2012 Ic Bus Re technical service bulletins
124 technical service bulletins and manufacturer communications cover the 2012 Ic Bus Re.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Suggested alignment target values when performing a vehicle axle alignment.
- Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison...
- J1939 Data Link Source Address Information
- Diagnosis of chassis wander complaints.
- General Wheel Speed Sensor Troubleshooting
- Bus seat back foam inspection guidelines
- How to request a horsepower quote; all International and Cummins engines
- J1939 Data Link Troubleshooting
- Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles...
- J1939 Data link source address information
- Pico Scope CCOS (Crankcase Separator Test)
- PicoScope Test
- PicoScope Test for Datalink (CAN) Health Shorts & opens
- PicoScope Test Resistance and Ohmmeter
- PicoScope Test One Channel RCT
- ECM Calibration for DPF Replacement; Applies to MaxxForce Engines
- Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
- Engine Oil Capacities
- General wheel speed sensor troubleshooting
- Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
- ECM Calibration for DPF Replacement; only trucks and busses built with 2007- 2009 MaxxForce DT/9/10....
- Driveline Information Center and Troubleshooting Procedures
- Repair Procedures for Vehicles Struck by Lightning
- This article is for adding additional protection to the driver's area of the bus to help mitigate the...
- Factory Installed Air Conditioning, EC4.0 System operating instructions and the service manual
- Bus Air Conditioning Service Contacts for HVAC Information
- Cleaning and Disinfecting Trucks and Buses
- Sound Off Bus Monitor Lamps Not Illuminating While Circuits and Exterior Lights are Operating and Test Good
- Bus Strobe Light Replacements
- Bus Body Entry Door Switch, LH Panel Mounted
- Oil Capacities; All Electronic International Engines 1994
- Suspension Lean Diagnostics; All models
- Suggested alignment target values when performing a vehicle axle alignment
- Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure
- Bus Door Adjustment procedure for Electric and Air; only models built 09/15/11 or later
- Bus Door Adjustment procedure for Electric and Air
- Fuel Fired Engine Coolant Heaters
- Aggressive Brakes with Air Brake Foot Valve Leak on Bus; only models with feature code 04WEA
- How to Get from History and Program a BCM or ESC; only models equipped with a BCM or ESC
- Applying Advanced Logic Templates; only models equipped with a BCM or ESC
- Engine Oil Capacities All Electronic International Engines 1994
- Radio Diagnostics and Information
- Diagnosis and repair of intermittent operation of the Child Checkmate reset button.
- Cylinder Performance Analyzer (CPA) Resource Center
- A/C Refrigerant and Oil Capacities
- Optional Fuel Fired Engine Coolant Heaters fuel fired engine coolant heaters may require the fuel system...
- Bus Body Tie Down, Floor Sill Repair
- Updating OnCommand Link with Accelerator
- Bus Passenger Window Troubleshooting; only buses built after 4/17/17
- Winter Front Usage
- Engine Oil Capacities
- OnCommand EZ-Tech
- Bus with ISB Frequent Regeneration; only models with Cummins ISB engine
- Bus Door Adjustment procedure for Electric and Air; only Models Built 9/15/11 or later
- Driver?s seat belt tongue button; Only with Seat Belt Part numbers 4091405c1 thru 4091408c1
- Using Supplier Software to Check DTCs
- Bus Entrance Door Adjustment Procedures; only models built prior to 9/15/2011
- EZ-Tech Download Center
- Determine Wheel Speed or Driveline Vibration using a Smart Phone and Free VibSensor Application
- How To Get A Helios Capture
- Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
- Using Vehicle Health Report Faults
- OnCommand EZ-Tech Download Center
- Troubleshooting & Resetting HVAC Doors; only vehicles with Feature Codes 0016WCT and 0016WCS
- 2010 MaxxForce 7 engine DPF Cracking
- Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information
- Battery Testing, Diagnostics, and Maintenance information
- Diagnostic Interface Cable Reference Guide
- First Check to make when Troubleshooting any Body Controller or ESC Issue
- NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
- IC Bus Service Brake Switch Inspection
- Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR...
- HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
- Dealer EZ-Tech and Diagnostic Software Support Resource Center
- CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
- OnCommand EZTech
- SCR Vehicles Setting 3363-16 (FC1713) due to Crossed DEF Tank Coolant Lines or Inverted DEFTHV
- Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
- How to Diagnose Electrical Problems with Diamond Logic Builder; only models equipped with a BCM or ESC
- Steering Fluids
- Cooling System Flush Procedure
- Radiator internal restriction and flush procedure
- MaxxForce 7 Fuel Dilution Diagnostics
- Iros suspension auxiliary leaf spring rattle
- Ricon Public Use,"S" 2000 and 5500 Series lift recall
- Engine Won?t Shut Off with the Key 5 amp Fuse Blowing
- Change in Seat Belt Manufacturer
- Windshield Glass Discoloration (Fogging)
- Post Trip Inspection System Will Not Disarm or Does Not Operate Correctly; excludes Child Reminder System...
- ESPAR AirTronic Low Run Time.
- DPF Snap Accel Test
- Factory Installed Air Conditioning, EC4.0 System
- Only vehicles equipped with davco fuel pro 382; technical manual installation diagnostics and service
- Driver and passenger seat belts
- Torque change for 5/8 inch rear axle shaft flange mounting stud with cone locks and flat washer type hardware.
- IC Bus Electric Entrance Door Fuse
- Surge Tank De-Aeration Hose Installation; only models with 2010 EPA MaxxForce DT engine
- Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
- The occupant of the adjacent seat located to the rear of the flip seat could suffer a pinch point injury...
- Hydraulic Reservoir Fluid Sight Tube
- Fuel Cooler Valve (FCV) Screen Removal to Reduce High Fuel Temperature; only Vehicles Built Prior to 01...
- RE Model IC Bus Surge Tank De-Aeration Hose Installation
- Certain driver side restraining barriers may not meet one of the forward push criteria of FMVSS 222 or...
- The lower outside corners of the passenger seat back may not have sufficient padding to conform to all...
- Ammeter gauge showing a negative reading at all times; only models built with option code 16HJB
- Master Disconnect and Noise Kill Solenoid Replacement; only BE, CE Built Prior to April 2012, RE Built...
- Factory Installed Air Conditioning, EC4.0 System operating instructions and service manual; only models...
- Passenger Seat Back Pan Inspection and Repair
- Gauges Drop out or Freeze Intermittently
- Hydraulic Cooling Fan Diagnostics
- Navistar: the recalibration of engine electronic control module (ECM) is required to be updated, with...
- Hydraulic Hose and Alternator Area Maintenance
- Fuel Fired Engine Coolant Heaters may require the fuel system to be primed prior to use.
- Aftertreatment Resource Center; All models equipped with EPA 2007 and newer engines
- Bus Door Adjustment procedure for Electric and Air; only models built on 9/15/2011 and later
- Navistar: greater force may be needed, on certain buses, to open an emergency roof mounted exit, for...
VIN decoder
See the problems and recalls for an exact car
Buying a used 2012 Ic Bus Re?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history