2003 International Prostar technical service bulletins
137 technical service bulletins and manufacturer communications cover the 2003 International Prostar.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article provides guidance to dealership personnel, Technical Services personnel, Dealer Service...
- This tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files
- This article equips technicians with the knowledge and steps needed to efficiently replace and program...
- Engine replacements for all International engines will need to follow this procedure.
- This document will guide the user through a step-by-step procedure for detecting water leaks in vehicle...
- This document provides: Steps to take when switch pack programming fails, or when switch pack disappears...
- This document will guide the user through understanding Prop Shaft Codes and understanding the variations...
- In some geographic areas, ambient temperatures reaching below 15°F (-10 °C), including high levels of...
- Title: Service Portal iKNow Feedback Case Types Applies To: All
- Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
- Title: A/C Refrigerant and Oil Capacities Applies To: All current models
- Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
- Title: Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition...
- Title: Steering Gear Seal Repair Guidelines Applies To: Steering gears
- Title: Vehicle Programming Information for Engine: Single Box 1998-2004 I6 & V8 Applies To: Single Box...
- Title: How to Request a Horsepower Quote Applies To: All International and Cummins Electronic engines
- This document reminds technicians of the critical relationship between the truck's suspension and the...
- Applies To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of...
- This article addresses chassis lean conditions on all chassis
- Suggested alignment target values when performing a vehicle axle alignment.
- Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison...
- Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles...
- J1939 Data link source address information
- PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
- PicoScope Test
- PicoScope Test for Datalink (CAN) Health Shorts & opens
- PicoScope Test Resistance and Ohmmeter
- PicoScope Wheel Speed Sensor Test
- PicoScope Test One Channel RCT
- Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
- Engine Oil Capacities
- General wheel speed sensor troubleshooting
- Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
- Suggested alignment target values when performing a vehicle axle alignment
- Driveline Information Center and Troubleshooting Procedures
- Repair Procedures for Vehicles Struck by Lightning
- A/C Refrigerant and Oil Capacities
- Cleaning and Disinfecting Trucks and Buses
- J1939 Data Link Troubleshooting
- Bendix EC80 Blank Module Replacement Program;
- Driver Information Display (VIS/DID) screen fails to boot up.
- LT / ProStar Fuel Tank Unable to Fill; only sleeper models
- Oil Capacities; All Electronic International Engines 1994
- Suspension Lean Diagnostics; All models
- J1939 Data Link Source Address Information
- Hendrickson Assembly Instructions; Transverse Torque Rods
- Improved Bushings for Hendrickson Torque Rods
- Tool Instruction
- Engine Oil Capacities All Electronic International Engines 1994
- Radio Diagnostics and Information
- The fire extinguishers may become clogged or require excessive force to activate
- Updating OnCommand Link with Accelerator
- ISX, N13, and N9 / N10 Aftertreatment Private Data Link Troubleshooting
- Winter Front Usage
- Engine Oil Capacities
- OnCommand EZ-Tech
- Using Supplier Software to Check DTCs
- Trailer Auxiliary Switch Lamp Burning Out; Only Vehicles Equipped with Feature Code 0008TTH or 0008THG
- NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
- Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR...
- HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
- Dealer EZ-Tech and Diagnostic Software Support Resource Center
- CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
- OnCommand EZTech
- Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
- OnCommand EZ-Tech Download Center
- Steering Shake, Shimmy, Shudder, or Steering Vibration; only with 14k front weight rated axles and below
- Steering Fluids
- Cooling System Flush Procedure
- J1939 Data Link Troubleshooting; Only Models with 250k Baud Data Link (Black 9 Pin Diagnostic Connector)
- To Get A Helios Capture; All 1939 and 1708 multiplexed trucks only
- Radiator internal restriction and flush procedure
- Wind noise at upper side door
- Tech Tip to aid technicians in the efficient removal and installation of a TC10 transmission
- Davco fuel pro 382 technical manual, installation, diagnostics, and service
- Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- Front Blower Motor Runs Breifly At Initial Power Up
- Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts
- Eaton Clutch Information
- ESPAR AirTronic Low Run Time.
- Navistar: steering wheel will not have shift controls due to phoenix shifter being programmed to look for...
- Dual Fuel Tank Transfer Pump System With Two Wire Pump Troubleshooting; equipped with feature 595192 built...
- Navistar: trucks equipped with electric fuel transfer pump for two tanks, the fuel is balance between both...
- The First Check to make when Troubleshooting any Body Controller or ESC Issue
- Navistar: some navistar prostar vehicles with the cummins isx 15L engines installed were built with the...
- Cluster Software Update Instructions
- Ik: repair information regarding the missing or loose bolt attaching horton stratis anti rotation bracket...
- Wind noise at upper side door
- Cowl tray seal; only built prior to 11/11/2013
- Cluster Issues
- 1939 Data Link Troubleshooting
- Transmission Keeps Shifting and Display Keeps Flashing After Ignition is Turned Off; only with Freedom...
- Headlight Condensation or Frost; excludes sealed beam headlights such as on WorkStar, Paystar and 9900i)
- City Horn Blows When Driver Shuts off Truck and Walks Away; only equipped with with ESC or Body Controller
- Body Controller/ESC Software Updates
- International: three inch fuel tank fill cap gasket cracking
- Iknow: information concerning the suspension dump feature
- International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is...
- Water entry into the cab / Adding Cowl tray seal; models built prior to 11/11/2013
- Navistar: the brake lights stay on and are not working
- Iknow: stratis fan hub diagnostics
- International: there are code faults, caused by load shedding, loaded in other modules and unit goes into...
- International: weldon tail lights are replacing the truck lite on some trucks built before 2/21/13
- Adjustment Procedure for Tilt Only Steering Column; only models with Feature code 0005708
- Iknow: repair procedures for complaints of foul odors in the cab
- Iknow: the battery cube fuse stud terminal with the alternative part needs to be replaced
- Iknow: install kit in order to alleviate loose, vibrating, or rattling of the hood-mounted mirrors
- Iknow: prostar brake assembly conversion
- Iknow: replacing truck -lite tail lights with weldon tail lights
- How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
- Iknow: sleeper side sill/underbody cross-member weld check and repair
- International: information regarding the fuel system components and repairs to correct interference to...
- International: information being provided regarding the rusting of power steering hoses that needs to be...
- International: battery cables routed too close to spring hanger shackle bolt for left-sided battery box or...
- International: spring hanger shackle bolt may have battery cables routed too close for left sided battery...
- Incorrect 5AMP fuse at location F11-D on wabco 6 sensor 6 modulater
- Navistar: HVAC front inside module drain repair
- Navistar: maxxforce 11, 13, and 15 recalibration to adress frequent warning lights
- Navistar: troubleshooting for intermittent or no front blower operation
- International: lower front shock mount bending on prostar s models (113) bbc w/all engines and prostar...
- International: brake pedal not returning and sticking slightly in the applied position
- International: fixed vent window 016HKR replacement and rebonding instructions
- International truck: intermittent or no front blower operation
- International: icon will not function properly
- Navistar: various types of vehicles including lonestar, prostar, 8600, and 7600 vehicles will need an...
- Navistar: mislocated torque rod bracket on certain prostar and 9000 models
- Navistar: power steering intermediate shaft u joint end play measurement.
- Navistar: prostar power steering cooler hoses.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2003 International Prostar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history