2012 International Terrastar technical service bulletins
187 technical service bulletins and manufacturer communications cover the 2012 International Terrastar.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article provides guidance to dealership personnel, Technical Services personnel, Dealer Service...
- New CARB Idle Reduction Change Request
- This tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files
- This document provides guidance for assessing the feasibility of implementing a customer-requested change...
- Engine replacements for all International engines will need to follow this procedure.
- This document will guide the user through a step-by-step procedure for detecting water leaks in vehicle...
- This document will guide the user through understanding Prop Shaft Codes and understanding the variations...
- In some geographic areas, ambient temperatures reaching below 15°F (-10 °C), including high levels of...
- Title: Service Portal iKNow Feedback Case Types Applies To: All
- Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
- Title: A/C Refrigerant and Oil Capacities Applies To: All current models
- Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
- Title: Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition...
- Title: Steering Gear Seal Repair Guidelines Applies To: Steering gears
- Title: How to Request a Horsepower Quote Applies To: All International and Cummins Electronic engines
- This document reminds technicians of the critical relationship between the truck's suspension and the...
- Applies To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of...
- This article addresses chassis lean conditions on all chassis
- Suggested alignment target values when performing a vehicle axle alignment.
- Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison...
- J1939 Data Link Source Address Information
- Diagnosis of chassis wander complaints.
- General Wheel Speed Sensor Troubleshooting
- How to request a horsepower quote; all International and Cummins engines
- J1939 Data Link Troubleshooting
- Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles...
- J1939 Data link source address information
- Pico Scope CCOS (Crankcase Separator Test)
- PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
- PicoScope Test 12V Electrical Noise Detection
- PicoScope Test
- PicoScope Test for Datalink (CAN) Health Shorts & opens
- PicoScope Test Resistance and Ohmmeter
- PicoScope Wheel Speed Sensor Test
- PicoScope Test One Channel RCT
- Calculating pulses per mile (speedometer setting); only models equipped with International engines
- ECM Calibration for DPF Replacement; Applies to MaxxForce Engines
- Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
- Engine Oil Capacities
- Cab water leak troubleshooting tips
- General wheel speed sensor troubleshooting
- Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
- ECM Calibration for DPF Replacement; only trucks and busses built with 2007- 2009 MaxxForce DT/9/10....
- Cab Lean Concern
- Driveline Information Center and Troubleshooting Procedures
- Repair Procedures for Vehicles Struck by Lightning
- A/C Refrigerant and Oil Capacities
- Cleaning and Disinfecting Trucks and Buses
- Oil Capacities; All Electronic International Engines 1994
- Suspension Lean Diagnostics; All models
- The First Check to make when Troubleshooting any Body Controller or ESC Issue
- Cab Water Leak Troubleshooting Tips; Excluding 9000i, PayStar(HX), CityStar, or LoadStar
- Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure
- Wind noise at upper side of cab door
- FLR-10
- Tool Instruction
- Engine Oil Capacities All Electronic International Engines 1994
- Radio Diagnostics and Information
- Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure;...
- The fire extinguishers may become clogged or require excessive force to activate
- Updating OnCommand Link with Accelerator
- ISX, N13, and N9 / N10 Aftertreatment Private Data Link Troubleshooting
- Winter Front Usage
- Engine Oil Capacities
- OnCommand EZ-Tech
- Using Supplier Software to Check DTCs
- Trailer Auxiliary Switch Lamp Burning Out; Only Vehicles Equipped with Feature Code 0008TTH or 0008THG
- NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
- Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR...
- HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
- Dealer EZ-Tech and Diagnostic Software Support Resource Center
- CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
- OnCommand EZTech
- Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
- OnCommand EZ-Tech Download Center
- Air Conditioning Mechanical Pressures Diagnostics
- Air Conditioning Control Head Diagnostics
- 2010 and Newer Vehicle Air Conditioning Diagnostics (Start Here)
- Steering Shake, Shimmy, Shudder, or Steering Vibration; only with 14k front weight rated axles and below
- Steering Fluids
- Cooling System Flush Procedure
- J1939 Data Link Troubleshooting; Only Models with 250k Baud Data Link (Black 9 Pin Diagnostic Connector)
- To Get A Helios Capture; All 1939 and 1708 multiplexed trucks only
- Power window binding
- Radiator internal restriction and flush procedure
- Power Window Binding
- Wind noise at upper side door
- MaxxForce 7 Fuel Dilution Diagnostics
- Performing relative compression test and misfire test with cpa tool
- Davco fuel pro 382 technical manual, installation, diagnostics, and service
- Exhaust manifold service procedures
- Service parts damaged new turbocharger oil supply tube
- Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- Change in Seat Belt Manufacturer
- TerraStar Transfer Case Diagnostic and Operational Information
- Seat occupant sensor; Emergency applications only
- Dash Cluster Lamp Operation, Functions and Regeneration Instructions, With International engines
- A jump start or electrical load dump event could result in an overvoltage condition of the cab Linear...
- Vehicles with Thandle Shifters; 6th Gear Disable Information and Diagnostics
- HVAC faults 520211 and 520465
- DPF Snap Accel Test
- International: information regarding issue with power windows failing to operate properly or power doors...
- 8,000 lbs
- International (navistar): chassis side, seats and seat belt sensors are not properly wired and may not...
- Air Conditioning Electrical Diagnostics
- Cluster Software Update Instructions
- Radio diagnostics and information
- Changing truck or trailer lighting, between combined or separate, stop and turn lights
- Combined or separate, turn and stop lights
- Wind noise at upper side door
- Cowl tray seal; only built prior to 11/11/2013
- Remote engine speed control module (RESCM) troubleshooting
- Cluster Issues
- 1939 Data Link Troubleshooting
- Brake Light Operation on TerraStar with HydroMax brakes
- 2010 Dash Cluster Lamp Operation with new DPF Lamp Locations , Functions and Regeneration Instructions
- Emergency vehicle applications that originally left the assembly plant with Engine Warning Protection...
- Horn Sounds On Its Own While Vehicle Parked
- City Horn Blows When Driver Shuts off Truck and Walks Away; only equipped with with ESC or Body Controller
- Retrieving Fault Codes Through the Cluster Doesn?t Work
- Remote Throttle Control Options for Vehicles with ESC?s or Body Controllers and International Engines
- Body Controller/ESC Software Updates
- HVAC faults 520211 and 520465; only Models with Body Controllers
- International: an improperly changing parameter in an ABS module or an ECM calibration update, CAN cause...
- ABS Fault After ECM Calibration or Incorrectly changing a parameter
- Iknow: some vehicles may experience an exhaust leak
- Exhaust Leak Repair at Turbocharger Adapter to Down Pipe Joint
- Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
- International: information provided regarding the operational and diagnostic of transfer case with 4...
- TerraStar Transfer Case Diagnostic and Operational Information; only TerraStar 4x4 Models
- Transfer Case Diagnostic and Operational Information; Only 4x4 Models
- 6th Gear Disable Information and Diagnostics
- Water entry into the cab / Adding Cowl tray seal; models built prior to 11/11/2013
- Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- Medium duty cole weather operation / solid winter front; EXCLUDING High Cab DuraStar
- International (navistar): the adhesive patch, used on one piece sunshade, fails, and the sunshade mounting...
- One piece sunshade mounting bracket becomes loose or comes off the cab; Only models built in Garland or...
- Location of 1000 OHM Resistor In the HVAC Wiring
- Diagnosis of Noise Originating from Steering System
- Adjustment Procedure for Tilt Only Steering Column; only models with Feature code 0005708
- TerraStar Frame Reinforcement Excessive Gap Variance
- Iknow: after replacement, program trw 355 ABS module
- Navistar: some vehicles may have loose or broken bolts on the AC compressor support
- Torsion Bar Retention Cotter Pin Design Change; only models built before 1/31/2013
- Engine Warning Light with fault codes or engine misfire due to open injector circuits caused by spread...
- Epa 2010
- Remote Engine Speed Control Module (RESCM) Troubleshooting; Only trucks equipped with RESCM
- Of a new chassis with a frame bow; only chassis equipped with "dogbone" style crossmembers
- Iknow: terrastar transmission shift cable routing
- TerraStar Transmission Shift Cable Routing
- International: this is a cosmetic issue, on some trucks, where a design change for the torsion bar...
- How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
- Body Controller Resource Center
- Headlight Operation and Troubleshooting; only Post 2007 Vehicles Built with a Body Controller
- FM/AM Radio with No Sound
- International: informational procedures for repairing connections for grommet pass through due to water...
- Water leaks through Cab Cowl pass-through connections
- Power Windows randomly stop
- Aftertreatment Resource Center; All models equipped with EPA 2007 and newer engines
- International: headlamp wiring harness rerouting
- Navistar: there is an improved engine calibration
- Navistar: a chirping sound from the HVAC blower when the ignition key is first turned on
VIN decoder
See the problems and recalls for an exact car
Buying a used 2012 International Terrastar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history