2002 International 9200I Problems: 0 Complaints, 4 Recalls

The worst 2002 International 9200I problems

Ranked by number of owner complaints. Mileage and cost come from what owners wrote.

Tap a problem to see which part fails, at what mileage and in which other years.

Exterior lighting: back up lightsReported May 18, 2023 · 32,880 vehicles affected

What is wrong: Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23514.

Recall number 23V353000 · Recall details

Electrical system: wiring: front underhoodReported June 30, 2004 · 7,610 vehicles affected

What is wrong: On certain heavy duty trucks, the engine electrical harness can chafe against sharp edges on the engine.
Risk: Sudden acceleration, activation of the engine compression brake, engine speed dropping to idle, alternator overload with possible fire, and a loss of engine ECM power resulting in engine shutdown could occur without warning.
Remedy: Dealers will inspect the harness to determine if it is damaged. If damaged, the engine harness will be repaired. All harnesses will be re-routed and stand-off brackets will be added. The recall began on september 8, 2004. Owners can contact international at 1‑800‑448‑7825.

Recall number 04V307000 · Recall details

Equipment: recreational vehicle/trailerReported February 27, 2004 · 83,312 vehicles affected

What is wrong: On certain conventional trucks equipped with pro-sleeper berths, water intrusion can be found in the bunk control panel area and pool in the tops of the dome light, tv/vcr, and or refrigerator power switches.
Risk: The circuit boards in the switches could heat up , possibly produce a flame or fire, and cause property damage, personal injury, or death.
Remedy: Dealers will install a water shield over the back of the entire bunk control panel. Owner notification began on july 16, 2004. Owners should contact international at 1‑800‑448‑7825.

Recall number 04V100000 · Recall details

Trailer hitches: fifth wheel assemblyReported June 18, 2003 · 13 vehicles affected

What is wrong: On certain heavy duty trucks equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.
Risk: If left undetected or corrected it could lead to the separation of the fifth wheel top plate from its mounting structure, possibly resulting in a crash
Remedy: Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jost international at 616‑846‑7700 or by email to [email protected] or international at 1‑800‑448‑7825.

Recall number 03V220000 · Recall details

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

Is the 2002 International 9200I reliable?

Owners have filed 0 complaints about the 2002 International 9200I.

What is the most common problem with the 2002 International 9200I?

There are not enough complaints to tell.

How many recalls does the 2002 International 9200I have?

4 recalls, covering exterior lighting, electrical system and equipment.

See the problems and recalls for an exact car

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.