1997 Jeep Wrangler technical service bulletins
84 technical service bulletins and manufacturer communications cover the 1997 Jeep Wrangler.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Charging System, Battery Diagnostic Tools and Warranty
- DIPAP Requirements
- Repair Parts Used For Structural Repairs
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- Valve Body
- Steering shimmy
- Reprogram PCM and inspect catalytic converter
- Primary door weatherstrip water leak at a-pillar belt line
- Automatic transmission diagnostic teardown procedure
- Air conditioning (a/c) cooling coil odor
- Dirt and debris accumulation at rear main seal
- Soft top zipper cleaner and lubricant - for difficult to operate window zippers
- HVAC drive water leaks under passenger side front carpet
- Flash programming failure recovery
- Customers may complain that the HVAC drain water leaks under passenger side carpet
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty
- Subject regarding generic scan tool (GST), publication no
- Automatic transmission fluid usage ATF+4
- Subject regarding wire splice repairs
- Subject regarding non-deployed airbag handling procedures
- This bulletin provides a revised wire splice procedure and related parts
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes P1494, P0442...
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles
- Information regarding the improved door weather strip
- Vehicles may experience water dripping from the bottom of the evaporator drain tube and enter the...
- This bulletin pertains to front end alignment - adjustable / offset ball joints
- This bulletin explains the operation and application of the leak detection pump (LDP) monitor test
- Vehicles exhibiting buzz, whining, or moaning like noise from cold transmission when reverse gear is selected
- Subject on water leak diagnostic / repair procedures
- Information regarding power distribution center (PDC) service
- Subject regarding airbag on - off switches
- Outer exhaust manifold studs may fatigue/break
- A thumping or creaking noise may be heard coming from the transmission tunnel area on acceleration or...
- Subject regarding i/m ( inspection maintenance ) testing - OBD II "carb" readiness monitor information
- Subject on flash programming failure recovery
- Subject regarding the airbag on-off switches
- Exhibiting minor brake pedal pulstion which may be caused by rough disc rotors
- Information to assist in identifying water leak entry points by highlighting areas where leaks are likely...
- Subject regarding safety recall -- fuel tank sending unit
- The outer exhaust manifold studs may fatigue and break
- A squeak or buzz coming from the hood of the vehicle
- A squawking or scrapping noise coming from the steering column which may be confused with clock spring or...
- Information on the OBD II misfire montior
- A squeaking noise may be heard when the system mode is changed from floor to panel or defrost
- Service caution on powertrain control module ( PCM )
- A squeaking noise heard in the front seat
- Information on installation of radio transmitting equipment
- A squeaking noise may be present when the system mode is changed from floor to panel heating
- A rattling or knocking noise may be present when driving over rough roads, noise was coming from rear of...
- Subject pertaining to OBD II misfire monitor
- Conditions on OBD II misfire monitor
- A popping or creaking noise may be present in the floor area
- Information on poor drivability with high di (drivability index) fuel
- This bulletin involves water leaking from the heater a/c housing
- Information on a/c refrigerant leaks
- Authorized airbag deactivation for medical necessity
- INFORMATION REGARDING the federal safety agency AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. NLM
- Consumer may complain of door latch binding
- Concerns with fuel gauge not reading accurately
- Information regarding fuel gauge accuracy
- Conditions with the odometer display may flash when the emergency flashers are activated
- Concerns with odometer led's flash when emergency flashers are activated
- Concerns with a/c evaporator odor
- Information on fuel pump diagnosis
- Fuel tank may be slow to fill
- Clicking noise in the steering column when the steering wheel is turned
- Hood contacts fender
- Information on tire and wheel runout
- This bulletin involves fuel gauge accuracy
- Information on windshield stress cracks
- Rough running engine with hex codes $28, $6A, $9B or $ba. tw
- Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of...
- Concerns with engine coolant usage
- Frame improvements to address customer's issues with the soft top
- Concerns with erroneous MIL illumination
- Air bag warning labels
- Difficult to clean light colored "chalky" residue from plastic body components that are molded in black
- Jtec powertrain control module wiring harness connector repair packages
- Water leak at front passenger compartment floor- water from the a/c evaporator drain tube may run back on...
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history