2005 Jeep Grand Cherokee technical service bulletins
117 technical service bulletins and manufacturer communications cover the 2005 Jeep Grand Cherokee.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Verify Reman part number availability
- Plate
- Security Module Lock Out After Entering the PIN to Unlock The Wireless Control Module (WCM)
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment
- Mechanical rocker arm, intake, 1.7 ratio.
- KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number
- Disinfectant Solution Recommended for COVID-19
- Charging System, Battery Diagnostic Tools and Warranty
- Damper
- Repair Parts Used For Structural Repairs
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- Exterior Mirror The latest version of these exterior mirrors have had their glass removed to be serviced...
- Valve Body
- NAG1 (5A580)
- Fiat chrysler: TSB has an owner notification letter
- Customer Satisfaction Notification P73 Reprogram Final Drive Control Module: The Final Drive Control...
- Customer Satisfaction Notification P73 Reprogram Final Drive Control Module The Final Drive Control Module...
- Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both...
- Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and...
- P41 Interim Repair Procedure Brazil ONLY Some Jeep Commander and Jeep Grand Cherokee vehicles may...
- UConnect Hands Free Module Fails To Respond Due To Module Lock Up
- Generic Powertrain Control Module (PCM) Procedure
- 4WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory
- Part Description: Actuator Motor
- New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety...
- 82212076, 82203694
- Chrysler/jeep: flash: esp system may prematurely activate momentarily when negotiating a curve or MIL...
- Jeep service campaign: rear axle fluid may contaminate the differential mounted rear wheel speed sensor
- Positive crankcase ventilation (PCV) system freezes in extreme cold ambient temperatures -- involves...
- 3.0L diesel oil filter cap service
- Engine cranks but will not start and applies to vehicles equipped with a 3.0L diesel engine
- This bulletin involves the replacement of mechanical clips for the intake manifold runner swirl valve linkage
- Passenger air bag deactivation
- Flash 42RLE - improved hill climb capability in reverse or diagnostic trouble codes (DTC) P1713/P1776
- Idle RPM flare cold vehicle operation-revised transmission oil fill level
- Tire pressure monitor system information
- Rear of sunroof glass is not flush to roof/sunroof will not close
- Powertrain control module initialization
- Enhanced torque converter and glow plug operation or brake switch DTC P0504
- Flash: enhanced torque converter, glow plug, skim operation
- Starscan@/starmobile abort recovery procedures. tt
- Flash: MIL illumination at start-up due to DTC P2112 or P1521
- Malfunction indicator lamp (MIL) illumination; a rattle-like sound from the torque converter; and...
- Generic powertrain control module (PCM) procedure
- Hydraulic radiator cooling fan system diagnostic check chart aid
- NAG1 (W5A580) transmission - shudder when torque converter clutch engages
- Flash: 42RLE - improved hill climb capability in reverse or dtc's P1713 / P1776
- Loose fuel cap message or malfunction indicator lamp illumination for diagnostic trouble code P0457 - evap...
- Daimlerchrysler corporation is now offering a passenger airbag deactivation wiring package
- Cylinder head bolt re-torque procedure
- Tire pressure monitor - system information
- Flash: fuel level indicator may momentarily drop to empty after refueling vehicle
- Flash:mil illumination at start-up due to DTC P2112 or P1521
- Transmission in limp-in mode or malfunction indicator lamp on due to powertrain control module ground wire
- High speed driveline vibration due to excess grease in rear propeller shaft joint
- Cold temperature initial startup - power steering whine-like sound
- Revised power steering system bleeding procedures
- Malfunction indicator lamp due to diagnostic trouble code P0401-EGR solenoid circuit negative deviation or...
- Automatic transmission diagnostic teardown procedure
- 45RFE/545RFE trans - delayed engagement due to cooler return filter replacement
- Rfe transmission - delayed engagement after an extended off period
- Generic scan tool - no communication with NAG1 (W5A580) transmission module
- Malfunction indicator lamp (MIL) illumination due to diagnostic trouble codes (DTCS) P0420 or P0430
- Oil pressure warning light may illuminate
- Air conditioning (a/c) cooling coil odor
- Correct shift tower sealer application to prevent restriction of vent
- Click-like sound on turns - possible cancel cam interference with turn signal
- HVAC automatic temperature control
- Front control module - disable rke horn chirp feature if fcm is replaced
- Intermittent 4WD lamp illumination or malfunction indicator lamp due to diagnostic trouble code P0573 -...
- Transmission fluid may be wicking in the right front corner of the transmission oil pan area
- New water pump for 3.7L engine - no longer common with 4.7L
- Squeak-like sound when outside door handle is used/pulled
- MIL (malfunction indicator lamp) illumination for dtc's (diagnostic trouble codes) P0750, P0755, P0760,...
- Flash: NAG1 transmission-improvements to 4-3-4 and garage shifts
- Powertrain control module initialization
- Door key cylinder may freeze and not turn in left front door exterior handle
- Idle quality, a/c performance, and 3,900 RPM limit
- Upon upshifting the 6-SPEED manual transmission into reverse, the customer may notice that reverse gear...
- Mopar accessory remote starter inoperative due to hood switch
- Extreme cold temperature start improvement and erroneous diagnostic trouble code (DTC)
- Auto headlamp feature may fail to operate as desired
- Improved driveability and erroneous diagnostic trouble codes (DTCS)
- The automatic smart beam headlamp system may not turn off the fog lamps as intended
- Erroneous diagnostic trouble code U1108 may occur if front control module is replaced on a traffic message...
- Park assist system false object detected and erroneous diagnostic trouble codes
- False downstream oxygen sensor diagnostic trouble code
- Fog lamps may fail to turn off as intended upon exiting vehicle
- Release clip not removed from power steering return hose clamps
- Structural dust cover bolt may contact oil pan
- Fog lamps may fail to turn off as intended upon exiting vehicle
- Whine-liking sound due to power steering pressure hose grounding
- Engine oil viscosity grades for 5.7L multiple displacement system (MDS)
- Growl-like sound from a/c compressor due to expansion valve
- New venture gear 140/245 transfer case fast feedback program
- New oil filter splash guard for 3.7L engine
- Generic powertrain control module (PCM) procedure
- Front and rear axle fast feedback program
- All wheel drive A580 transmission fast feedback program
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Jeep Grand Cherokee?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history