The worst 2004 International 7600 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
Recalls 6
Engine and engine cooling
- What is wrong
- On certain heavy duty trucks equipped with caterpillar diesel engines, the engine electrical ground cable that connects the engine block with the starter may be routed in a way that could cause chafing against the starter's positive battery cables.
- Risk
- If chafing occurs between the positive and negative cables, an electrical short may result and may cause a vehicle fire, possibly resulting in property damage, personal injury or death.
- Remedy
- Dealers will inspect the engine ground cables for proper routing. If any chafing is found, the engine block ground cable will be replaced with a shorter (280mm) cable and any other damaged cables will be replaced and routed correctly free of charge. The recall began on december 21, 2005. Owners may contact international at 1‑800‑448‑7825.
Recall number 05V567000 · Recall details
Trailer hitches: fifth wheel assembly
- What is wrong
- On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. This could result in inadvertent operation of the fifth wheel slide control.
- Risk
- If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning.
- Remedy
- Dealers will relocate the msva 7-pack to a less water intensive environment. A new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. The recall began on august 5, 2005. Owners may contact international at 1‑800‑448‑7825.
Recall number 05V188000 · Recall details
Structure
- What is wrong
- On certain trucks, the bolts that mount the front of the cab to the mounting brackets were not properly torqued at the manufacturing plant.
- Risk
- These bolts can loosen during normal vehicle use and fall out. This may lead to the cab separating from the vehicle's chassis during a vehicle crash that may result in property damage, personal injury or death.
- Remedy
- As an interim action, dealers will properly tighten the existing cab mounting bolts and replace any missing bolts. As soon as parts are available, dealers will replace all sixteen bolts and tighten them properly. An interim letter was sent to owners on february 11, 2005. Another letter was sent to owners on april 8, 2005, as soon as parts are available. Owners should contact international at 1‑800‑448‑7825.
Recall number 04V569000 · Recall details
Electrical system: 12v/24v/48v battery: cables
- What is wrong
- On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar I-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.
- Risk
- This could cause an electrical short and/or fire.
- Remedy
- Dealers will inspect for any chafing. If there is no evidence of chafing, a saddle clamp will be installed. If there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. The recall began on august 16, 2004. Owners should contact international at 1‑800‑448‑7825.
Recall number 04V306000 · Recall details
Seat belts: front: buckle assembly
- What is wrong
- Certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 209, "seat belt assemblies." the seat belt latch failed a quality review.
- Risk
- This could cause the seat belt latch to become disengaged without warning in a vehicle crash or during episodes of high seat belt loading.
- Remedy
- Dealers will replace the seat belt assemblies. Owner notification is began on june 11, 2004. Owners should contact international at 1‑800‑445‑7825.
Recall number 04V193000 · Recall details
Parking brake
- What is wrong
- Certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 121, "air brake systems." a standard fitting was installed in place of a single check valve on the park brake relay valve.
- Risk
- This could result in the parking brake not releasing and stopping the vehicle increasing the risk of a crash.
- Remedy
- Dealers will install the check valve. Owner notification began on may 3, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1‑800‑448‑7825.
Recall number 04V191000 · Recall details
Technical service bulletins for the 2004 International 7600 95
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article provides guidance to dealership personnel, Technical Services personnel, Dealer Service...
- This tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files
- Engine replacements for all International engines will need to follow this procedure.
- This document will guide the user through a step-by-step procedure for detecting water leaks in vehicle...
- This document will guide the user through understanding Prop Shaft Codes and understanding the variations...
- In some geographic areas, ambient temperatures reaching below 15°F (-10 °C), including high levels of...
- Title: Service Portal iKNow Feedback Case Types Applies To: All
- Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
- Title: A/C Refrigerant and Oil Capacities Applies To: All current models
- Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
Compare the 2004 International 7600
Other model years
Questions about the 2004 International 7600
Is the 2004 International 7600 reliable?
Owners have filed 0 complaints about the 2004 International 7600.
What is the most common problem with the 2004 International 7600?
There are not enough complaints to tell.
How many recalls does the 2004 International 7600 have?
6 recalls, covering engine and engine cooling, trailer hitches and structure.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 International 7600?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history