2006 Itasca Cambria problems

What is wrong

Winnebago is recalling 31 my 2006-2008 itasca cambria, horizon, winnebago access, adventurer, journey, minnie winnie, signtseer, tour, vectra, and voyage motor homes equipped with ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift systems for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. The lift could stow even though someone or something is still on the lift.

Risk

A lift occupant can be injured should the lift begin to stow unintentionally.

Remedy

Winnebago is working with ricon to correct the wheelchair lifts (please see 07e097). Owners may contact ricon at 1‑800‑322‑2884 or winnebago at 1‑641‑585‑3535.

Recall number 08V419000 · Recall details

What is wrong

On certain motorhomes,the flame on the cooking range may be forced downward over the burner or flame outage may occur when the cooking range and furnace are operated at the same time. This is due to the possibility of a missing or incomplete cabinet panel that isolates the furnace return air.

Risk

If the furnace is operated at the same time as the stove and the cabinet panel is missing or incomplete, the stove flame may go out and the propane gas will continue to flow, which has the potential to ignite resulting in personal injury, vehicle and property damage.

Remedy

Dealers will inspect the cabinet assembly and, if the cabinent panel is missing or incomplete, the panel will be installed or repaired. The recall began on august 10, 2006. Owners may contact winnebago at 1‑641‑585‑6939.

Recall number 06V292000 · Recall details

What is wrong

On certain motor homes equipped with kwikee brand electric steps, the steps may have been manufactured with defective step control units.

Risk

The defective control units could develop an electrical short allowing for the potential of the plastic case to ignite, possibly resulting in personal injury and/or vehicle and property damage.

Remedy

Dealers will inspect the kwikee step and replace the step control unit, if necessary, free of charge. The recall began on december 23, 2005. Owners may contact winnebago at 1‑800‑537‑1885.

Recall number 05V573000 · Recall details

What is wrong

On certain motor homes built on ford chassis, the fasteners holding the fuel tank mounting straps may not have been properly tightened, allowing the possibility for the fuel tank to loosen and fall.

Risk

If the fuel tank falls, there is the potential for the tank to ignite, resulting in personal injury, vehicle and property damage.

Remedy

Dealers will inspect and properly tighten the fasteners to the fuel tank straps. The recall began on october 15, 2005. Owners may contact winnebago at 614‑585‑6939.

Recall number 05V475000 · Recall details

During this investigation, ODI identified 29 reports of cracked and/or fractured hitch receiver assemblies installed on the subject vehicles.The majority (27 of 29) of the reported hitch incidents occurred prior to the initiation of PE10-048 in December, 2010.This investigation has been characterized by (1) Scant forensic samples available for inspection and review since most of the reported incidents occurred prior to ODI?s investigation and pertinent material has been scrapped; (2) Uncertainty regarding the contributory role of issues such as unintended hitch contact with road surfaces, use of hitches with offsets that exceed Winnebago recommendations; and (3) Other usage factors.Based on reported failures, the indicated failure rate for detected and reported cracking /fracture incidents associated with the estimated population of subject vehicles was found to be 0.10% after the vehicles had been in service for between 6 and 8 years.Reports were higher in calendar year 2007 (9 reports) than in succeeding years 2008-2010 (3-5 reports per year) and 2011 (2 reports) and appear likely to decline further due to diminished use associated with vehicle aging.ODI is aware of only one consumer complaint (ODI# 10368002) in its files describing a hitch receiver malfunction in Winnebago-Itasca vehicles.As of September 2013, Winnebago has reported that there have been no additional incidents of cracked or fractured hitch receivers reported since the most recent incident reported in May 2011.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.For more detailed information, see the attached closing report.

PE10048