International 4100 recalls

What is wrong

Navistar is recalling certain model year 2003 through 2010 international trucks and ic commercial buses manufactured from december 4, 2001 through december 14, 2009 equipped with international vt365 engines having engine calibration pan2pvr0, pan2pvr1, or pan2pwr. The engine normally responds to a failed open accelerator position sensor circuit fault by returning the engine to low idle speed of 800 RPM and disabling the driver's ability to increase the engine speed. However if the open circuit corrects itself within 30 seconds of initiation, engine speed could suddenly increase to a high idle speed of 1200 RPM.

Risk

This increase to high idle speed may occur without warning causing a sudden and unexpected shift in vehicle position possibly resulting in property damage, personal injury, or death.

Remedy

Navistar will notify owners and dealers will repair the vehicles free of charge. The safety recall began on july 1, 2010. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 10V267000 · Recall details

What is wrong

Navistar has notified the federal safety agency of a defect on certain model year 2008-2011 international trucks equipped with an optional jump start stud. Corrosion at the base of the stud may cause an electrical short between the stud and battery box.

Risk

An electrical short may cause a vehicle fire.

Remedy

A final remedy has been established. Navistar will notify owners, and dealers will repair the vehicles by installing a new jump start stud. Repairs will be preformed free of charge. An interim action will involve the removal of the jump start stud and the connecting cable. The safety recall began on september 10, 2010. Owners may contact international dealers at 1‑800‑448‑7825.

Recall number 10V107000 · Recall details

What is wrong

Navistar has notified the federal safety agency about a defect in certain model year 2010 and 2011 ic ce, hc, and be commercial buses and international 1300, 3200, 3300, 4100, 4200, 4300, 4400, and mxt trucks manufactured from november 19, 2003 through february 9, 2010. The parking brake may release if the brake system electronic control unit (ecu) software misinterprets input signals generated from cycling the ignition switch more than once at a specific frequency.

Risk

Release of the parking brake may cause sudden, unexpected shift in vehicle position possibly resulting in property damage, personal damage, or death.

Remedy

Navistar will notify owners and will repair the vehicles by reprogramming the vehicle's brake system ecu free of charge. The safety recall began on april 14, 2010. Owners may contact navistar at 1‑260‑461‑1890.

Recall number 10V104000 · Recall details

What is wrong

Navistar is recalling 977 my 2009 international 3200, 4100, 4300, 4400 trucks and ic bus hc commercial buses. The front axle bearings in some cases were not sufficiently lubricated during assembly which may result in bearing seizing or possible wheel separation.

Risk

A seized bearing on the front axle could result in a vehicle crash which may result in property damage, personal injury, or death.

Remedy

Dealers will inspect the front axle bearings. Bearings will be lubricated and replaced if required. The recall began on december 19, 2008. Owners may contact navistar at 1‑800‑448‑7825.

Recall number 08V619000 · Recall details