2011 International Prostar technical service bulletins
492 technical service bulletins and manufacturer communications cover the 2011 International Prostar.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article provides guidance to dealership personnel, Technical Services personnel, Dealer Service...
- The new clusters in the post-2007 models store the mileage in memory
- This document enables technicians to: 1. Accurately identify second generation MaxxForce medium duty...
- New CARB Idle Reduction Change Request
- This tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files
- This document provides guidance for assessing the feasibility of implementing a customer-requested change...
- This document will guide the user through Mass Air Flow (MAF) calibration procedure
- Engine replacements for all International engines will need to follow this procedure.
- This document will guide the user through a step-by-step procedure for detecting water leaks in vehicle...
- This document provides: Steps to take when switch pack programming fails, or when switch pack disappears...
- This document describes the process for utilizing the CPA High Pressure Fuel Pump (HPFP) Test
- In some geographic areas, ambient temperatures reaching below 40°F (4°C), including high levels of...
- This document will guide the user through understanding Prop Shaft Codes and understanding the variations...
- In some geographic areas, ambient temperatures reaching below 15°F (-10 °C), including high levels of...
- Title: Service Portal iKNow Feedback Case Types Applies To: All
- Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
- Title: A/C Refrigerant and Oil Capacities Applies To: All current models
- Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
- Title: Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition...
- Title: Steering Gear Seal Repair Guidelines Applies To: Steering gears
- Title: How to Request a Horsepower Quote Applies To: All International and Cummins Electronic engines
- This document reminds technicians of the critical relationship between the truck's suspension and the...
- Applies To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of...
- This article addresses chassis lean conditions on all chassis
- This document is to guide users to eliminate brake pedal rattle noise.
- This document covers battery diagnostics, maintenance and storage requirement.
- This document details the procedure that must be followed to ensure proper alternator troubleshooting.
- Suggested alignment target values when performing a vehicle axle alignment.
- Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison...
- J1939 Data Link Source Address Information
- Rebuilding Cylinder Heads on Certain MaxxForce 11/13, N13, and A26 engines; 2010 to present.
- Diagnosis of chassis wander complaints.
- General Wheel Speed Sensor Troubleshooting
- How to request a horsepower quote; all International and Cummins engines
- J1939 Data Link Troubleshooting
- Snap-On torque wrench requirement for all big bore engine connecting rod bolts; A26, MaxxForce 13, N13 engines
- New air compressor incorporates an oil feed dowel O-ring
- New Air compressor Incorporates an oil feed dowel O-ring; only models built with MaxxForce 11/13, N13, or...
- Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles...
- Rebuilding cylinder heads on certain EPA 2010 MaxxForce 11/13, N13, and A26 Engines
- Rebuilding Cylinder Heads on Certain International MaxxForce 11/13 engines and all International N13 and...
- J1939 Data link source address information
- Turbocharger oil supply tube retrofit; only models with 2010 emissions MaxxForce 11 and 13 engines and N13...
- Pico Scope CCOS (Crankcase Separator Test)
- PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
- PicoScope Test
- PicoScope Test for Datalink (CAN) Health Shorts & opens
- PicoScope Test Resistance and Ohmmeter
- PicoScope Wheel Speed Sensor Test
- PicoScope Test One Channel RCT
- Textured surfaces on painted plastic bumpers, chassis side skirts, and fender extendtions
- Primer recommendation for matching textured panels to smooth panels for field repairs
- Cab water leak troubleshooting tips; HX with steel cab only
- Calculating pulses per mile (speedometer setting); only models equipped with International engines
- ECM Calibration for DPF Replacement; Applies to MaxxForce Engines
- High Pressure Fuel Pump external leaks from weep hole
- Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
- Engine Oil Capacities
- Oil leaks at the Bottom of the Oil Filter Module; Only International A26, N13, or 2010 and newer 11 and 13...
- Cab water leak troubleshooting tips
- General wheel speed sensor troubleshooting
- Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
- Steering Shake, Shimmy, Shudder, Wobble, Steering Vibration; only models built with 14K weight rated axles...
- Suggested alignment target values when performing a vehicle axle alignment
- A26, N13, and 2010 EPA MaxxForce 11 and 13 engine Auxiliary Programable Parameters
- ECM Calibration for DPF Replacement; only trucks and busses built with 2007- 2009 MaxxForce DT/9/10....
- Cab Lean Concern
- Driveline Information Center and Troubleshooting Procedures
- Repair Procedures for Vehicles Struck by Lightning
- Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
- MaxxForce 15L Engine Oil Leaks; an aid in repairing engine oil leaks on the MaxxForce 15L engine.
- Cab Odor Service Plan Information; only models equipped with EPA 2010 or later MaxxForce 11 or MaxxForce...
- A/C Refrigerant and Oil Capacities
- Cleaning and Disinfecting Trucks and Buses
- Bendix EC80 Blank Module Replacement Program;
- MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; Only sleeper cab models with feature code 16UZL
- Stand Alone Real Time (SART) Module Diagnostics
- Driver Information Display (VIS/DID) screen fails to boot up.
- LT / ProStar Fuel Tank Unable to Fill; only sleeper models
- Steering Shake, Shimmy, Shudder, Steering Vibration
- Oil Capacities; All Electronic International Engines 1994
- Suspension Lean Diagnostics; All models
- Only truck models built with 2010 MaxxForce 15 engine
- The First Check to make when Troubleshooting any Body Controller or ESC Issue
- Steering Shake, Shimmy, Shudder, or Steering Vibration; only with 14k front weight rated axles and below
- Cab Water Leak Troubleshooting Tips; Excluding 9000i, PayStar(HX), CityStar, or LoadStar
- Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure
- ProStar Electrical System Load Shed Feature 08XEV
- Wind noise at upper side of cab door
- Steering Shake, Shimmy, Shudder, Steering Vibration; only models with 14k front weight rated axles and below
- Brake Lights Staying On
- Programing New Key Fobs
- Hendrickson Assembly Instructions; Transverse Torque Rods
- Air Pressure Gauges and A/C Pressure Transducer Troubleshooting
- Build to VIN Wiring Harnesses
- Improved Bushings for Hendrickson Torque Rods
- FLR-10
- Tool Instruction
- Engine Oil Capacities All Electronic International Engines 1994
- Radio Diagnostics and Information
- Espar Airtronic Heater Diagnostic Guide; only models with Feature code 16VTV
- Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure;...
- Auto Start Stop Troubleshooting; only ProStar with feature code 0008TSJ
- Cab Water Leak Troubleshooting Tips; primarily for Sleeper cab models and some aspects may also apply to...
- The fire extinguishers may become clogged or require excessive force to activate
- Updating OnCommand Link with Accelerator
- ISX, N13, and N9 / N10 Aftertreatment Private Data Link Troubleshooting
- Winter Front Usage
- Engine Oil Capacities
- OnCommand EZ-Tech
- Using Supplier Software to Check DTCs
- Trailer Auxiliary Switch Lamp Burning Out; Only Vehicles Equipped with Feature Code 0008TTH or 0008THG
- NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
- Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR...
- HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
- MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; models equipped with feature 16UZL
- Auto Start Stop Troubleshooting; only LT and ProStar with feature code 0008TSJ
- Dealer EZ-Tech and Diagnostic Software Support Resource Center
- Auto Start Stop Troubleshooting; only models with feature code 0008TSJ Auto Start Stop
- CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
- OnCommand EZTech
- Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
- OnCommand EZ-Tech Download Center
- Parasitic Battery Load and Predelivery Storage Recommendations
- DM harness inspection; Only with Steering Column feature code 05710
- Steering Fluids
- Cooling System Flush Procedure
- Offensive Odors Inside Cabin
- Mirror / Map Light / Visor LED Lighting Up when CB MIC is Keyed
- J1939 Data Link Troubleshooting; Only Models with 250k Baud Data Link (Black 9 Pin Diagnostic Connector)
- To Get A Helios Capture; All 1939 and 1708 multiplexed trucks only
- Power window binding
- Air compressor retrofit for prostar models equipped with 2010 epa and newer maxxforce 11 & 13 engines and...
- New brake light operation; prostar and lonestar with air brakes
- The on board diagnostic (OBD) data stored for purposes of defining required maintenance or repair may be...
- Radiator internal restriction and flush procedure
- Prostar sleeper cab strut noise or air leaks
- Power Window Binding
- Wind noise at upper side door
- Air Conditioning Electrical Diagnostics
- 2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
- Driveline
- Brake Light Operation on HPV, ProStar and LoneStar
- Adding an Electronic Trailer Brake Controller
- Tech Tip to aid technicians in the efficient removal and installation of a TC10 transmission
- Brake Single Hot Wheel End Service Procedure
- Performing relative compression test and misfire test with cpa tool
- Misfire diagnostics ibb; SPN132(X)
- Davco fuel pro 382 technical manual, installation, diagnostics, and service
- Exhaust manifold service procedures
- Service parts damaged new turbocharger oil supply tube
- Mirror / Map Light / Visor LED Lighting Up when CB MIC is keyed
- Fan Shaft Failure Diagnostics with feature code 12THX (Viscous Fan Drive)
- Active Faults During Load Shed
- Retrofiting a Horton VMaster(Stratis) fan drive to Horton 2spd air operated fan drive on N13 or MaxxForce...
- Espar D5
- Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- The fifth wheel and its locking mechanism may be susceptible to cumulative damage resulting in the fifth...
- Vorad VS-400
- Vibration Troubleshooting
- Change in Seat Belt Manufacturer
- Hard to Crank Condition with Hydraulic Clutch Linkage and Solo Clutch
- Standard to Heavy Duty Brake Chamber Replacement
- ESPAR Preventative Maintenance / Inpection
- Symptom 1: No Idle HVAC Cools but Operates Incorrectly
- Symptom 3: NoIdle HVAC Inoperative
- Symptom 5: NoIdle HVAC Blows Warm Air
- Mirror Repair Procedures and Replacement Parts Availability
- Lt EGR
- Retrofiting a Horton VMaster(Stratis) fan drive to Horton 2spd air operated fan drive on MaxxForce 13 and...
- Dash Cluster Lamp Operation, Functions and Regeneration Instructions, With International engines
- Newer Brake Light Operation
- Front Blower Motor Runs Breifly At Initial Power Up
- A jump start or electrical load dump event could result in an overvoltage condition of the cab Linear...
- Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts
- Rear S Cam Tube / Bracket part update
- N13, MaxxForce 11, 13 engine Two Cylinder Air Compressor Testing
- HVAC faults 520211 and 520465
- Eaton Clutch Information
- ESPAR AirTronic Low Run Time.
- DPF Snap Accel Test
- International: information regarding issue with power windows failing to operate properly or power doors...
- Navistar: steering wheel will not have shift controls due to phoenix shifter being programmed to look for...
- Grille/Bug Screen Rubbing Against A/C Condenser
- Vehicle Air Conditioning Diagnostics (Start Here)
- Air Conditioning Mechanical Pressures Diagnostics
- Coolant odor in cab with rear HVAC; equipped with Feature 0595BJN or 0595BWZ
- Dual Fuel Tank Transfer Pump System With Two Wire Pump Troubleshooting; equipped with feature 595192 built...
- Dual Fuel Tank Transfer Pump Troubleshooting on Post-2007 NGV and ProStar
- Davco Fuel Filter Replacements Recommendation for Maxx Force 11 and 13, 2010 Engines
- HVAC Diagnostic Information
- MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; equipped with Feature 16UZL
- Charge Air Cooler Outlet Temperature Sensor Damaged; equipped with N13, MaxxForce 11, 13 engines
- No-Idle HVAC Operational Check
- Symptom 2: No-Idle HVAC Fault Codes
- Symptom 3: No-Idle HVAC Inoperative
- Symptom 4: No-Idle HVAC Digital Display Inoperative
- Symptom 5: No-Idle HVAC Blows Warm Air
- Navistar: some navistar prostar vehicles with the cummins isx 15L engines installed were built with the...
- Air pressure gauges and a/c pressure transducer troubleshooting
- 2010 and newer vehicle air conditioning diagnostics (start here)
- Charge air cooler outlet temperature sensor damaged; equipped with N13, maxxforce 11, 13 engines
- Mirror repair procedures and replacement parts availability
- Air conditioning mechanical pressures diagnostics
- Newer brake light operation
- Espar heater diagnostic guide
- Cluster Software Update Instructions
- Air Conditioning Control Head Diagnostics
- Air Conditioning Diagnostics
- ProStar and NHPV with Suspension Dump feature code 595ACA or 595BBC
- MaxxForce 15 ECM recalibration to improve exhaust aftertreatment, Exhaust Gas Recirculation (EGR) valve,...
- No Idle HVAC Solution Parts Identification; only with feature 16UZL No Idle HVAC
- Compressor Relay and Power Harness Upgrade; only with feature 16UZL No Idle HVAC
- Rear A/C Blows Warm Air
- Rear A/C Control Panel Inoperative
- Sleeper Fan and Sleeper TEMP Switch Inoperative
- Maxxpower no idle battery-powered a/c system diagnostic guide; models equipped with feature 16UZL
- Radio diagnostics and information
- Temperature radiator diagnostics
- Battery discharge during extended storage; prostar equipped with feature 0008WEN
- Ik: repair information regarding the missing or loose bolt attaching horton stratis anti rotation bracket...
- Air conditioning electrical diagnostics
- Air conditiong control head diagnostics
- Vehicle air conditioning diagnostics
- Wind noise at upper side door
- Cowl tray seal; only built prior to 11/11/2013
- International truck: the fuel level is not equal between tanks
- HVAC diagnostic information
- Cluster Issues
- Horton VMaster Ultra (Stratis) Viscous Fan Hub Diagnostics and Troubleshooting Guide
- 2010 and later HVAC Diagnostic Information
- Collision Avoidance Wingman FLR-10 to FLR 20 Retrofit
- International: truck hard to crank due to clutch bearing contacting clutch brake prior to clutch release...
- 1939 Data Link Troubleshooting
- Wipers and Aftertreatment Lights Inop on Post 2007 Trucks with Body Controller
- Activate HVAC Front Blower Message In Dash Message center; with Sleeper cab only
- International: there are issues of missing complete engine air supply line and also missing t fitting with...
- Sleeper HVAC blower will not run on high with engine off; with Sleeper cab only
- 2010 Dash Cluster Lamp Operation with new DPF Lamp Locations , Functions and Regeneration Instructions
- New Synthetic Oil for Eaton and Spicer Transmissions; only with Eaton or Spicer transmissions
- Transmission Keeps Shifting and Display Keeps Flashing After Ignition is Turned Off; only with Freedom...
- Roll Pins Backing Out of Bell Crank; Only with manual transmission
- LUK/Ixetic Power Steering Pump Fittings; only Vehicles equipped with Maxxforce 11, 13 engines
- Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics; Only equipped with Maxxforce 11, 13 engines
- In Chassis Cleaning Procedure for Cooling Package in All Models with MaxxForce 11, 13 Engines
- Headlight Condensation or Frost; excludes sealed beam headlights such as on WorkStar, Paystar and 9900i)
- Clutch Linkage Rattle
- ZF Sachs Twin XTend clutch; only Vehicles with heavy-duty ZF Sachs Twin XTend Clutch
- Rubbing Between Front and Rear Skirts on ProStar
- ProStar Side Skirt Paint Mismatch
- Push-in Trim Fasteners Popping out or Missing
- Sleeper Curtain Getting Sucked into HVAC Duct
- No Idle Curtains Missing Velcro; only models with feature 16UZL
- Sleeper Buzz, Squeak, Rattle
- Drawer Rattle
- Work Surface Rattle
- Work Surface Latch Jammed
- Automatic Traction Control (ATC) Tire Size Compatibility; only with feature 04AZD and 04AZJ Bendix ATC
- ProStar Air Deflector Mounting Procedure (Rattling Noise from Air Deflector or Bulging Between Fasteners)
- Auxiliary Battery Box Cover Difficult to Remove; Only vehicles with Feature Code 0008XGG (auxilary battery...
- Seat Switch Operation, Testing, Diagnostics and Replacement
- Erratic rear lighting, water pump and back up alarm in combination
- Fuel Level Not Equal Between Tanks on Dual Draw Dual Return Dual Tank Systems.
- MaxxForce 15L engine PayStar to ProStar Conversion
- Troubleshooting Auto Start Stop; only on ProStar with feature code 0008TSJ
- City Horn Blows When Driver Shuts off Truck and Walks Away; only equipped with with ESC or Body Controller
- Retrieving Fault Codes Through the Cluster Doesn?t Work
- Asterisk in Lower Right Quadrant of Dash Display
- Remote Throttle Control Options for Vehicles with ESC?s or Body Controllers and International Engines
- Cab Odor Service Plan Information
- Body Controller/ESC Software Updates
- Navistar: due to blocked radar sensor from a built up of snow and/or ice on the front of snow removal may...
- Battery Drain ( Parasitic Drain) with Sleeper Refrigerator; only models with optional refrigerator
- Dual Fuel Tank Transfer Pump System With Two Wire Pump Troubleshooting; Only models built with Feature...
- Dual Fuel Tank Transfer Pump Troubleshooting
- Filterminder Air Restriction Gauge Improvement; only models with 0016HKC, FILTER MINDER UNDER HOOD W/SWITCH
- Disable Cummins Icon; Only models equipped with Cummins engine and with Icon installed.
- HVAC faults 520211 and 520465; only Models with Body Controllers
- Navistar truck: when bellows are bent out of form CAN cause damage to exhaust bellows
- Proper Exhaust Shield Orientation
- Exhaust Bellows Damage; only models equipped with bellows exhaust pipe.
- Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
- Phosphate Conditioner Required When Replacing Radiators; only models with EPA 2009.5, 2009.75 and 2010...
- Spn 1590 fmi 19
- International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is...
- Horizontal Aftertreatment Mounting Bolt Torque; only models equipped with MF 11/13 engines
- International: on certain heavy duty trucks, an issue with up shift and down shift manual mode buttons,...
- Manual Mode Button on the Eaton Shift Console is flashing with No Active Codes in the TCM. With Active...
- Preventative Maintenance on Horton Stratis Fan Hub Anti Rotation Bracket
- FLR-10
- Dash Cluster Stuck in one mode
- Bendix Wingman FLR- 20 alignment; only vehicles equipped with Bendix Wingman system
- Water entry into the cab / Adding Cowl tray seal; models built prior to 11/11/2013
- Espar Heater Diagnostic Guide; only vehicles with feature code 16UZL, 16VTV (Airtronic D2 Heater, Hydronic...
- Mirror Repair Procedures and Replacement Parts Availability; only models with Lang Mekra Mirrors
- Certain MaxxForce 13 engines may experience increase in engine RPM while idling (only while vehicle is...
- Webasto Airtop 2000 ST D Service and Repair Manual; only with feature code 0016VSU
- Bendix Wingman
- Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- SkyRise Roof Replacement
- ESPAR AirTronic Low Run Time; only models with Feature Code 0016VTV
- One piece sunshade mounting bracket becomes loose or comes off the cab; Only models built in Garland or...
- Location of 1000 OHM Resistor In the HVAC Wiring
- Deaeration Tank Hose Re-Route Engine Parameter Download Instructions; Only models marked with AFC12917
- Low Temperature Radiator Diagnostics
- Navistar: the brake lights stay on and are not working
- Only equipped with Air Brakes
- How to Add Lift Gate Battery Protection; only models equipped with Electronic System Controller (ESC) or...
- Suspension Dump; only models with programming feature 595ACA (Suspension Dump).
- Horton Stratis Fan Hub Diagnostics
- On vehicles with the electronic jaw release system, the airlines at the isolation/vent valve may not be...
- Remote Power Module (RPM) Troubleshooting
- Iknow: stratis fan hub diagnostics
- International: there are code faults, caused by load shedding, loaded in other modules and unit goes into...
- International: information is being provided regarding the procedures for the adjustment of internal and...
- Deaeration Tank Hose Re-Route Engine Parameter Download Instructions
- Meritor Front Brake Return Spring Install
- Hydraulic Clutch Adjustment for ProStar + Vehicles; only Vehicles with Hydraulic Clutch
- Auxiliary Battery Box
- International: weldon tail lights are replacing the truck lite on some trucks built before 2/21/13
- Additional hardware is required when replacing Tail Light Assemblies from Truck-Lite to Weldon; only...
- Adjustment Procedure for Tilt Only Steering Column; only models with Feature code 0005708
- VIS Display wont boot up; only with feature code 0016HLP, ELECT VEHICLE MONITOR/WING PANEL/WI-FI or...
- Wiper Troubleshooting
- Cab Ride Height Specifications and Adjustment Procedures
- Hood-Mounted Mirror Reinforcement Kit. Retired
- Iknow: the battery cube fuse stud terminal with the alternative part needs to be replaced
- Navistar: some vehicles' low coolant light may illuminate or may have been deactivated. therefore; the...
- Iknow: on some vehicles the turning angle may cause a bent or broken axle stop bolts
- Iknow: install kit in order to alleviate loose, vibrating, or rattling of the hood-mounted mirrors
- Troubleshooting & Resetting HVAC Doors; only 2010 and later vehicles with feature code 0016WCT.
- Auto Start/Stop Feature, shut down Issue; only with Body Controller Feature 595BVG
- Certain 2010, 2011, and 2012 model year MaxxForce® 11 engines do not meet EPA emissions requirements.
- FLR-10
- Remote Engine Speed Control Module (RESCM) Troubleshooting; Only trucks equipped with RESCM
- International: engine would shut down after few minutes once auto start/stop button was engaged and in...
- Of a new chassis with a frame bow; only chassis equipped with "dogbone" style crossmembers
- Parts Lists for Maxx Power and Espar Anti Idle Systems; only models with Feature Code 0016UZL
- Iknow: prostar brake assembly conversion
- HVAC Diagnostic Information; only models 2010 and newer
- Wingman DTC Report; onle vehicles equipped with Bendix Wingman system
- Navistar: emissions recall on certain trucks that do not meet emissions requirements and need installed an...
- Blower Motor Assemblies and Linear Power Module (LPM) Updates.
- Iknow: replacing truck -lite tail lights with weldon tail lights
- Ambient Air Temperature (AAT) senor faults; only models with 2010 EPA MaxxForce 11, 13 engines.
- Updating Body Controller Software
- Navistar: blower motor assemblies and linear power module (LPM) updates
- How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
- The Doser tube coolant return hose assemblies and coolant hoses have been found to leak.
- International: the turn signal lamps and hazards fails to illuminate and/or work properly
- Power Windows Stop Randomly
- The brake S-Cam tube bracket assemblies on steer axles may exhibit fractures between the wing bracket and...
- Body Controller Resource Center
- Inverter/Charger Power System
- The fuel gauges may operate intermittently, accompanied by audible lamp and/or LCD messages
- ECM Recalibration to provide engine protection against an increase in engine RPM while vehicle is idling...
- Headlight Operation and Troubleshooting; only Post 2007 Vehicles Built with a Body Controller
- Navistar: on some trucks, fuel gauges operated intermittently and was accompanied by audible, lamp, and/or...
- Navistar: while idling in park and not moving, engine's RPM would increase and to reduce back pressure...
- Fan Clutch Harness Routing Repair; only models with MaxxForce 11, 13 engines
- Iknow: sleeper side sill/underbody cross-member weld check and repair
- Sleeper Side Sill/Underbody Cross-Member Weld Check and Repair
- ECM recalibration to provide engine overspeed protection (only in a parked state or if the vehicle is not...
- Air Control Valve (ACV) Connector with Plugs Installed Backwards in Empty Connector Cavities; Only models...
- Navistar: fan clutch harness routing repair
- Exhaust Gas Recirculation (EGR) Valve Replacement; Only models equipped with MaxxForce 11 or 13 engines
- International: informational procedures for repairing connections for grommet pass through due to water...
- Water leaks through Cab Cowl pass-through connections
- Power Windows randomly stop
- Aftertreatment Resource Center; All models equipped with EPA 2007 and newer engines
- Peoplenet Information; Only models equipped with Peoplenet option
- Drive Axle and Steer Axle Air Suspension Ride Height Settings; only models equipped with Feature Code...
- Circuit diagram for ProStar/LoneStar Fifth wheel; link to missing diagram.
- The piston in the spring brake chamber may in certain cases,
- Navistar: 2010 maxxforce 15 high-pressure (HP) fuel pump replacement
- International (navistar): the cruise control wires, from switches, are momentarily shorted out when...
- International: procedure is provided regarding the pop up of the battery hold down and to install new...
- International: information provided in regards to repair procedures of replacing dipstick tube, in...
- Navistar: replacement pump, for certain hp fuel pumps maxxforce 11 and 13, fell into suspect build period...
- International (navistar): procedures regarding the replacement and installation, on certain trucks, of the...
- International (navistar): information is being provided regarding the inspection and removal of steering...
- International: information regarding the fuel system components and repairs to correct interference to...
- International: information being provided regarding the rusting of power steering hoses that needs to be...
- International: battery cables routed too close to spring hanger shackle bolt for left-sided battery box or...
- International: spring hanger shackle bolt may have battery cables routed too close for left sided battery...
- International: information provided regarding the re-routing of alternator wiring to prevent rub points
- Navistar: on certain trucks, the wabco ABS brake module change from 5-AMP to 10AMP fuse but fuse panel...
- International: vibration while braking
- Navistar: on certain maxxforce engines, a repair procedure is provided for cracks during truck operation...
- Navistar: need to remount or realign the air suspension pressure sensor horizontal and not vertical
- Navistar: on certain trucks, the door and window locks fails to operate properly
- Navistar: seat belt components currently installed in some buses and trucks will be replaced by new...
- Incorrect 5AMP fuse at location F11-D on wabco 6 sensor 6 modulater
- Navistar: fuel tank to battery box bolt clearance
- Navistar: HVAC front inside module drain repair
- Navistar: procedure is provided regarding the installation of grease in EGR valve that was produced...
- International: on some trucks, an auto start stop feature code 0008TSJ, allows preset values in body...
- Navistar: maxxforce 11, 13, and 15 recalibration to adress frequent warning lights
- Navistar: certain trucks may allow water intrusion into module where seal, between two halves of eaton...
- Navistar: engines on certain vehicles have an idler gear stud that was nitrate coated improperly resulting...
- Navistar: on prostar truck, the duel fuel tank system transfer pump is not functioning properly.
- Navistar: on certain trucks, lonestar and prostar, the warning indicators for the fifth wheel jaw...
- International: fifth wheel jaw monitoring feature,, which has two warning indicators i.e
- Navistar: troubleshooting for intermittent or no front blower operation
- Navistar: there is updated ECM software
- Navistar: poor launch concerns and stored trouble codes
- Navistar: there are air control valve trouble codes that CAN be caused by connector vibration, loose...
- International truck: the fuel pump is not working due to air bubbles
- Navistar: prostar inspection information
- Navistar: the 2010 prostar and fanstar with a 2010 maxxforce emissions and variable speed fan drive CAN...
- Navistar: cooler filter clearance procedure
- Navistar: the procedure for a centrifuge filter hose routing and mounting
- Navistar: on certain 2010 trucks there was a misbuild and they have oversized cac hose clamps
- Navistar: the fan is running all the time and vehicle is built with 0012TKT borg warner cool logic fan
- Navistar: fastener that clamps pitman arm to steering gear shaft may not have been fully tightened upon...
- Navistar: cummins air temperature sensor located rear of vehicle, instead of front, on some models
- International: fixed vent window 016HKR replacement and rebonding instructions
- Navistar: various types of vehicles including lonestar, prostar, 8600, and 7600 vehicles will need an...
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 International Prostar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history