2002 Itasca Sunova recalls

What is wrong

Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Risk

The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.

Remedy

Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1‑800‑767‑9101 or winnebago at 1‑641‑585‑3535.

Recall number 10V525000 · Recall details

What is wrong

On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.

Risk

An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.

Remedy

Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800‑932‑3837 or winnebago at 641‑585‑3535.

Recall number 03V405000 · Recall details

What is wrong

On certain motor homes, when the cooking range and furnace are operating at the same time, the flame on the cooking range could be forced downward over the burner or flame outage could occur. This condition is due to the location of the furnace and cooking range whereby the furnace may draw air in from above the range burners and cause a downdraft.

Risk

Should this occur, the flame may go out, and the liquid propane (lp) gas will continue to flow. This is a hazardous situation that could result in an explosion or fire.

Remedy

Dealers will install an air restrictor panel under the range. Owner notification began july 10, 2003. Owners should contact winnebago at 1‑641‑585‑6939.

Recall number 03V243000 · Recall details

What is wrong

Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105,"hydraulic and electric brake systems." the brake system warning indicator may not function as required by the standard.

Risk

In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the system warning indicator.

Remedy

Dealers will repair these vehicles. Owner notification began april 25, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1‑641‑585‑3535.

Recall number 03V060000 · Recall details