Ic Bus Ce recalls

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, 2018-2020 and 2023-2024 International 1300FBC Stripped chassis, 2019-2022 IC Bus CE Commercial bus, 2019-2024 IC Bus TC Commercial bus, and 2019-2024 International MV vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Risk

An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Remedy

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch and if necessary, the wire harness or fuse, free of charge. Owner notification letters were mailed September 29, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23517.

Recall number 23V397000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021-2024 International HV, HX, LoneStar, LT, MV, eMV, and RH trucks, and IC Bus CE, 2021-2023 IC Bus RE, and 2022-2023 IC Bus TC Commercial Buses. The anti-lock brake system (ABS) indicator light does not remain illuminated when a malfunction exists, and when the vehicle's ignition switch is on, and the vehicle is in motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Risk

An ABS indicator light that fails to remain illuminated will not alert the driver of an ABS malfunction, which could increase the risk of a crash.

Remedy

Towing variant vehicles under this campaign will not be repaired under recall 24V-8918. Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 24, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23515.

Recall number 23V370000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2022-2023 IC Bus CE, and 2022-2023 IC RE transit buses. The roof panel may have been manufactured with insufficient joint strength.

Risk

A school bus roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.

Remedy

Dealers will add additional fasteners to secure the joints, free of charge. Owner notification letters are expected to be mailed April 3, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23502.

Recall number 23V066000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2023 IC CE and IN RE commercial buses. The fasteners that connect the transverse torque arm to the rear axle housing may have been tightened incorrectly, which can allow the rear axle to shift side to side.

Risk

A rear axle that moves side to side can cause a loss of handling and control, increasing the risk of a crash. In addition, a loose rear axle may cause vehicle instability during an evacuation in an emergency, increasing the risk of injury.

Remedy

Dealers will replace and tighten the fasteners, free of charge. Owner notification letters are expected to be mailed February 6, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 22528.

Recall number 22V910000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021-2022 International CV, 2022-2023 International HV, 2023 IC 1300 FBC, CE, RE, TC, International MV, HX, LT, RH, and LoneStar vehicles. The hex flange lock nuts, used in the suspension and steering joints, were improperly heat treated and may lose tension over time.

Risk

A loss of tension in the steering and suspension joints may lead to steering instability and increase the risk of a crash.

Remedy

Dealers will replace the hex flange lock nuts as necessary, free of charge. Owner notification letters are expected to be mailed January 20, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 22524.

Recall number 22V869000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2022-2023 IC CE, IC RE and 2023 IC 1300FBC transit buses. The steering wheel retaining nut may have been tightened incorrectly, which can allow the steering wheel to loosen and detach from the steering column shaft.

Risk

A loose or detached steering wheel increases the risk of a crash.

Remedy

Owners are advised not to drive their vehicles until the repair has been performed. Dealers will remove the steering wheel nut, apply thread locker, and reinstall the nut, free of charge. Owner notification letters are expected to be mailed May 2022. Owners may contact Navistar, Inc. customer service at 1-331- 332-1590. Navistar number for this recall is 22512.

Recall number 22V369000 · Recall details

What is wrong

Navistar, Inc. is recalling certain 2022-2023 IC CE, IC RE, and 2023 IC EV school buses. The steering wheel retaining nut may have been tightened incorrectly, which can allow the steering wheel to loosen and detach from the steering column shaft.

Risk

A loose or detached steering wheel increases the risk of a crash.

Remedy

Owners are advised not to drive their vehicles until the repair has been performed. Dealers will remove the steering wheel nut, apply thread locker, and reinstall the nut, free of charge. Owner notification letters were mailed on May 25, 2022. Owners may contact Navistar, Inc. customer service at (331) 332-1590. Navistar's number for this recall is 22511.

Recall number 22V367000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2020-2021 IC CE transit buses. The engine control module (ECM) may set a fault code that results in an unexpected engine shut down.

Risk

Unexpected engine shut down can increase the risk of a crash. Additionally, a disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.

Remedy

Dealers will update the engine control unit software, free of charge. Owner notification letters notifying owners of the safety risk were mailed January 18, 2022. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 21508.

Recall number 21V838000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021-2022 IC Bus CE school buses. The weather seal of the illuminated stop sign unit may allow contaminants to enter into the unit, resulting in reduced performance. In certain cases, an electrical short may occur which would render the unit inoperable.

Risk

If the sign performance is inhibited, or completely inoperable, it can reduce the visibility for oncoming drivers, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will replace the LED illuminated school bus signs, free of charge. The recall began December 15, 2020. Owners may contact Navistar customer service at 1‑800‑448‑7825.

Recall number 20V789000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2017-2021 IC CE School Buses equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Risk

A fire increases the risk of injury. An engine stall can increase the risk of a crash.

Remedy

Cummins will notify the affected Navistar customers and dealers will disable the fuel heater by either installing a plug in place of the heater or otherwise rendering the fuel heater non-operable and remove the fuse supplying electrical power to the fuel heater and install a cover over the wire harness connector, free of charge. The recall began May 28, 2020. Owners may contact Cummins customer service at 1‑800‑286‑6467.

Recall number 20V220000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2017-2020 International WorkStar and International DuraStar, 2018-2019 IC 1300 FBC Commercial and IC HC Commercial, 2018-2021 IC CE Commercial, International MV and International HV, and 2019-2021 IC TC Commercial buses with Cummins B6.7 diesel engines with a fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Risk

A fire increases the risk of injury. An engine stall can increase the risk of a crash.

Remedy

Cummins will notify the affected Navistar customers and dealers will disable the fuel heater by either installing a plug in place of the heater or otherwise rendering the fuel heater inoperable and removing the fuse supplying electrical power to the fuel heater and installing a cover over the wire harness connector, free of charge. The recall began May 28, 2020. Owners may contact Cummins customer service at 1‑800‑286‑6467.

Recall number 20V219000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2019-2020 IC RE and IC CE commercial buses equipped with feature code 48PZP, 48PZR, 48RZY, 48SXV, or 48SZG (Prolo emergency exit roof hatches). Due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use.

Risk

If the roof hatch external handle breaks, in the event of an emergency, the hatch cannot be easily opened from outside the vehicle, increasing the risk of injury.

Remedy

Navistar will notify owners, and dealers will replace the outer handle, free of charge. The recall began October 7, 2019. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 19514.

Recall number 19V581000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2011 IC CE transit buses equipped with certain non-retractable passenger two-point lap belts. After long term buckling and unbuckling of the seat belt, the plastic fingers on the male portion of the buckle may crack and fall off, requiring excessive force to buckle the seat belt.

Risk

In the event of a crash, the seat belt may not buckle or properly restrain a passenger in the event of a crash, increasing the risk of an injury.

Remedy

Navistar will notify owners and dealers will replace the seat belt assemblies, free of charge. Navistar issued interim notifications to owners on August 16, 2019. The recall began September 23, 2019. Owners may contact Navistar customer service at 1‑800‑448‑7825.

Recall number 19V479000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2011 IC Bus BE, CE, and RE school buses equipped with certain non-retractable passenger two-point seat belts. After long term buckling and unbuckling of the seat belt, the plastic fingers on the male portion of the buckle may crack and fall off, requiring excessive force to buckle the seat belt.

Risk

The seat belt may not easily buckle, increasing the risk of an injury in the event of a crash.

Remedy

Navistar will notify owners and dealers will replace the seat belt assemblies, free of charge. Navistar issued owners an interim notification on August 16, 2019. The recall began September 23, 2019. Owners may contact Navistar customer service at 1‑800‑448‑7825.

Recall number 19V478000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2017 IC CE transit buses equipped with Bendix ADB 22X brake calipers. The driver side rear brakes may drag.

Risk

A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increase the risk of a fire. Either condition increases the risk of injury.

Remedy

Navistar will notify owners, and dealers will replace the left rear caliper with a redesigned adjuster mechanism, free of charge. The recall began July 12, 2019. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 19507.

Recall number 19V374000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2016-2020 IC CE and 2019 IC RE school buses equipped with Bendix ADB 22X brake calipers. The driver side rear brakes may drag.

Risk

A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increase the risk of a fire. Either condition increases the risk of injury.

Remedy

Navistar will notify owners, and dealers will replace the left rear caliper with a redesigned adjuster mechanism, free of charge. The recall began July 12, 2019. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 19506.

Recall number 19V373000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2017-2020 IC Bus CESB school buses equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electrical wiring within the fuel heater may overheat and may cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Risk

A fire increases the risk of injury. An engine stall can increase the risk of crash.

Remedy

Cummins will notify the affected Navistar owners. Cummins dealers will replace the fuel heater with a newly designed fuel heater, free of charge. The recall began May 2, 2019. Owners may contact Cummins customer service at 1‑800‑286‑6467 or Navistar customer service at 1‑800‑448‑7825.

Recall number 19V217000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2017-2020 International DuraStar and WorkStar, 2018-2020 IC Bus CECB, International HV and MV, 2018-2019 IC Bus 1300 FBC and HCCB, and 2019-2020 IC Bus TCCB vehicles equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Risk

A fire increases the risk of injury. An engine stall can increase the risk of crash.

Remedy

Cummins will notify the affected Navistar owners. Cummins dealers will replace the fuel heater with a newly designed fuel heater, free of charge. The recall began May 2, 2019. Owners may contact Cummins customer service at 1‑800‑286‑6467 or Navistar customer service at 1‑800‑448‑7825.

Recall number 19V216000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2019 International HX, DuraStar, WorkStar, HV, LoneStar, LT, MV, and RH vehicles, and IC Bus HC, CE, and RE vehicles equipped with long stroke brake chambers and spring actuated parking brakes. The spring actuated parking brake may be improperly crimped to the long stroke service brake chamber, causing a service brake air leak and the possible separation of the spring brake chamber from the service brake section.

Risk

An air leak or separation of the spring brake chamber can increase the needed stopping distance, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will replace the brake chamber assemblies from the suspected lot, free of charge. The recall began October 23, 2018. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 18512.

Recall number 18V597000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2018 IC Bus CE transit buses. The release mechanism on the emergency windows may be difficult to open in an emergency situation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk

If extra force is needed to pull the release handle, exit of the vehicle may be hindered, increasing the risk of injury in the event of an emergency.

Remedy

Navistar will notify owners, and dealers will apply dry lubricant to the latch assembly, free of charge. The recall began on June 13, 2018. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 18509.

Recall number 18V316000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2018 IC bus CE transit buses equipped with 8.8L liquid propane gas (LPG) engines. The LPDM relay for the propane booster pump and the scavenge pump may intermittently fail, causing the fuel pump to stop.

Risk

If the fuel pump stops, the bus will stall, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will replace the LPDM relay, free of charge. The recall began on April 12, 2018. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 18502.

Recall number 18V127000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain model year 2011-2016 IC Bus CE transit buses manufactured July 1, 2010, to February 4, 2015, and one IC Bus BE transit bus manufactured on November 2, 2010. The affected vehicles have a water shutoff valve, inside, forward of driver heater (feature code 48PPJ or 48PPP) that has a formed heater hose that over time, may fatigue and split resulting in hot engine coolant fluid leaking into the driver's foot area.

Risk

If hot, pressurized coolant suddenly spills into the operator's foot area, there is an increased risk of a burn injury or a crash.

Remedy

Navistar will notify owners, and dealers will replace the formed heater hose with a more robust one, free of charge. The recall began on January 4, 2017. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 16511.

Recall number 16V838000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain model year 2011-2016 IC Bus CE school buses manufactured November 3, 2009, to February 26, 2015, and 2012-2015 IC Bus BE school buses manufactured August 2, 2010, to September 15, 2014. The affected vehicles have a water shutoff valve, inside, forward of driver heater (feature code 48PPJ or 48PPP) that has a formed heater hose that over time, may fatigue and split resulting in hot engine coolant fluid leaking into the driver's foot area.

Risk

If hot, pressurized coolant suddenly spills into the operator's foot area, there is an increased risk of a burn injury or a crash.

Remedy

Navistar will notify owners, and dealers will replace the formed heater hose with a more robust one, free of charge. The recall began on January 4, 2017. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 16510.

Recall number 16V837000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain model year 2016 IC CE commercial buses manufactured from November 24, 2014, to January 20, 2016. In the affected vehicles, the hood straps used to latch the hood closed may become elongated and not return to their original length. As a result, the hood may open unexpectedly when the bus is braking.

Risk

If the hood opens while braking, the driver's vision may be obstructed, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will replace the hood straps, free of charge. The recall began on April 18, 2016. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 16503.

Recall number 16V090000 · Recall details

What is wrong

Navistar, Inc. is recalling certain model year 2007-2015 IC CE transit buses, 2008-2011 IC FE transit buses and 2009-2013 IC RE transit buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk

If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy

Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1‑800‑448‑7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Recall number 15V870000 · Recall details

What is wrong

Navistar, Inc. is recalling certain model year 2007-2015 IC BE and CE school buses, 2013-2015 IC AE school buses, 2007-2011 IC FE school buses, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk

If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy

Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1‑800‑448‑7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Recall number 15V868000 · Recall details

What is wrong

Kingmor Supply, Inc. (Kingmor) is recalling certain model year 2005-2017 IC CE school buses manufactured September 1, 2005, to May 1, 2017, and modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk

If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy

Kingmor will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 18, 2015. Owners may contact Kingmor customer service at 1‑800‑782‑4474, or Ricon Customer Service at 1‑800‑322‑2884. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Recall number 15V772000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain model year 2015-2016 International 9900, DuraStar, LoneStar, PayStar, ProStar, WorkStar and 2015 International TranStar and IC Bus CE vehicles equipped with a Haldex air braking system. The affected brake actuators may have been manufactured with an incomplete attachment of the internal rubber diaphragm to the actuation mechanism. This could cause dragging or overheated brakes.

Risk

If the brakes drag and overheat there is an increased risk of a wheel end fire.

Remedy

Navistar will notify owners, and dealers will replace the Haldex Life Seal Brake chambers, free of charge. The recall began on June 19, 2015. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 15504. Note: This recall supersedes recall 14V‑806.

Recall number 15V165000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain model year 2013-2015 IC AE, 2007-2015 IC BE, CE, 2007-2011 IC FE, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Risk

If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy

Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1‑331‑332‑1590 or Ricon customer service at 1‑800‑322‑2884. Navistar's number for this recall is 14518.

Recall number 14V692000 · Recall details

What is wrong

Navistar, Inc.(Navistar) is recalling certain model year 2007-2015 IC CE transit buses manufactured January 23,2006, to May 12, 2014, 2008, and 2011 IC FE transit buses manufactured October 5, 2006, to September 28, 2009, and 2009-2010, and 2013 IC RE transit buses manufactured September 19, 2007, to November 29, 2011, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Risk

If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy

Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The interim notices were mailed on December 29, 2014. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1‑331‑332‑1590 or Ricon customer service at 1‑800‑322‑2884. Navistar's number for this recall is 14517.

Recall number 14V691000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain model year 2015 International Durastar vehicles manufactured May 9, 2014, to July 22, 2014, and 2015 IC Bus CE Commercial buses manufactured June 5, 2014, to June 6, 2014. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.

Risk

If the engine stalls unexpectedly there is an increased risk of a crash.

Remedy

Cummins will notify owners and dealers will replace the fuel filter with a non-defective one, free of charge. The notification schedule for this recall ran July 29 to December 31, 2014. Owners may contact Navistar customer service at 1‑800‑448‑7825 or Cummins customer service at 1‑800‑223‑4583. Cummins' number for this recall is C1545.

Recall number 14V572000 · Recall details

What is wrong

Navistar, Inc. is recalling certain model year 2012-2014 model year CE school buses manufactured December 31, 2010, through November 6, 2012, and equipped with Eaton-brand hybrid automated transmissions. The software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.

Risk

The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.

Remedy

Navistar will notify owners and Eaton authorized service facilities will update the Hybrid Control Module Software version, free of charge. The recall began on May 28, 2014. Owners may contact Navistar at 1‑331‑332‑1590.

Recall number 14V043000 · Recall details

What is wrong

Navistar Inc. (Navistar) is recalling certain model year 2010-2011 IC bus 3200, model year 2012 and 2014 IC bus CE and model year 2011-2013 IC bus HC transit buses and model year 2008-2013 International 4300 and model year 2013 International Workstar commercial trucks equipped with Eaton hybrid automated transmissions. The software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.

Risk

The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.

Remedy

Navistar will notify owners and Eaton authorized service facilities will update the Hybrid Control Module Software version, free of charge. The recall began on May 28, 2014. Owners may contact Navistar at 1‑331‑332‑1590.

Recall number 14V042000 · Recall details

What is wrong

Navistar Inc. is recalling certain model year 2014-2015 IC Bus CE and model year 2014 IC Bus RE transit buses manufactured August 12, 2013, through November 14, 2013 and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Risk

If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy

Navistar will notify owners, and dealers will inspect and replace the seat belt buckles, as necessary, free of charge. The recall is expected to begin by February 18, 2014. Owners may contact Navistar at 1‑800‑448‑7825. Navistar's number for this campaign is 13521.

Recall number 13V631000 · Recall details

What is wrong

Navistar, Inc. is recalling certain model year 2013-2014 IC Bus AE, and 2011-2014 BE, CE, and RE buses. These buses were manufactured February 11, 2010, through June 17, 2013. The passenger seat foam padding did not adequately reduce the impact forces to the knee in the lower outside corners of the seat back during compliance testing. Thus, these buses fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 222, "School Bus Passenger Seating and Crash Protection."

Risk

In the event of a crash, the seat padding may not properly protect against knee impact force, increasing the risk of injury.

Remedy

Navistar will notify owners, and dealers will install polystyrene blocks in the lower outside corners of each seat to increase the knee protection, free of charge. The recall began on October 10, 2013. Owners may contact Navistar at 1‑800‑448‑7825. Navistar's recall campaign number is 13512.

Recall number 13V308000 · Recall details

What is wrong

Navistar is recalling certain model year 2012-2013 IC Bus brand model 1300FBC, CE, HC, and RE buses; model year 2011-2013 International brand model Durastar, model year 2013 International brand Workstar trucks; model year 2013 Holiday Rambler brand model Ambassador and Endeavor vehicles; and model year 2013 Monaco brand model Diplomat and Knight vehicles. These vehicles were manufactured August 5, 2010 through September 6, 2012 and are equipped with certain 2011-2013 model year I-6 engines with feature codes 12NUK, 12NUL, 12NUM, 12NUN, 12NUP, 12NUR, 12NUS, 12NUT, 12NUU, 12NUV, 12NUX, 12NUY and 12NUZ. The injection pressure regulator (IPR) harness wire may break due to vibrational damage. This could cause an unexpected shut down of the engine.

Risk

An unexpected engine shut down while driving may increase the risk of a vehicle crash.

Remedy

Navistar will notify owners, and dealers will replace the IPR wire connector free of charge. The safety recall began on March 15, 2013. Owners may contact Navistar at 1‑800‑448‑7825.

Recall number 13V020000 · Recall details

What is wrong

Navistar is recalling certain model year 2011-2012 ic ce school buses manufactured from september 7, 2010 through september 9, 2010. The interior lower lining fails to comply with federal motor vehicle safety standard no. 221, “school bus body joint strength.”

Risk

In the event of a crash, there is an increased risk of personal injury to vehicle occupants.

Remedy

Navistar will notify owners, and dealers will inspect and retighten joint screws to the proper specification, free of charge. The recall began on july 23, 2012. Owners may contact navistar at 1‑260‑461‑1890.

Recall number 12V294000 · Recall details

What is wrong

Navistar is recalling certain model year 2012 and 2013 ic bus ce and re commercial buses manufactured from april1, 2011, through march 31, 2012, equipped with prolo roof escape hatches. Increased friction between the rear plate assemblies, p/no. 009327, and the nylon rear pop-up support, p/no. 008956, may result in an opening force of the prolo roof hatches that exceeds federal standard requirements. Thus, these hatches fail to conform to the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release."

Risk

In the event of an emergency, egress of the bus may be hindered possibly resulting in injury to the vehicle occupants.

Remedy

Navistar will notify owners. Specialty manufacturing, inc. (smi) will provide service kits along with repair instructions to dealers and owners, free of charge. The safety recall began on august 3, 2012. Owners may contact navistar at 1‑260‑461‑1890 or smi at 1‑800‑951‑7867.

Recall number 12V287000 · Recall details

What is wrong

Navistar is recalling certain model year 2012 and 2013 ic ce, re, and be school buses manufactured from april 1, 2011, through march 31, 2012, equipped with prolo roof escape hatches. Increased friction between the rear plate assemblies, p/no. 009327, and the nylon rear pop-up support, p/no. 008956, may result in an opening force of the prolo roof hatches that exceeds federal standard requirements. Thus, these hatches fail to conform to the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release."

Risk

In the event of an emergency, egress of the bus may be hindered possibly resulting in injury to the vehicle occupants.

Remedy

Navistar will notify owners. Specialty manufacturing, inc. (smi) will provide service kits along with repair instructions to dealers and owners, free of charge. The safety recall began on august 3, 2012. Owners may contact navistar at 1‑260‑461‑1890 or smi at 1‑800‑951‑7867.

Recall number 12V285000 · Recall details

What is wrong

Navistar is recalling certain model year 2012-2013 ic bus ce and re school buses manufactured from december 2, 2010, through january 26, 2012, and equipped with bendix atr-6 antilock traction relay valves. In extremely cold conditions, these bendix relay valves may potentially develop internal leakage. Internal leakage can lead to air pressure being delivered to affected primary or secondary brakes causing continuous brake application.

Risk

Unexpected continuous brake application can cause the driver to lose control of the vehicle, increasing the risk of a crash. Also, the brakes may be applied without illuminating the brake lights, failing to give proper warning to other drivers.

Remedy

Navistar will notify owners, and dealers will provide a temporary repair until bendix develops a permanent remedy. The safety recall began on april 40, 2012. This service will be performed free of charge. Owners may contact navistar at 260‑461‑1890.

Recall number 12V061000 · Recall details

What is wrong

Navistar is recalling certain model year 2011-2012 ic bus be and ce and certain model year 2012 re school buses manufactured from april 8, 2010 through july 1, 2011, equipped with c. E. White seat cushions. The self-latching mechanism used to retain the seat cushion to the frame may not activate. Thus, these seats fail to conform to the requirements of federal motor vehicle safety standard number 222, "school bus passenger seating and crash protection."

Risk

If the seat cushion is not securely latched to the seat structure, the seat could become dislodged, increasing the risk of injury to the vehicle occupants.

Remedy

Navistar will notify owners, and dealers will repair the seats free of charge. Owners may contact navistar at 260‑461‑1890.

Recall number 12V059000 · Recall details

What is wrong

Navistar is recalling certain model year 2007-2012 ic ce and be commercial buses manufactured from june 27, 2006, through march 23, 2011, equipped with a maxxforce 7 engine feature code 12nth, 12ntd, 12nte, 12ntg, 12vyy, or 12627 and alternator feature code 0008ggr, 0008ggm, 0008gwx, or 0008gel. The positive alternator cable may rub on the engine control module mounting bracket, possibly chafing its insulation and causing an electrical short.

Risk

An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death.

Remedy

Navistar will notify owners and dealers will inspect and replace, if necessary, the alternator cable. Tie straps will be installed to route the alternator cable away from the engine control module mounting bracket. These repairs will be performed free of charge. The safety recall began on september 27, 2011. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 11V428000 · Recall details

What is wrong

Navistar is recalling certain model year 2007-2012 ic ce and be school buses manufactured from june 27, 2006, through march 23, 2011, equipped with a maxxforce 7 engine feature code 12nth, 12ntd, 12nte, 12ntg, 12vyy, or 12627 and alternator feature code 0008ggr, 0008ggm, 0008gwx, or 0008gel. The positive alternator cable may rub on the engine control module mounting bracket, possibly chafing its insulation and causing an electrical short.

Risk

An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death.

Remedy

Navistar will notify owners, and dealers will inspect and replace, if necessary, the alternator cable and the installation of the tie straps to route the alternator cable away from the engine control module mounting bracket. Repairs will be performed free of charge. The safety recall began on september 27, 2011. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 11V427000 · Recall details

What is wrong

Navistar is recalling certain model year 2011 and 2012 ic ce and re school buses manufactured from october 8, 2009, through april 14, 2011. These buses were built without or incorrectly installed floor channel reinforcements. Accordingly, the buses fail to conform with the seat back rear force and displacement requirements of federal motor vehicle safety standard no. 222, "school bus passenger seating and crash protection."

Risk

Noncompliance to the standard increases the passenger's risk of rearward ejection from the seat which may cause personal injury or death in the event of a crash.

Remedy

Navistar will notify owners and dealers will repair the buses free of charge. The safety recall is expected to begin on or before september 16, 2011. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 11V368000 · Recall details

What is wrong

Navistar is recalling certain model year 2008 through 2012 ic be, ce, and fe school buses manufactured from november 1, 2006, through may 2, 2011. The reflective tape for the rear exit door may not have been totally completed. Accordingly, the buses fail to conform to the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release."

Risk

This noncompliance may reduce conspicuity of the rear door, reducing the ability of emergency personnel to identify and gain access to the rear exit during an emergency, possibly increasing the occupant's risk of personal injury or death during an emergency.

Remedy

Navistar will notify owners and dealers will inspect the buses and add reflective tape if necessary. The safety recall began on august 3, 2011. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 11V375000 · Recall details

What is wrong

Navistar is recalling certain model year 2011 and 2012 ic ce and be school buses manufactured from may 27, 2010, through march 8, 2011, equipped with maxxforce 7 engines. A cap on the return fuel valve may fall off, allowing air to be drawn into the fuel system, possibly resulting in engine hard start, no start, or stall conditions.

Risk

Engine stall on the roadway increases the risk of a vehicle crash.

Remedy

Navistar will notify owners and dealers will replace the return fuel valve cap free of charge. The safety recall is expected to begin on or about august 12, 2011. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 11V291000 · Recall details

What is wrong

Navistar is recalling certain model year 2011-2012 ic AC, be, ce, hc and international 4300, and terrastar commercial trucks manufactured from february 25, 2010, through april 4, 2011, and equipped with a maxxforce 7 engine. A cap on the return fuel valve may fall off allowing air to be drawn into the fuel system possibly resulting in engine hard start, no start, or stall conditions.

Risk

Engine stall on the roadway increases the risk of a vehicle crash.

Remedy

Navistar will notify owners and dealers will replace the return fuel valve cap free of charge. The safety recall began on july 18, 2011. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 11V290000 · Recall details

What is wrong

Navistar is recalling certain model year 2011 international commercial trucks models 4300 and 4400 and 2011 ic bus models ce and hc commercial buses manufactured from february 25, 2010, through september 20, 2010. The engine turbo oil supply line may rub on the frame rail possibly causing an oil leak in the engine compartment.

Risk

An oil leak in the engine compartment may cause a fire.

Remedy

Navistar will notify owners and international dealers will repair the buses free of charge. The safety recall is expected to begin on or about january 14, 2011. Owners may contact navistar 1‑800‑448‑7825.

Recall number 10V576000 · Recall details

What is wrong

Navistar is recalling certain model year 2011 ic bus ce school buses manufactured from february 25, 2010, through september 20, 2010. The engine turbo oil supply line may rub on the frame rail possibly causing an oil leak in the engine compartment.

Risk

An oil leak in the engine compartment may cause a fire.

Remedy

Ic bus will notify owners and ic bus dealers will repair the buses free of charge. The safety recall is expected to begin on or about january 14, 2011. Owners may contact ic bus at 1‑800‑448‑7825.

Recall number 10V574000 · Recall details

What is wrong

Navistar is recalling certain model year 2003 through 2010 international trucks and ic commercial buses manufactured from december 4, 2001 through december 14, 2009 equipped with international vt365 engines having engine calibration pan2pvr0, pan2pvr1, or pan2pwr. The engine normally responds to a failed open accelerator position sensor circuit fault by returning the engine to low idle speed of 800 RPM and disabling the driver's ability to increase the engine speed. However if the open circuit corrects itself within 30 seconds of initiation, engine speed could suddenly increase to a high idle speed of 1200 RPM.

Risk

This increase to high idle speed may occur without warning causing a sudden and unexpected shift in vehicle position possibly resulting in property damage, personal injury, or death.

Remedy

Navistar will notify owners and dealers will repair the vehicles free of charge. The safety recall began on july 1, 2010. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 10V267000 · Recall details

What is wrong

Navistar is recalling certain model year 2006 through 2008 ic be, re, and ce school buses manufactured from december 4, 2001 through december 14, 2009 equipped with international vt365 engines having engine calibration pan2pvr0, pan2pvr1, or pan2pwr. The engine normally responds to a failed open accelerator position sensor circuit fault by returning the engine to low idle speed of 800 RPM and disabling the driver's ability to increase the engine speed. However if the open circuit corrects itself within 30 seconds of initiation, engine speed could suddenly increase to a high idle speed of 1200 RPM.

Risk

This increase to high idle speed may occur without warning causing a sudden and unexpected shift in vehicle position possibly resulting in property damage, personal injury, or death.

Remedy

Navistar will notify owners and dealers will repair the vehicles free of charge. The safety recall began on july 1, 2010. Owners may contact navistar at 1‑800‑448‑7825..

Recall number 10V265000 · Recall details

What is wrong

Navistar is recalling certain model year 2010 ic be and ce school buses manufactured from april 22 through may 14, 2009, and fitted with certain ricon s series and k series l-model wheelchair lifts. Due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point.

Risk

When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.

Remedy

Navistar will notify owners and the repairs will be performed by authorized ricon dealers free of charge. A software solution for this safety defect is under investigation. Until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. The safety recall began on june 27, 2011. Owners may contact ricon at 1‑818‑267‑3000 or navistar at 1‑800‑448‑7825.

Recall number 10V258000 · Recall details

What is wrong

Navistar is recalling certain model year 2009 through 2011 ic ce, fe, re, and be model non school buses manufactured from december 10, 2007 through january 12, 2010 and fitted with ricon public use lifts. The restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. Ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. In this case, the restraint belt would appear to be latched, and the operator could run the lift. If the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.

Risk

The user of the lift could be injured should the lift move without the restraint belt properly buckled.

Remedy

Navistar is working with ricon and ricon will be performing the remedy for this campaign. Please see ricon's defect report 09e-060. Ricon will provide customers with a warning decal and a dvd-based training aid. The safety recall began on july 1, 2010. Owners may contact ricon at 1‑818‑267‑3000 or navistar at 1‑800‑448‑7825.

Recall number 10V257000 · Recall details

What is wrong

Navistar is recalling certain model year 2009 through 2011 ic ce, fe, re, and be model school buses manufactured from december 10, 2007 through january 12, 2010 and fitted with ricon public use lifts. The restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. Ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. In this case, the restraint belt would appear to be latched, and the operator could run the lift. If the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.

Risk

The user of the lift could be injured should the lift move without the restraint belt properly buckled.

Remedy

Navistar is working with ricon and ricon will be performing the remedy for this campaign. Please see ricon's defect report 09e-060. Ricon will provide customers with a warning decal and a dvd-based training aid. The safety recall began on july 1, 2010. Owners may contact ricon at 1‑818‑267‑3000 or navistar at 1‑800‑448‑7825.

Recall number 10V256000 · Recall details

What is wrong

Navistar is recalling certain model year 2011 ic ce school buses manufactured from january 19 through january 21, 2010 equipped with international maxxforce dt engines. The high pressure power steering hose may have been routed incorrectly possibly causing the hose to chafe on the power steering reservoir bracket potentially resulting in a power steering fluid leak in the engine compartment.

Risk

A high pressure power steering fluid leak in the engine compartment may cause a fire possibly resulting in property damage, personnel injury, or death.

Remedy

Navistar will notify owners and dealers will repair the buses free of charge. The safety recall began on june 11, 2010. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 10V221000 · Recall details

What is wrong

Navistar is recalling certain model year 2011 ic ce transit buses manufactured from february 22 through march 16, 2010 equipped with passenger flip seats. The weld that retains a reinforcement rod inside the seat back frame tube may fail allowing the rod to fall out of the frame. The seats fail to conform to the requirements of federal motor vehicle safety standard no. 222, "school bus passenger seating and crash protection."

Risk

Without the reinforcement rod, the strength of the seat may be compromised, increasing the risk of personal injury or death in the event of a crash.

Remedy

Navistar will notify owners and dealers will repair the seats free of charge. The safety recall began on july 16, 2010. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 10V220000 · Recall details

What is wrong

Navistar is recalling certain model year 2011 ic ce and re model school buses manufactured from february 22 through march 16, 2010 equipped with passenger flip seats. The weld that retains a reinforcement rod inside the seat back frame tube may fail allowing the rod to fall out of the frame. The seats fail to conform to the requirements of federal motor vehicle safety standard no. 222, "school bus passenger seating and crash protection."

Risk

Without the reinforcement rod, the strength of the seat may be compromised, increasing the risk of personal injury or death in the event of a crash.

Remedy

Navistar will notify owners and dealers will repair the seats free of charge. The safety recall began on july 16, 2010. Owners may contact navistar at 1‑800‑448‑7825 .

Recall number 10V217000 · Recall details

What is wrong

Navistar has notified the federal safety agency about a defect in certain model year 2010 and 2011 ic ce, hc, and be commercial buses and international 1300, 3200, 3300, 4100, 4200, 4300, 4400, and mxt trucks manufactured from november 19, 2003 through february 9, 2010. The parking brake may release if the brake system electronic control unit (ecu) software misinterprets input signals generated from cycling the ignition switch more than once at a specific frequency.

Risk

Release of the parking brake may cause sudden, unexpected shift in vehicle position possibly resulting in property damage, personal damage, or death.

Remedy

Navistar will notify owners and will repair the vehicles by reprogramming the vehicle's brake system ecu free of charge. The safety recall began on april 14, 2010. Owners may contact navistar at 1‑260‑461‑1890.

Recall number 10V104000 · Recall details

What is wrong

Navistar has notified the federal safety agency about a defect in certain model year 2010 and 2011 ic ce, be, and fe school buses manufactured from november 19, 2003 through february 9, 2010. The parking brake may release if the brake system electronic control unit software misinterprets input signals generated from cycling the ignition switch more than once at a specific frequency.

Risk

Release of the parking brake may cause sudden, unexpected shift in vehicle position possibly resulting in property damage, personal damage, or death.

Remedy

Navistar will notify owners and will repair the buses by reprogramming the vehicle's brake system ecu free of charge. The safety recall began on april 2, 2010. Owners may contact navistar at 1‑260‑461‑1890.

Recall number 10V103000 · Recall details

What is wrong

Navistar is recalling 3,449 ic school buses manufactured between march 1, 2008 and february 1, 2009, equipped with specialty manufacturing, inc. (smi) 000290 LED light kits. A change to the wire used in the LED light kits may reduce the effective life of the lights used on the stop arms. The lights may stop functioning without warning.

Risk

Should the LED lights stop functioning, visibility of a stopped bus would be decreased, possibly endangering a child or pedestrian to injury by passing vehicles.

Remedy

Navistar will notify owners and the buses will be repaired free of charge. Repairs will be performed by smi. The safety recall began on september 19, 2009. Owners may contact smi warranty service at 1‑800‑951‑7867 or navistar toll-free at 1‑800‑448‑7825.

Recall number 09V293000 · Recall details

What is wrong

Navistar is recalling 630 model year 2009 and 2010 ic school and commercial buses manufactured between february 1, 2008 and july 6, 2009, equipped with trans/air air conditioning systems. Each trans/air system comes with an electrical kit and ec pc board which if improperly installed could overheat.

Risk

Overheating of the pc board could result in a fire.

Remedy

Navistar will notify owners and the vehicles will be repaired free of charge. Repairs will be performed by trans/air. The safety recall is expected to begin on or about september 11, 2009. Owners may contact trans/air warrant and service department at 1‑800‑673‑2448 or navistar toll-free at 1‑800‑448‑7825.

Recall number 09V292000 · Recall details

What is wrong

Navistar is recall 7,521 my 2009 international model trucks and my 2009 and 2010 ic school and transit buses manufactured from april 1, 2008 to december 12, 2008, equipped with a horton 2-speed fan drive, identified by feature code 12tht. The fasteners that connect the magnet brackets to the air chamber housing of the 2-speed engine fan could fail resulting in the magnet bracket being thrown from the fan drive and the vehicle at high speed.

Risk

The bracket could separate and strike a person or motor vehicle resulting in property damage, personal injury, and/or death.

Remedy

Navistar will notify owners and repair the vehicles by replacing the engine fan drive air chamber and magnet brackets free of charge. The safety recall is expected to begin on or about june 1, 2009. Owners may contact navistar toll-free at 1‑800‑448‑7825.

Recall number 09V101000 · Recall details

What is wrong

Navistar is recalling 61,316 my 2001 through 2009 ic be, ce, and fe model commercial and school buses manufactured between february 2, 2000 and june 2, 2008, equipped with an entrance door stepwell heater feature code 0048pms or 0548001 and/or a rear wall mounted heater feature code 0048tar or 0048psx. The affected heater units may fail in low speed operation causing elevated temperatures.

Risk

Elevated temperatures can result in a fire, possibly resulting in property damage, personal injury, or death.

Remedy

An interim letter was mailed on february 20, 2009, to communicate the defect and recommend action to mitigate the risk until the final remedy and customer notification could be provided at a later date. The manufacture filed an amended defect report dated march 27, 2009 advising that a final remedy has been developed and parts are being manufactured. The safety recall began on june 2, 2009. Owners may contact navistar toll-free at 1‑800‑448‑7825.

Recall number 09V052000 · Recall details

What is wrong

Navistar is recalling 24,975 my 2003 through 2008 ic be, ce, hc, and re school and commercial buses and 2002 through 2008 international 3200 and 3300 model buses manufactured between september 21, 2001 through december 14, 2007, equipped with international vt365 engines. These vehicles may exhibit engine hard start, no start, or stall conditions due to possibly damaged terminals in the fuse holder connector of the injector drive module (idm) clean battery power circuits. The terminals may have been damaged during electrical continuity testing in the manufacturing process.

Risk

These conditions could result in a vehicle crash, possibly resulting in personal injury.

Remedy

Navistar will notify owners and replace the idm fuse holder free of charge. The recall began on october 3, 2008. Owners can contact navistar toll-free at 1‑800‑448‑7825.

Recall number 08V353000 · Recall details

What is wrong

Navistar is recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. The potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination intrusion. If the encapsulation is compromised, water and contaminants may cause an internal electrical short, possibly resulting in a fire.

Risk

A fire could cause personal injury or death.

Remedy

Navistar will notify owners and repair the vehicles free of charge. The recall began on july 10, 2008. Owners may contact navistar at 1‑280‑461‑1890.

Recall number 08V258000 · Recall details

What is wrong

Certain my 2004 through 2007 ce and be school buses and 1300 and 3300 model vehicle chassis manufactured by ic corporation between march 17, 2004, and may 15, 2006. The park brake system may activate while the vehicle is under normal operation. Although the vehicle is brought to a stop, the activation may occur without warning or input from the driver and may strand the vehicle in an active lane. The spring applied, hydraulic release (sahr) park brake actuator could experience a hydraulic lock condition that will not allow the park brake to apply.

Risk

Should the park brake activate and strand the vehicle, it may contribute to a vehicle crash, possibly resulting in property damage, personal injury, or death. Should the park brake not apply, a vehicle roll away can occur and may result in a crash, possibly resulting in property damage, personal injury, or death.

Remedy

Dealers will repair the buses free of charge. The recall began july 7, 2006. Owners may contact ic corporation at 800‑322‑2884 or owners may contact international at 1‑800‑448‑7825.

Recall number 06V189000 · Recall details

What is wrong

Certain 2005-2007 ce and my 2007 be school and transit buses manufactured between february 10, 2004, and december 15, 2005. Passenger coat strings or carry on items can get caught between the door control bracket and the door control arm as the passenger exits the bus.

Risk

If the driver is unaware of the situation, the entrance door may be closed, capturing the item in the door. Death or injury could occur to the person exiting the bus.

Remedy

Ic will notify its owners and repair all the buses free of charge. The recall began march 2, 2006. Customers may contact international at 800‑448‑7825.

Recall number 05V561000 · Recall details