLEASE inspect it. Anytime you want. It's not like I can drive it anywhere. I would drive it straight to a junk yard, but am still paying on it. You should know, if you don't already, that Hyundai is regularly giving owners of cars that have been included in the recall, the runaround on repairing anything. There are multiple facebook groups with literally THOUSANDS of people complaining about the same or similar issues with their Hyundai vehicles and nothing is being done. The MOST disreputable company I have ever dealt with - from the dealer all the way up to corporate. READ SOME OF THESE STORIES TO GET A TRUE UNDERSTANDING OF THE PROBLEM... [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving approximately 45–55 MPH, several unknown warning lights illuminated. The contact was able to pull over, looked under the hood, and notice that an unknown fluid was boiling. The vehicle was towed to an independent mechanic, who informed her about unknown recalls. The vehicle was towed to the local dealer, where it was diagnosed that the radiator was empty. The vehicle was not repaired under the federal safety agency Campaign Number: 20V746000 (Engine) due to owner neglect. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 79,000.
Unknown Regular oil changes, cranked my car up one morning and it started knocking, I have been in a rental for 2 weeks now and paying out pocket as a single mother in grad school. The dealers excuse of not diagnosing the car sooner, is that their schedule is busy after arguing with the extended warranty company about my coverage. I booked their next soonest appointment to be told we'll see if we can get it looked at that day. I believe they're hiding the fact that my bricks falls under recall 198 and do not want to admit it.
The contact owns a 2016 Hyundai Veloster. The contact stated while driving 40 MPH, the engine started knocking. The contact stated that several days later the knocking sound became louder, and the vehicle became inoperable. The vehicle was towed back to the residence. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in a recall. The failure mileage was approximately 109,852.
My vehicle started making knocking noise in front end. Took it to my mechanic and he told me to take to dealership and see if there is a recall for my car. I've done so much research on vehicle for recall and it says that its the rod knocking which should be covered as the recall I found but Hyundai is giving me problems with it. Vehicle is a 2016 Hyundai Veloster Turbo
The engine is stalling. Check engine light is flashing. Car is in limp mode. Dealership say it not a matter of it but when the engine blows up. Have seen where some of these cars blow up and catch on fire. Hyundai want help me or thousands of other people with this problem
When my car 2016 Hyundai Veloster reached almost 95000 mileage the oil starts to dissipate much faster so started to do oil change much often. Recently and my care already at 97000 mileage. We are driving going up a hill and it started to make some noise kind of like a motorcycle noise and I know there is something wrong but no light warnings or anything. I was trying to push it to get to a safer side of the road because I have my 86 year old mother with me but the car did nor make it and heard something snap really loud and the car just stopped and saw a little bit of smoke. Had to stop immediately on the side of the road and it was a bad spot against the rail and that blocked the 2 doors on the right side. the car only have 3 doors so now my mother is stuck and had to figure out how to have her crawl out to get out the driver side of the vehicle. If the car was on fire that would have been really dangerous. Took it to the mechanic and my insurance inspector already saw the car and determined that there was some kind of rod that came off and that the engine is blown an that it is with a hole. it is beyond repair or if I do it will cost $5000-$6000. I bought it on 2018 with only 5000 miles on it. I kept up with yearly maintenance. I think it is insane that it will break that fast and we are traumatize with the danger. I am not ready financially for this.
Engine is consuming oil. Catalytic converter becomes restricted, and motor will stop running while driving. After restart motor will not have enough performance to exit traffic. Catalytic converter was replaced and now problem is recurring.
Car started making a loud rattling sound. Took car to get diagnosed, issue was with the connecting rod bearings inside the engine. Asked about current NHSTA campaign id # 20V746000 but was denied because my engine is not part of the recall. My car recently had a maintenance check up at the dealer and was marked as fine, no issues. Engine light blinked once for about two seconds, no other warnings. I am very upset as this could have lead to serious issues and now I have to pay out of pocket to replace entire engine. Open campaign recall is for 2015-2016 Hyundai Veloster, my car is a 2016 Hyundai Veloster. Why is my engine not covered in recall?
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving at various speeds, the vehicle stalled, and the check engine warning light illuminated and remained illuminated. The cause of the failure was not yet determined. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in a recall. The failure mileage was 76,000.
The contact owns a 2016 Hyundai Veloster. The contact stated that while his son was driving at an undisclosed speed, the vehicle lost motive power with the oil pressure warning light illuminated. The vehicle was taken to an independent mechanic, who inspected the engine oil and noticed there were metal shavings inside the engine oil. The vehicle was later towed to the dealer, where it was diagnosed that there were metal shavings inside the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to the federal safety agency Campaign Number: 20V746000 (Engine); however, the VIN was not included in the recall. The failure mileage was approximately 48,000.
The contact owns a 2016 Hyundai Veloster. The contact stated while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer and the catalytic converter was replaced. On another occasion while driving 40 MPH, the vehicle lost motive power. The contact was able to pull over on the side of the road and shifted into neutral and was able to restart the vehicle and the vehicle operated normally. The vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was 147,400.
The contact owns a 2016 Hyundai Veloster. The contact stated that the vehicle was taken to the local dealer for trade-in and the contact was informed that the dipstick was burned and that the engine was defective. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 73,400.
Driving on highway at night coming around curve my car was still on which electrical was okay but my car started gliding like it was in neutral and could not accelerate. My car engine cuts off on highway. I'm luckily , a lot of cars were not on the highway at the time, letting me use my steering wheel to mauver to side of the highway. I tried turning the car off and turning back on would not crack but lights would come on. I had to get a car towed to my house. Appointments book until first week of May so been without a car sense April 11th. I was made aware of the 2016 Hyundai Recall on premature connecting bearing rods vehicle that could lead to crashes because Veloster's are shutting down on the highway like mines did. I'm sending my car to dealership on May 2, 2023, to Thorton Rd Hyundai dealership to perform the steps the dealership recommended me to do to see if my car qualifies to get extended warranty to fix my engine. All complaints read on 2016 HYUNDAI VELOSTER 3C FWD | the federal safety agency reads to me that my car was underling and part of the effect it's just that I'm more fortune than others that my engine lasted longer due to the care that I gave to my car. I had no warning lights of this incident was near future going to happen to me. All warning lights presented itself when car shut down on highway while costing over to, emergency lane. I love my little bug and want my car to be fixed so we can joy ride again.
I got an inspection on my car and was told to take it to dealership due to a recall The engine would sometimes stall while I was driving The last time I used it, it no longer turned on at all But a check engine light never turned on or anything of the sort The car hasn’t been inspected by anyone
The contact owns a 2016 Hyundai Veloster. The contact stated while driving at various speeds, the engine made knocking sounds, with a burning odor coming from the vehicle and the vehicle then stalled. The failure occurred intermittently and while idling. The check engine warning light was illuminated. The vehicle became inoperable. The contact had spoken to the dealer who confirmed that the vehicle was not included in the federal safety agency Campaign Number: 20V7460000 (Engine) despite exhibiting the same failure. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.
Late Spring 2021–notified of recall due to connecting rod/bearing issue. Hyundai dealer does engine inspection on 4/27/2021 & clears it. Also installed software update to monitor the problem. April 27, 2022–Car dies multiple times while driving on highway. Starts back up each time, but making clacking noise with Check engine & oil light on. Pulled over and had towed to mechanic. Couldn’t get diagnostic code, but told based on the incident, believe the issue related to recall & told to take it to dealer. Had car towed to Hyundai. Ran simple diagnostic. Got no codes. Manager drives & says some hesitation not unusual with Veloster. Did not stall. Recommends fuel additive. Early May 2022-Check engine light comes on & stays. Check at Autozone, Firestone, & dealer– told only catalytic converter code & car is drivable. Oil light starts flickering intermittently about every two weeks. Start scheduling earlier oil changes. Continues to flicker. Start adding oil between changes. August/September 2022?–Receive Hyundai letter stating warranty extended on my engine due to connecting rod recall. Warranty now 15 years/150,000 miles. December 20, 2022–Check engine light starts flashing. December 27, 2022–Dealer says can’t look at for 4 months, take to Firestone. Tech gets code 1326-returns no info in system but research & believe related to recall requiring Dealer fix. Connect with Dealer service & am able to get it looked at in a week. January 9, 2023–tech says excessive oil burnt at top of pistons & oil leaking into cylinders, due to internal seal failure. Recommend replacing engine, but not related to recall. Research finds recall due to faulty piston seals/oil leaks on 2019-2021 Velosters & plenty of complaints about oil seal problems & excessive oil burning problems with earlier Velosters as well. Car unsafe to drive on highway due to lagging acceleration & hesitation. 2/3/2023–call Hyundai America about safety concerns. 2/7/2023–Hyundai denies claim.
The engine overheated with no lights on the dash and the engine block cracked
While driving down the highway the engine began to knock loudly. When the engine stalled. The vehicle stalled while traveling on a congested highway at a speed of approximately 70MPH. The vehicle was pulled to the side of the road where I waited for a tow truck via AAA for 5 Hours. The vehicle was towed to an independent service center that diagnosed it with a worn rod bearing, which in turn is causing the knocking. The vehicle has been maintained and oil changed regularly. Vehicle is unusable in current state as it is at risk for complete engine failure and risk of fire. No warning lamps or messages were present at time of incident. Vehicle is available for inspection upon request.
The contact owns a 2016 Hyundai Veloster. The contact stated while driving 70 MPH, the vehicle began to stall. The contact stated no warning light was illuminated. The contact was able to park on the side of the road. The vehicle was not drivable. The contact towed the vehicle to her residence. The contact towed the vehicle to the local dealer, where it was diagnosed and determined that the catalytic converter needed to be replaced; and the vehicle was repaired under the federal safety agency Campaign Number: 20V746000 (Engine). The dealer replaced the catalytic converter but then informed the contact that the VIN was not included in the federal safety agency Campaign Number: 20V746000 (Engine). The vehicle was not serviced under the recall. The manufacturer had been informed of the failure. The failure mileage was approximately 81,000.
I was driving my 2016 Hyundai Veloster Turbo when I started to hear a loud knocking sound coming from the engine. At this time I also noticed a decline in power and the check engine light came on. I made an appointment to bring the car to my local Hyundai dealership to have the car looked at. While en route to the dealership, the car suddenly made a loud bang and a profusion of smoke came out of the engine and engulfed the car, inside & out, making it impossible for not only me to see but also limited visibility for the person following me, which was extremely dangerous. I couldn't see or breathe and had to rapidly exit the car on the side of a busy road with no shoulder. The engine completely failed and the car was not drivable. I had the car towed to the Hyundai dealership where they told me the engine had seized and needed to be completely replaced. Although my VIN is not yet included in engine recall 20V746000, my car has the 1.6 liter GDI Gamma engine included in that recall. In addition, the exact chain of events that I experienced have been described by others whose cars are included in the recall which describes connecting rod bearings inside the engine wearing prematurely (creating a knocking sound and reduced engine power), causing engine damage. I am requesting an investigation into this incident as I feel that my car should be included in the recall. It was a very dangerous incident and I don't want others to needlessly experience this same problem, possibly with more harmful consequences.
The contact owns a 2016 Hyundai Veloster. The contact stated that an abnormal rumbling noise was coming from the vehicle at start-up. The check engine warning light was illuminated. The contact then received notification of the federal safety agency Campaign Number: 20V746000 (Engine). The vehicle was taken to a dealer where a software update was performed; however, the failure persisted. The vehicle was then taken to an independent mechanic who diagnosed the vehicle with engine failure. The vehicle was also taken to AutoNation Hyundai Hilton Head (255 Drivers Way Suite B, Hardeeville, SC 29927) where a temporary repair was performed; however, the failure recurred. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 109,000.
The contact owns a 2016 Hyundai Veloster. The contact stated that while driving approximately 55 MPH a loud booming sound from the engine compartment had occurred and a knocking noise followed along with white smoke from the exhaust pipes. The vehicle drove off the road before flames were present coming from under the hood. The fire department was called to the scene and extinguished the flames. A police report was taken and the vehicle was towed away. No injuries were reported. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The contact indicated that the vehicle had previously been serviced several times for a faulty engine and catalytic converter. The failure mileage was 100,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Hyundai Veloster?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history