2009 International Transtar technical service bulletins
204 technical service bulletins and manufacturer communications cover the 2009 International Transtar.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article provides guidance to dealership personnel, Technical Services personnel, Dealer Service...
- This article describes how to fix a speedometer that does not read accurately
- New CARB Idle Reduction Change Request
- This tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files
- Engine replacements for all International engines will need to follow this procedure.
- This document will guide the user through a step-by-step procedure for detecting water leaks in vehicle...
- This document will guide the user through understanding Prop Shaft Codes and understanding the variations...
- In some geographic areas, ambient temperatures reaching below 15°F (-10 °C), including high levels of...
- Title: Service Portal iKNow Feedback Case Types Applies To: All
- Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
- Title: A/C Refrigerant and Oil Capacities Applies To: All current models
- Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
- Title: Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition...
- Title: Steering Gear Seal Repair Guidelines Applies To: Steering gears
- Title: How to Request a Horsepower Quote Applies To: All International and Cummins Electronic engines
- This document reminds technicians of the critical relationship between the truck's suspension and the...
- Applies To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of...
- This article addresses chassis lean conditions on all chassis
- Suggested alignment target values when performing a vehicle axle alignment.
- Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison...
- J1939 Data Link Source Address Information
- Diagnosis of chassis wander complaints.
- General Wheel Speed Sensor Troubleshooting
- How to request a horsepower quote; all International and Cummins engines
- J1939 Data Link Troubleshooting
- Snap-On torque wrench requirement for all big bore engine connecting rod bolts; A26, MaxxForce 13, N13 engines
- New Air compressor Incorporates an oil feed dowel O-ring; only models built with MaxxForce 11/13, N13, or...
- Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles...
- J1939 Data link source address information
- Pico Scope CCOS (Crankcase Separator Test)
- PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
- PicoScope Test 12V Electrical Noise Detection
- PicoScope Test
- PicoScope Test for Datalink (CAN) Health Shorts & opens
- PicoScope Test Resistance and Ohmmeter
- PicoScope Wheel Speed Sensor Test
- PicoScope Test One Channel RCT
- Cab water leak troubleshooting tips; HX with steel cab only
- Calculating pulses per mile (speedometer setting); only models equipped with International engines
- ECM Calibration for DPF Replacement; Applies to MaxxForce Engines
- Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
- Engine Oil Capacities
- Cab water leak troubleshooting tips
- General wheel speed sensor troubleshooting
- Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
- Frame Rail Straightness Inspection Procedure
- Suggested alignment target values when performing a vehicle axle alignment
- ECM Calibration for DPF Replacement; only trucks and busses built with 2007- 2009 MaxxForce DT/9/10....
- Cab Lean Concern
- Driveline Information Center and Troubleshooting Procedures
- Repair Procedures for Vehicles Struck by Lightning
- A/C Refrigerant and Oil Capacities
- Cleaning and Disinfecting Trucks and Buses
- Bendix EC80 Blank Module Replacement Program;
- Oil Capacities; All Electronic International Engines 1994
- 8600/TranStar Hood Latches Do Not Fit Correctly
- Suspension Lean Diagnostics; All models
- The First Check to make when Troubleshooting any Body Controller or ESC Issue
- Cab Water Leak Troubleshooting Tips; Excluding 9000i, PayStar(HX), CityStar, or LoadStar
- Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure
- Wind noise at upper side of cab door
- Brake Lights Staying On
- Programing New Key Fobs
- Hendrickson Assembly Instructions; Transverse Torque Rods
- Air Pressure Gauges and A/C Pressure Transducer Troubleshooting
- Improved Bushings for Hendrickson Torque Rods
- Tool Instruction
- Engine Oil Capacities All Electronic International Engines 1994
- Radio Diagnostics and Information
- Cummins Programming Guide and Cummins 285 Fault Code; Only pre-2007 models built with Cummins ISM Engine
- Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure;...
- The fire extinguishers may become clogged or require excessive force to activate
- Updating OnCommand Link with Accelerator
- ISX, N13, and N9 / N10 Aftertreatment Private Data Link Troubleshooting
- Winter Front Usage
- Engine Oil Capacities
- OnCommand EZ-Tech
- Using Supplier Software to Check DTCs
- Trailer Auxiliary Switch Lamp Burning Out; Only Vehicles Equipped with Feature Code 0008TTH or 0008THG
- NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
- Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR...
- HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
- Dealer EZ-Tech and Diagnostic Software Support Resource Center
- CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
- OnCommand EZTech
- Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
- OnCommand EZ-Tech Download Center
- DM harness inspection; Only with Steering Column feature code 05710
- Steering Shake, Shimmy, Shudder, or Steering Vibration; only with 14k front weight rated axles and below
- Steering Fluids
- Cooling System Flush Procedure
- Repair Information for Damaged Headlight Connector
- J1939 Data Link Troubleshooting; Only Models with 250k Baud Data Link (Black 9 Pin Diagnostic Connector)
- To Get A Helios Capture; All 1939 and 1708 multiplexed trucks only
- Radiator internal restriction and flush procedure
- Wind noise at upper side door
- Adding an Electronic Trailer Brake Controller
- Tech Tip to aid technicians in the efficient removal and installation of a TC10 transmission
- Performing relative compression test and misfire test with cpa tool
- Misfire diagnostics ibb; SPN132(X)
- Davco fuel pro 382 technical manual, installation, diagnostics, and service
- Exhaust manifold service procedures
- Service parts damaged new turbocharger oil supply tube
- Fan Shaft Failure Diagnostics with feature code 12THX (Viscous Fan Drive)
- Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- Vibration Troubleshooting
- Mirror Repair Procedures and Replacement Parts Availability
- Front Blower Motor Runs Breifly At Initial Power Up
- Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts
- Rear S Cam Tube / Bracket part update
- Eaton Clutch Information
- DPF Snap Accel Test
- Dual Fuel Tank Transfer Pump System With Two Wire Pump Troubleshooting; equipped with feature 595192 built...
- Dual Fuel Tank Transfer Pump Troubleshooting on Post-2007 NGV and ProStar
- Air pressure gauges and a/c pressure transducer troubleshooting
- Mirror repair procedures and replacement parts availability
- Trailer ABS In-Dash Lamp Stays On After A Trailer Has Been Disconnected; only with An In-Dash Trailer ABS...
- Cluster Software Update Instructions
- ProStar and NHPV with Suspension Dump feature code 595ACA or 595BBC
- Radio diagnostics and information
- International: two new accelerator position sensor (APS) contain non-contact hall effect idle validation...
- Accelerator position sensor / idle validation switch aps / ivs diagnostics
- Wind noise at upper side door
- Cowl tray seal; only built prior to 11/11/2013
- Body controller software revision 231 HVAC improvements; post 2007 models only
- Remote engine speed control module (RESCM) troubleshooting
- Cluster Issues
- 1939 Data Link Troubleshooting
- Wipers and Aftertreatment Lights Inop on Post 2007 Trucks with Body Controller
- International: there are issues of missing complete engine air supply line and also missing t fitting with...
- Lubrication to the Intermediate Steering Column Upper U-Joint
- International truck: there is a body controller software revision
- Body Controller Software Revision 231 HVAC Improvements for Post 2007 ProStar, DuraStar, TranStar Only
- 2010 Dash Cluster Lamp Operation with new DPF Lamp Locations , Functions and Regeneration Instructions
- New Synthetic Oil for Eaton and Spicer Transmissions; only with Eaton or Spicer transmissions
- Transmission Keeps Shifting and Display Keeps Flashing After Ignition is Turned Off; only with Freedom...
- Roll Pins Backing Out of Bell Crank; Only with manual transmission
- LUK/Ixetic Power Steering Pump Fittings; only Vehicles equipped with Maxxforce 11, 13 engines
- In Chassis Cleaning Procedure for Cooling Package in All Models with MaxxForce 11, 13 Engines
- Headlight Condensation or Frost; excludes sealed beam headlights such as on WorkStar, Paystar and 9900i)
- Clutch Linkage Rattle
- Engine Cover Appears to be Scuffed
- Cab Air Suspension Ride Height Measurement and Adjustment
- Hood Latches Do Not Fit Correctly
- General Air Brake Plumming Schematic
- Fuel Level Not Equal Between Tanks on Dual Draw Dual Return Dual Tank Systems.
- City Horn Blows When Driver Shuts off Truck and Walks Away; only equipped with with ESC or Body Controller
- Retrieving Fault Codes Through the Cluster Doesn?t Work
- Asterisk in Lower Right Quadrant of Dash Display
- Remote Throttle Control Options for Vehicles with ESC?s or Body Controllers and International Engines
- Horton 2 Speed Drive Master Fan Clutch missing or loose magnets; only with MaxxForce DT, 9 and 10 Engines...
- Body Controller/ESC Software Updates
- Water In Fuel (WIF) Message Blinking in Dash Message Center at Key On; only models with International Engines
- Dual Fuel Tank Transfer Pump System With Two Wire Pump Troubleshooting; Only models built with Feature...
- Dual Fuel Tank Transfer Pump Troubleshooting
- Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
- Threaded Drain Hole In DPF (Muffler); only trucks equipped with CAT 2007 Emission Engines
- Dash Cluster Stuck in one mode
- Water entry into the cab / Adding Cowl tray seal; models built prior to 11/11/2013
- Mirror Repair Procedures and Replacement Parts Availability; only models with Lang Mekra Mirrors
- Certain MaxxForce 13 engines may experience increase in engine RPM while idling (only while vehicle is...
- Location of 1000 OHM Resistor In the HVAC Wiring
- Only equipped with Air Brakes
- How to Add Lift Gate Battery Protection; only models equipped with Electronic System Controller (ESC) or...
- Suspension Dump; only models with programming feature 595ACA (Suspension Dump).
- Horton Stratis Fan Hub Diagnostics
- Remote Power Module (RPM) Troubleshooting
- Wiper Troubleshooting
- Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- Remote Engine Speed Control Module (RESCM) Troubleshooting; Only trucks equipped with RESCM
- Cummins Active Fault Code 249 / 256 Ambient Air Temperature Sensor; only models with Cummins ISX or ISM...
- Cummins Ambient Air Temperature (AAT) Sensor Located Rear of Vehicle; Only models with Cummins ISX or ISM...
- Updating Body Controller Software
- How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
- Body Controller Resource Center
- Headlight Operation and Troubleshooting; only Post 2007 Vehicles Built with a Body Controller
- Power Windows randomly stop
- Aftertreatment Resource Center; All models equipped with EPA 2007 and newer engines
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 International Transtar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history