2007 Jeep Wrangler 4-DR 4x4 fuel system problems

223 complaints (38% of all complaints for this car). Typical mileage when it fails: 43,000.

owner complaints: 223
of this car's complaints: 38%
typical mileage: 43,000
crashes: 0
recalls: 0

Which part fails

Storage: tank assembly: filler pipe and cap
1
Delivery: fuel pump
1

At what mileage

Complaints by mileage at the time of the problem.

0k-25k

25k-50k

50k-75k

75k-100k

100k-125k

125k-150k

150k-175k

175k-200k

200k+

Jeep Wrangler 4-DR 4x4 fuel system problems in other years

Specific symptoms reported on the 2007 Jeep Wrangler 4-DR 4x4 fuel system

Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.

Fuel pump 7

Related recalls

No recalls on record for this model year.

Related investigations

Fuel Spill During RefuelingOpened August 23, 2010, closed February 16, 2011

ODI found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.Although the rate of complaints reported to the agency on the subject vehicles is higher than or similar to the rates experienced in previous investigations where safety recalls were conducted, ODI suspects that the federal safety agency safety complaints submitted by subject vehicles owners may have been influenced by internet related publicity both before and during this investigation.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See attached report for additional information.In addition, Chrysler is initiating a lifetime warranty program, at no cost to the consumer, to address the fuel spit back problem in approximately 135,000 model year 2007-2008 Jeep Wrangler vehicles built from March 1, 2007 to March 31, 2008.Chrysler will notify all affected vehicle owners of this action.Consumers should refer to the warranty and service bulletins and sample owner notification letter available in the investigative file.The vehicle build date can be found on the certification label located on the driver door or door jamb.

PE10032

What 2007 Jeep Wrangler 4-DR 4x4 owners say

Most recent owner complaints, unedited.

Filed Jan 29, 2019 · Fuel system · AZ

So everytime when I fill my tank its over flowing and its a really big safety issues last week I was going to work and stopped in gas station and it over filled and my suit was all gas and went to work smeling as gas. Also this can be really dangerous . In the past under the service bulletin 14-001-11 I lot of jeep owners changed this part for free but now the dealers are not changing it anymore and asking almost 1500$ to fix this issue was caused by jeep. Jeep needs to reacall this cars and pay change the gas tank

Filed Nov 23, 2018 · Fuel system · 109,000 miles · MA

When filling the gas tank fuel will spill out when the nozzle shuts off. Spilling copious amounts of fuel down the side of the vehicle all over the nozzle and my hand and creating a large puddle on the ground. This happens almost every time the vehicle is filled up.

Filed Oct 18, 2018 · Fuel system · 48,575 miles · NJ

I had service done on the gas tank but it still the gas spills out the jeep only has as 48575 miles. Their saying it back pressure this is something that should be address to the manufacturer know their telling me to 1172 dollars. For something that is wrong on the gas than I would appreciate if you can help me with this issue I'm sending the report they gave me.this started at the gas pump station

Filed Oct 30, 2017 · Fuel system · 117,000 miles · VA

Fuel does not shut off while filling tank, leading to overflow onto vehicle, ground, keys, person.

Filed Oct 24, 2017 · Fuel system · 85,000 miles · IL

For the past 5 months I've had my check engine light on. I read the code and is says "large e vap leak " I've replaced the pcv valve and the e vap charcoal canister and the check engine light is still on. I've brought it to a mechanic and they did a smoke test and everything tested out good. Showing that there were no problems and to start with the gas cap. I've spent over 100.dollars on gas caps and I still have the problem. I have to for emissions by the end of december. I've had every recall known to man on this jeep. I've done research and found out that it could be the gas filler neck itself. How to I go about getting a new one and will it cost me anything? I also have problems when I try and fill the tank. The gas comes flying back out if I try and fill it. Its getting out of hand and the dealership won't give me an answer. I was going to go to.another dealership but I want to know if this will cost me? I have until december 31 to get this problem fixed or my plates will be suspended and I won't be able to get my plate sticker. What should I do?? The check engine light comes on while stationary and while driving. This started in the middle of may.

Filed May 8, 2017 · Fuel system · 50,803 miles · TX

Parked at a gas station, refueling my jeep to the fullest causes it to choke on the gas and throws up some of it.

Filed Feb 8, 2017 · Fuel system · 55,000 miles · KS

Filling the jeep up with fuel it spits a lot of fuel out when it gets full and several times getting on my cloths and shoes. I've read that a lot of people are having the same issue. If I were to get back in the jeep and would get static and ignite my cloths and burn myself badly I don't think this would be good for anyone. I've read that certain dealers are replacing the tank for free and others aren't .is there a recall or fix in the works for this or do people have to burn up to get any action? Please advise

Filed Nov 9, 2016 · Fuel system · 123,000 miles · UT

Fuel spills out when filling tank. The shutoff on the gas pump does not prevent this from occurring. This is not an overfill but happens even when the pressure is light. This is a potential fire hazard and environmental concern. Chrysler/jeep has a tsb to correct this issue. This has been occurring since the vehicle was purchased in 2010

Filed Dec 23, 2015 · Fuel system · 76,000 miles · PA

After the gas pump shuts off, when filling your tank, the jeep wrangler will shoot out fuel all over the jeep and toward the person pumping.

Filed Dec 15, 2015 · Airbags, Fuel system · 88,000 miles · MI

Fuel over flows when filling up. Jeep shakes violently at random times. Air bag lights up and dings at random times

Questions about the 2007 Jeep Wrangler 4-DR 4x4 fuel system

Does the 2007 Jeep Wrangler 4-DR 4x4 have fuel system problems?

Owners have filed 223 complaints about the fuel system of the 2007 Jeep Wrangler 4-DR 4x4, 38% of all its complaints, more than any other problem.

At what mileage do 2007 Jeep Wrangler 4-DR 4x4 fuel system problems start?

The typical (median) mileage in owner complaints is 43,000 miles.

Was there a recall on the 2007 Jeep Wrangler 4-DR 4x4 fuel system?

There is no recall for this problem on this model year.

What year does the Jeep Wrangler 4-DR 4x4 have the most fuel system problems?

The Jeep Wrangler 4-DR 4x4 model years with the most fuel system complaints are 2007 (223 complaints), 2008 (198 complaints) and 2009 (45 complaints).