International MV recalls

What is wrong

International Motors, LLC (International) is recalling certain 2027 HV, HX, LT, MV, and RH trucks. A retaining nut in the wiper assembly may loosen, causing both windshield wipers to disconnect from the motor.

Risk

Inoperative windshield wipers can reduce the driver's visibility, increasing the risk of a crash.

Remedy

Dealers will tighten the wiper motor drive nut and three motor mounting bolts, free of charge. Owner notification letters were mailed September 21, 2026. Owners may contact International customer service at 1‑331‑332‑5000. International's number for this recall is 26513.

Recall number 26V516000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2021, 2023-2027 MV, and 2026-2027 HV vehicles. The battery interconnect cable may contact the auxiliary stud and hold down bracket, causing a short circuit.

Risk

A short circuit increases the risk of a fire.

Remedy

Dealers will install plastic saddles onto the positive interconnect cable, install wind laces and a J-bolt between each battery, free of charge. Owner notification letters were mailed October 26, 2026. Owners may contact International customer service at 1‑800‑448‑7825. International's number for this recall is 26510. This recall replaces and expands the federal safety agency Recall 25V534. Vehicles previously repaired under 25V534 will need the new remedy completed.

Recall number 26V459000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2026-2027 MV vehicles. The ECU software may fail to engage the brakes with adaptive cruise control (ACC) or hill hold assist.

Risk

A vehicle that does not automatically brake as expected increases the risk of a crash.

Remedy

Dealers will update the brake ECU software, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact International's customer service at 1‑800‑448‑7825. International's number for this recall is 26501. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on beginning April 6, 2026.

Recall number 26V084000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2016 7600, 2016-2023 Lonestar, 2018 8600, 2018-2023 LT, 2021-2026 MV, 2022-2023 RH, 2023-2026 HX, and 2025-2026 HV vehicles. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.

Risk

Safety systems that depend on the ECU, such as Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System, may have diminished or lost functionality, increasing the risk of a crash.

Remedy

International will work with Bendix to reprogram the ECU, free of charge. Owner notification letters were mailed January 19, 2026. Owners may contact International's customer service at 1‑800‑448‑7825. International's number for this recall is 25525. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on beginning January 12, 2026.

Recall number 25V817000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2026 MV commercial trucks. The transmission shift actuator may not have been calibrated properly, preventing the transmission from shifting into reverse.

Risk

The truck may be unable to move as needed on the road, increasing the risk of a crash.

Remedy

Dealers will replace the shift actuator input shaft, free of charge. Owner notification letters were mailed December 8, 2025. Owners may contact International customer service at 1‑800‑448‑7825. International's number for this recall is 25519.

Recall number 25V702000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2026 MV vehicles. The battery interconnect cable may contact the auxiliary stud and hold down bracket, causing a short circuit.

Risk

A short circuit increases the risk of a fire.

Remedy

Dealers will install three wind laces on the battery hold down and add a J-bolt between each battery to ensure 3 mm of terminal clearance, free of charge. Owner notification letters were mailed October 10, 2025. Owners may contact International customer service at 1‑800‑448‑7825. International's number for this recall is 25513.

Recall number 25V534000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2018 International 4000 Series 4300, 2017-2025 MV, 2018-2024 1300 FBC, 2018-2025 IC Bus TC, and 2024-2025 IC Bus CECB vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Risk

An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Remedy

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a silicone black jumper harness, free of charge. Owner notification letters are expected to be mailed December 15, 2025. Owners may contact International customer service at 1‑800‑448‑7825. International's number for this recall is 25509. Vehicles previously repaired under 23V397 will need to have the new remedy completed.

Recall number 25V502000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2025-2026 HV, HX, LT, MV, RH, and 2025 EMV vehicles. The linkage that connects the right-side wiper arm to the motor may separate, causing the wipers to fail.

Risk

Windshield wiper failure can reduce driver visibility, increasing the risk of a crash.

Remedy

Dealers will replace the wiper module, free of charge. Owner notification letters were mailed June 2, 2025. Owners may contact International customer service at 1‑800‑448‑7825. International's number for this recall is 25505.

Recall number 25V276000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2024 HV, 2020-2025 MV, and 2019 Workstar 7400 trucks. The caliper may contact a suspension spring or axle U-bolt and prevent the outer brake pad from functioning.

Risk

A loss of outer brake pad function can extend the vehicle's stopping distance, increasing the risk of a crash.

Remedy

Dealers will switch the left and right rear air disc brake calipers, replace the rear brake torque plates, and replace the brake pads, free of charge. Owner notification letters were mailed May 12, 2025. Owners may contact International customer service at 1‑800‑448‑7825. International's number for this recall is 25501.

Recall number 25V178000 · Recall details

What is wrong

International Motors, LLC (International) is recalling certain 2021-2024 Lonestar, 2021-2025 RH, HV, MV, LT, HX, and 2022 PROSTAR vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.

Risk

Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.

Remedy

International will work with Bendix to reprogram the ECU software, free of charge. Owner notification letters were mailed December 16, 2024. Owners may contact International customer service at 1‑800‑448‑7825. International's number for this recall is 24515.

Recall number 24V818000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2025 International HV, HX, LT, MV, and RH vehicles. The tie rod assemblies may contain ball studs that have been incorrectly heat-treated, which can cause them to break, and possibly result in tie rod failure.

Risk

Tie rod failure can cause a loss of vehicle steering control and increase the risk of a crash.

Remedy

Dealers will replace the tie rod end and re-align the front axle, free of charge. Owner notification letters were mailed September 9, 2024. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 24511.

Recall number 24V556000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2025 International HV, LT, MV, and RH trucks. Tie rod assemblies may contain ball studs that may have been incorrectly heat-treated, which can cause them to break, and possibly result in tie rod failure.

Risk

Tie rod failure can cause a loss of vehicle steering control and increase the risk of a crash.

Remedy

Dealers will replace the tie rod ends and realign the front axle, free of charge. Owner notification letters were mailed July 29, 2024. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 24509.

Recall number 24V462000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2025 International HV, HX, LT, and MV vehicles. The steering gear sector shaft may have been improperly heat-treated, which can cause the gear teeth to crack or fracture.

Risk

Fractured steering gear teeth can cause a loss of steering control, increasing the risk of a crash.

Remedy

Dealers will replace the steering gears, free of charge. Owner notification letters were mailed September 30, 2024. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 24505.

Recall number 24V164000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2024 International HX, LT, RH and 2024-2025 International HV, MV trucks and 2024 IC Bus CE commercial buses. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.

Risk

A loss of steering control increases the risk of a crash.

Remedy

Dealers will inspect and replace the defective gears, free of charge. Owner notification letters were mailed September 30, 2024. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 24503.

Recall number 24V088000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2024 International HV and International MV trucks. The driver's seat belt tether bolt may not be properly seated in the anchor, causing a bind at the anchor point.

Risk

An improperly anchored seat belt tether may not restrain an occupant as intended, increasing their risk of injury during a crash.

Remedy

Dealers will inspect and replace the seat belts as necessary, free of charge. Owner notification letters were mailed February 26, 2024. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 24501.

Recall number 24V026000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2023 International MV and International HV vehicles. The driveshafts can break under certain loading conditions.

Risk

A broken driveshaft can separate and cause a loss of drive power, increasing the risk of a crash.

Remedy

Dealers will replace the driveshafts, free of charge. Owner notification letters are expected to be mailed October 16, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23520.

Recall number 23V587000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, 2018-2020 and 2023-2024 International 1300FBC Stripped chassis, 2019-2022 IC Bus CE Commercial bus, 2019-2024 IC Bus TC Commercial bus, and 2019-2024 International MV vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Risk

An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Remedy

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch and if necessary, the wire harness or fuse, free of charge. Owner notification letters were mailed September 29, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23517.

Recall number 23V397000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021-2024 International HV, HX, LoneStar, LT, MV, eMV, and RH trucks, and IC Bus CE, 2021-2023 IC Bus RE, and 2022-2023 IC Bus TC Commercial Buses. The anti-lock brake system (ABS) indicator light does not remain illuminated when a malfunction exists, and when the vehicle's ignition switch is on, and the vehicle is in motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Risk

An ABS indicator light that fails to remain illuminated will not alert the driver of an ABS malfunction, which could increase the risk of a crash.

Remedy

Towing variant vehicles under this campaign will not be repaired under recall 24V-8918. Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 24, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23515.

Recall number 23V370000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk

Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.

Remedy

Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23514.

Recall number 23V353000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2023 International MV trucks. The driveshaft tube seam weld may separate or tear, resulting in drive line separation and a sudden loss of drive power.

Risk

A sudden loss of drive power can increase the risk of a crash.

Remedy

Dealers will replace the driveshafts, free of charge. Owner notification letters are expected to be mailed July 3, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23513.

Recall number 23V322000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2023 International HV and 2023-2024 International MV vehicles. The assembly bolts used to attach the battery box to the mounting bracket may be loose or missing.

Risk

Loose or missing bolts can allow the battery box to detach from the vehicle and become a road hazard, increasing the risk of a crash.

Remedy

Dealers will replace and tighten all four bolts, as necessary, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23506.

Recall number 23V154000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2023 International HV and 2023-2024 International MV vehicles. The rear axle spring wedge shim may have been incorrectly installed, which can cause U-joint failure and result in driveshaft separation.

Risk

Driveshaft separation can cause a loss of drive power and increase the risk of a crash.

Remedy

Dealers will reinstall the rear axle wedge shim, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23505.

Recall number 23V153000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2022-2024 International HV, International MV trucks, and 2022-2023 IC Bus TC commercial buses. When the parking brake is applied, the automatic transmission is still in drive or reverse position, and the stationary power take-off (PTO) switch is engaged by the operator, the engine may rev and overcome the parking brake's ability to keep the vehicle from moving.

Risk

Unexpected vehicle movement can increase the risk of a crash or injury.

Remedy

Dealers will update the Cummins ECM software, free of charge. Owner notification letters are expected to be mailed April 24, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23504. This recall expands previous the federal safety agency recall number 20V‑810.

Recall number 23V120000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2018-2021 International HV, 2019-2021 International RH, 2019-2022 International MV, and 2022 International HX vehicles. A software error in the Body Control Module (BCM) may allow the vehicle to overcome the park brake during power-take-off (PTO) operation.

Risk

A parking brake that does not hold can allow the vehicle to move unexpectedly and increase the risk of a crash or injury.

Remedy

Dealers will update the BCM software, free of charge. Owner notification letters are expected to be mailed April 24, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 23503.

Recall number 23V119000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021-2022 International CV, 2022-2023 International HV, 2023 IC 1300 FBC, CE, RE, TC, International MV, HX, LT, RH, and LoneStar vehicles. The hex flange lock nuts, used in the suspension and steering joints, were improperly heat treated and may lose tension over time.

Risk

A loss of tension in the steering and suspension joints may lead to steering instability and increase the risk of a crash.

Remedy

Dealers will replace the hex flange lock nuts as necessary, free of charge. Owner notification letters are expected to be mailed January 20, 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 22524.

Recall number 22V869000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021-2023 International MV vehicles. The high voltage positive cables that connect the battery packs to the manual service disconnects (MSD) may have been mislabeled.

Risk

A misidentified electrical cable may be mistaken for a de-energized cable by a technician or first responder, increasing the risk of electrical shock and injury.

Remedy

Dealers will reinstall the battery cables and replace the associated warning labels, free of charge. Interim owner notification letters were mailed January 13, 2023. Remedy parts are expected to become available 1st Quarter of 2023. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 22522.

Recall number 22V849000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2023 International MV vehicles. The locking clips of the wheel hub retaining nut may have been damaged during installation, which may cause the wheel hub to loosen and separate from the axle housing.

Risk

A wheel hub that separates from the axle housing may increase the risk of a crash.

Remedy

Dealers inspected the hub retaining nuts for damage and replaced them, as necessary, free of charge. All affected vehicles have been remedied and therefore no owner notification letters will be mailed. Owners may contact Navistar's customer service at 1‑800‑448‑7825. Navistar's number for this recall is 22521.

Recall number 22V834000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2023 International LT, International Lonestar, International MV, International HV, International HX, and IC Bus TC Commercial buses. The engine control module (ECM) may experience an internal electrical short-circuit, causing the engine to stall.

Risk

An unexpected engine stall can increase the risk of a crash.

Remedy

Cummins will replace the ECM. Owner notification letters were mailed September 26, 2022. Owners may contact Navistar customer service at 1‑800‑448‑7825.

Recall number 22V609000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2022-2023 International HX, HV, LoneStar, LT, MV, RH, IC TC Commercial Bus, and 2022 International WorkStar vehicles. The steering gears may have been assembled incorrectly, which can cause the gear to fracture.

Risk

A fractured steering gear can cause a loss of steering control, increasing the risk of a crash.

Remedy

Dealers will inspect the steering gear serial numbers, and replace the steering gears as necessary, free of charge. Interim owner notification letters were mailed August 18, 2022. Remedy parts are expected to become available in mid-October 2022. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 22513.

Recall number 22V428000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2022-2023 International MV, International HV, and 2022 IC RE commercial buses built without a forward radar unit. The warning label notifying the driver that the collision mitigation system is inoperative may be missing.

Risk

Failure to warn the driver that the collision mitigation system is inoperative increases the risk of a crash.

Remedy

Navistar will provide a warning label and installation instructions, free of charge. Owner notification letters were mailed June 14, 2022. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 22508.

Recall number 22V282000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2018-2019 International WorkStar, International DuraStar, 2019-2021 International HV, International MV, and IC Bus RE Commercial Bus vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Risk

A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

Dealers will inspect the rail threads, and replace the rail as necessary, free of charge. Owner notification letters were mailed on June 21, 2021. Owners may contact Navistar customer service at 1‑800‑448‑7825.

Recall number 21V366000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021 International LT, RH, MV, and HV vehicles equipped with Bendix pressure switches. A retainer was not properly seated in the SC-3 single check valve and may not provide source air isolation when pressure is applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Risk

Unintended spring brake application may occur, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will replace the SC-3 check valves, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 21503.

Recall number 21V227000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2019-2021 International MV, 2020-2021 International HV, 2014-2020 International DuraStar and 2015-2018 International WorkStar vehicles. When the parking brake is applied and the automatic transmission is still in the drive or reverse position and the stationary PTO switch is engaged by the operator, the engine may rev and overcome the parking brake's ability to keep the vehicle from moving.

Risk

Unexpected Vehicle movement can increase the risk of a crash or injury.

Remedy

Navistar will notify owners, and dealers will update the parameters in the Cummins ECM for feature codes 12VXT or 12VXU that enables the PTO neutral interlock, free of charge. The recall began February 17, 2021. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 20510.

Recall number 20V810000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2021 International MV and HV vehicles equipped with feature code 10EWW, 10EYD, 10HYR, or 10JPJ (Fifth wheel, stationary), 10HJA (Fifth wheel, air slide) or 10WDN (Fifth wheel mounting angles). The vehicles may not have had sections of reflective tape applied to the right and left upper contours of the cab. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamp, Reflective Devices, and Associated Equipment."

Risk

Without the reflective strips, a truck operating without a trailer at night may be less visible, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will install reflective tape to the back of the cab, free of charge. The recall began October 21, 2020. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 20508.

Recall number 20V584000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2017-2020 International WorkStar and International DuraStar, 2018-2019 IC 1300 FBC Commercial and IC HC Commercial, 2018-2021 IC CE Commercial, International MV and International HV, and 2019-2021 IC TC Commercial buses with Cummins B6.7 diesel engines with a fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Risk

A fire increases the risk of injury. An engine stall can increase the risk of a crash.

Remedy

Cummins will notify the affected Navistar customers and dealers will disable the fuel heater by either installing a plug in place of the heater or otherwise rendering the fuel heater inoperable and removing the fuse supplying electrical power to the fuel heater and installing a cover over the wire harness connector, free of charge. The recall began May 28, 2020. Owners may contact Cummins customer service at 1‑800‑286‑6467.

Recall number 20V219000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2019-2020 International MV and HV, 2018-2020 Workstar, and 2018-2019 Durastar vehicles equipped with feature codes 12VXT and 12VXU. With the parking brake applied and the automatic transmission in the 'Drive' or 'Reverse' position, when the stationary PTO switch is engaged by the operator, the engine RPM will ramp up and may overcome the parking brake's ability to hold the vehicle.

Risk

Unintended vehicle movement increases the risk of a crash.

Remedy

Navistar will notify owners, and dealers will update the Engine Control Module to enable the PTO neutral interlock, free of charge. The recall began January 16, 2020. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 19518.

Recall number 19V841000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2017-2020 International DuraStar and WorkStar, 2018-2020 IC Bus CECB, International HV and MV, 2018-2019 IC Bus 1300 FBC and HCCB, and 2019-2020 IC Bus TCCB vehicles equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Risk

A fire increases the risk of injury. An engine stall can increase the risk of crash.

Remedy

Cummins will notify the affected Navistar owners. Cummins dealers will replace the fuel heater with a newly designed fuel heater, free of charge. The recall began May 2, 2019. Owners may contact Cummins customer service at 1‑800‑286‑6467 or Navistar customer service at 1‑800‑448‑7825.

Recall number 19V216000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2019 International HV, MV, 2018-2019 HX, LT, RH, LoneStar, ProStar, WorkStar, and 2018 TranStar automated manual transmission vehicles, equipped with certain Eaton ECA heavy-duty truck clutches. An internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement.

Risk

Unintended vehicle movement can increase the risk of a crash.

Remedy

Navistar will notify owners, and dealers will recalibrate the Transmission Control Module (TCM), free of charge. The recall began January 18, 2019. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 18518.

Recall number 18V826000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2019 International MV and 2018-2019 International HV trucks equipped with option for combined trailer stop and turn lights. When a trailer is connected to one of the affected vehicles, the trailer brake lights may not illuminate when the truck's brakes are used.

Risk

If the trailer brake lights fail to illuminate, other drivers may not be warned of the vehicle slowing, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will relocate the trailer brake light circuits from the trailer turn signal circuits to the vehicle brake light circuits, free of charge. The recall began October 23, 2018. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 18514.

Recall number 18V644000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2019 International HX, DuraStar, WorkStar, HV, LoneStar, LT, MV, and RH vehicles, and IC Bus HC, CE, and RE vehicles equipped with long stroke brake chambers and spring actuated parking brakes. The spring actuated parking brake may be improperly crimped to the long stroke service brake chamber, causing a service brake air leak and the possible separation of the spring brake chamber from the service brake section.

Risk

An air leak or separation of the spring brake chamber can increase the needed stopping distance, increasing the risk of a crash.

Remedy

Navistar will notify owners, and dealers will replace the brake chamber assemblies from the suspected lot, free of charge. The recall began October 23, 2018. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 18512.

Recall number 18V597000 · Recall details

What is wrong

Navistar, Inc. (Navistar) is recalling certain 2018-2019 International WorkStar, DuraStar, LoneStar, LT, ProStar, RH and IC Bus HC, 2018 International TranStar, 2019 International HV and MV trucks and transit buses. The front driver and passenger seat belt anchor D-ring bolt may break in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Risk

If the D-ring bolt breaks during a crash, the seat occupant may not be properly restrained, increasing their risk of injury.

Remedy

Navistar has notified owners, and dealers will replace the D-ring bolt depending on the information found on the seat belt label, free of charge. The recall began May 23, 2018. Owners may contact Navistar customer service at 1‑800‑448‑7825. Navistar's number for this recall is 18505.

Recall number 18V293000 · Recall details