2022 Jeep Gladiator: check engine light

Filed Jul 14, 2026 · MO · fire

What happened: Driving on road, check engine light and traction control light appeared, smelled metallic-type odor, pulled over, before I could put it in park smoke started pouring from under the hood on passenger side. Unable to extinguish due to ball of flames hitting me as I opened hood. Burned it to the ground. Which component: I'm assuming it was the electric hydraulic power steering pump (EHPSP) wiring. The fire was on the passenger side. The vehicle is available for inspection in a tow lot near [XXX]. Safety: It caught fire on a small dirt road in the country. I was the only occupant and I was uninjured. There was nobody on the road at the time. Thankfully the woods got rain recently or it would have caused a massive forest fire. Problem reproduced: No Inspection: No one has inspected the car yet. Warning: There was no other warning other than described above and the truck was behaving perfectly normal. Other: The vehicle was taken to Tri-Lakes Ford in [XXX] to replace the high pressure fuel pump (another recall). They told me they didn't have the parts to fix the steering yet, so I planned on coming back when they did. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 9, 2025 · Engine · NY

Component Affected: Engine – Camshaft and Rocker Arms Summary of the Problem: My 2022 Jeep Gladiator experienced a failure of the camshaft and rocker arms due to scoring on the camshaft. This issue occurred at approximately 52,000 miles. The vehicle is currently inoperable (on and off flashing check engine light) Dealership gave me the vehicle back to drive while awating parts for repair. The required components are on national backorder with an estimated delay of over 4 weeks, leaving me without a functioning/safe vehicle. Safety Concern: This failure occurred without warning and could have led to a dangerous situation if it had happened while towing. I use this vehicle to tow a 3,500 lb camper, which is well within its rated towing capacity (6,500 lbs). The sudden loss of engine performance could pose a serious safety risk, especially on highways or in remote areas. Additional Notes: I am reporting this issue because I have learned that other Jeep Gladiator owners have experienced similar camshaft and rocker arm failures. This may indicate a broader defect in the engine design or materials. I believe this issue warrants investigation for potential recall or manufacturer accountability.

Filed Sep 29, 2024 · IL · fire

In the early afternoon hours of July 5, 2024, our 2022 jeep gladiator rubicon with only 18,000 miles spontaneously combusted in our driveway after being parked there for just under 24 hours. While working in the yard, my husband noticed thick black smoke coming from the engine. The smoke quickly turned into flames then rapidly intensified as it spread throughout the engine, cabin and then ultimately the entire jeep. The jeep was a total and complete loss with Jeep claiming no responsibility whatsoever. We have over $60,000 in damages to our home, driveway, landscaping and soil (PFAS) from the fire, NOT including the jeep itself. Note *The engine light did go on about a month prior to the fire, which from what we were told by Jeep service dept, was due to multiple misfires. This issue was resolved immediately. After the fire, the jeep was inspected by our insurance company and also by Jeep. Because the fire was so intense and quickly spread, there wasn’t anything left. Jeep never returned our calls and never once tried to make things right! Our safety was at risk for obvious reasons. The Jeep spontaneously started on fire due to no fault of our own. Had we not have been home, or had the Jeep been parked in our garage, facing the garage or the fire started at night while we were sleeping, the outcome would have been quite different. The damage it DID do to our property along with the mental anxiety and stress of trying to pay for repairs is significant enough without actually having our house burn down to the ground. This is unacceptable! Jeep needs to take responsibility!

Filed Sep 27, 2024 · Fuel system, Transmission · NM

The High-Pressure Fuel Pump (HPFP) failed while I was entering a downhill curve on a paved but narrow mountain road with no shoulder. The HPFP had been under an active recall, (Y78 / the federal safety agency 21V‑880) but every time we went in for service our Jeep dealership said a remedy was not yet available. When I asked if it was safe to drive, they said yes, continue to drive the vehicle and that they would call us when a remedy became available. Not very sage advice. The failure happened while we were on vacation in a remote area of New Mexico, four hours away from home. An unrecognizable warning light flashed but did not remain on. The engine remained running, but the HPFP failure caused a complete loss of power to the engine and transmission. Steering became difficult. I gently braked and coasted to a safe spot. Luckily that spot was a forest service road about a quarter of a mile from where the Jeep lost power. We had the vehicle towed to the nearest Jeep Dealership. They confirmed that the HPFP failed. It took 2 months for Fiat Chrysler Automobiles N.V. (FCA), and that dealership to address the HPFP issue. At the end of 2 months, they called and said the vehicle was fixed and ready. While driving home from the dealership a check engine light came on. That was [XXX]. We had the vehicle towed to our local Jeep dealership. Our dealership checked and said that there were still metal shavings in the fuel system. Our dealership and FCA have not found a solution and our Jeep is still inoperable and setting at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 14, 2022 · Transmission · PR

On Sept 23, the vehicle went into the dealership service department to replace an apparent faulty transmission oil pan gasket, and today October 14, my Gladiator had to be towed to the dealership because the problem was not resolved, causing the check engine light to come on and additional loss of transmission fluid, apparently coming from the main seal.

Filed Sep 25, 2022 · Acceleration, Electrical · IN

The check engine light came on and said the vehicle will be shutting down and the vehicle died while driving and wouldn't restart! It said to service the power steering, vehicle not in service electronic stability control. It currently still won't restart. It has 300 miles and is one week old.