International 8500 recalls

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk

Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.

Remedy

Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23514.

Recall number 23V353000 · Recall details

What is wrong

Navistar has notified the federal safety agency of a defect on certain model year 2008-2011 international trucks equipped with an optional jump start stud. Corrosion at the base of the stud may cause an electrical short between the stud and battery box.

Risk

An electrical short may cause a vehicle fire.

Remedy

A final remedy has been established. Navistar will notify owners, and dealers will repair the vehicles by installing a new jump start stud. Repairs will be preformed free of charge. An interim action will involve the removal of the jump start stud and the connecting cable. The safety recall began on september 10, 2010. Owners may contact international dealers at 1‑800‑448‑7825.

Recall number 10V107000 · Recall details

What is wrong

Navistar is recall 7,521 my 2009 international model trucks and my 2009 and 2010 ic school and transit buses manufactured from april 1, 2008 to december 12, 2008, equipped with a horton 2-speed fan drive, identified by feature code 12tht. The fasteners that connect the magnet brackets to the air chamber housing of the 2-speed engine fan could fail resulting in the magnet bracket being thrown from the fan drive and the vehicle at high speed.

Risk

The bracket could separate and strike a person or motor vehicle resulting in property damage, personal injury, and/or death.

Remedy

Navistar will notify owners and repair the vehicles by replacing the engine fan drive air chamber and magnet brackets free of charge. The safety recall is expected to begin on or about june 1, 2009. Owners may contact navistar toll-free at 1‑800‑448‑7825.

Recall number 09V101000 · Recall details

What is wrong

International is recalling 34,993 my 2006-2008 school and transit buses and heavy duty trucks/tractors manufactured between june 1, 2006 and june 28, 2007, equipped with international dt466 or dt570 engines. The base plate of the engine oil cooler may crack allowing pressurized oil to leak into the engine compartment.

Risk

This condition may cause either engine shut down without warning, or in extreme cases, possible engine fire which can lead to property damage, personal injury, or death.

Remedy

International will notify owners and repair the vehicles free of charge. The recall began on november 21, 2008. Owners may contact international at 800‑448‑7825.

Recall number 08V089000 · Recall details

What is wrong

On certain trucks, one or both rear axle housings may contain thinner material than what is necessary for normal vehicle operation. Over time, this thinner material may result in a fatigue failure of the rear axle housing, possibly in the location of the brake flange.

Risk

A crack in the brake flange location of the rear axle housing may result in a wheel end lockup or wheel separation possibly resulting in property damage, personal injury, or death.

Remedy

Dealers will inspect the vehicle's rear axles and, if necessary, replace the axle housings. The recall began on may 18, 2007. Owners may contact international at 1‑800‑448‑7815.

Recall number 07V179000 · Recall details

What is wrong

On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. This could result in inadvertent operation of the fifth wheel slide control.

Risk

If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning.

Remedy

Dealers will relocate the msva 7-pack to a less water intensive environment. A new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. The recall began on august 5, 2005. Owners may contact international at 1‑800‑448‑7825.

Recall number 05V188000 · Recall details

What is wrong

On certain trucks, the bolts that mount the front of the cab to the mounting brackets were not properly torqued at the manufacturing plant.

Risk

These bolts can loosen during normal vehicle use and fall out. This may lead to the cab separating from the vehicle's chassis during a vehicle crash that may result in property damage, personal injury or death.

Remedy

As an interim action, dealers will properly tighten the existing cab mounting bolts and replace any missing bolts. As soon as parts are available, dealers will replace all sixteen bolts and tighten them properly. An interim letter was sent to owners on february 11, 2005. Another letter was sent to owners on april 8, 2005, as soon as parts are available. Owners should contact international at 1‑800‑448‑7825.

Recall number 04V569000 · Recall details

What is wrong

On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar I-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.

Risk

This could cause an electrical short and/or fire.

Remedy

Dealers will inspect for any chafing. If there is no evidence of chafing, a saddle clamp will be installed. If there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. The recall began on august 16, 2004. Owners should contact international at 1‑800‑448‑7825.

Recall number 04V306000 · Recall details

What is wrong

Certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 209, "seat belt assemblies." the seat belt latch failed a quality review.

Risk

This could cause the seat belt latch to become disengaged without warning in a vehicle crash or during episodes of high seat belt loading.

Remedy

Dealers will replace the seat belt assemblies. Owner notification is began on june 11, 2004. Owners should contact international at 1‑800‑445‑7825.

Recall number 04V193000 · Recall details