1995 Jeep Wrangler engine problems

Filed Jul 27, 2004 · Engine · 103,000 miles · VA

I purchased a 1995 jeep wrangler rio grande edition jan 2003. It had 103,000 miles on it and is in great condition. After about 6 months I started to hear a cold engine knocking in the 2.5l engine. I had mechanicls check the lower end and all looked good. I also replaced the oil pump, lifters, pushrods and rocker arms and the noise is still there until the engine warms up. I have researched this problem and have found that there was a problem with the 2.5l, and 4.0l engines that dc produced from 1991 - 1995 which is piston slap when the engines get over 70,000 miles on them. I also found a class action suite against dc concerning this problem and the consumers won with the options of a new engine, good trade in on another car or great discounts on dealer items. I called dc and also wrote a letter about my problem and this law suite. The reply I got was that basicaly sucks to be me and they were not going to do anything for me. This is a manufacture defect and they will not correct this problem. So now I either replace my engine that will cost me over 2,000 or hope and pray when I drive that it will not destroy itself. I am in the coast guard and my jeep is my transportation to and from work and I dont get alot of money that I can just throw around on a new engine when I just bought the jeep last year. If I did not like jeeps so much I would drive it to thier factory and park it there till they fix it.

Filed May 25, 2004 · Engine · 45,000 miles · IA

I am the second owner of a 1995 wrangler. Through warranty, the catalytic converter was replaced in september 1999. Less than 15k miles later, I am told the converter must be replaced again. The dealer referred me to chrysler who have offered no assistance whatsoever. If I purchase a catalytic converter, I receive a one year warranty. Chrysler provides an 8 year warranty on it from the date of "in service" of the vehicle (1995). The replacement due to no failure or misuse on my part makes no provision for any extension of the warranty and I am told no one has any discretionary authority on this matter. Apparently, the oem catalytic converter isn't worth the endorsement. Guess I won't get that second jeep - can't afford to keep up the catalytic converter purchases it requires, especially with the worthless warranty issues!

Filed Jun 25, 2003 · Engine · PA

I own a 1995 jeep wrangler, sahara model, and the question I have is that the exhaust manifold is cracked. The dealer found it and said it should be fixed or replaced for a nominal fee ($750). I elected not to have it done at that time. This was about a year ago. After further discussion with the serviceman about this he stated to me that it is a design problem and that they have repaired or replaced many of them. My question is if it is a design problem and the manufacturer is aware of it, then they should replace or repair it free of charge. What can be done to correct this problem? Am I entitled to a free replacement of the part? Please let me know if you have received any other complaints about this? I am not sure of the date but had to put something in the incident date field. Thank you for your help. Regards, darl m. Dodson, e-mail [email protected].

Filed May 27, 2003 · Acceleration, Brakes · GA · crash

While parked the vehicle emergency brake failed which caused the vehicle to roll backwards and hit a van. The vehicles fuel sensor, oxygen sensor, tp sensor and exhaust manifold studs failed. The catalytic converter also rattled. *mr *scc

Filed Jan 6, 2003 · Engine · 110,000 miles · NY

While driving, consumer heard a snapping noise from the right front of the vehicle. Consumer had vehicle serviced by a mechanic who indicated that the engine mount stand bolt had broken off, and this is a common problem with these make/model vehicle. Ph

Filed Dec 10, 2002 · Engine · PA

While vehicle was sitting in park with engine off and emergency brake engaged. Consumer states' vehicle rolled backards into a parked vehicle. Please provide any further information. Ts

Filed Oct 17, 2002 · Engine · CO

Consumer states vehicle was on a hill in park with engine on, when vehicle suddenly began to roll backwards. Cause is unknown. Please provide any further information. Ts

Filed Oct 14, 2002 · Engine · MA

This is the third cat I have had to place on this automobile. The dealership replaced the first two, all failing at about the time 50,000 miles comes around. The dealership stated that there was a problem with these, and replaced the first two free of charge. Now another dealership states they know nothing about a problem with these. The inside of the cat comes loose, blocking the exhaust, hindering performance. Also noted by a noisy metal rattling noise while at idle or under acceleration. Mr

Filed Oct 4, 2002 · Engine · OH

Consumer stated the exhaust manifold studs are fatiguing and breaking.

Filed Sep 20, 2001 · Engine · CO

A bolt from manifold sheared off. Dealer notified, and informed consumer that vehicle was not covered under a manufacturer's recall, and warranty expired. Feel free to provide any further information.