1998 Jeep Wrangler suspension problems

Filed Aug 27, 2019 · Suspension · 178,000 miles · KY

Jeep tj frame separated at the torsion bar on passenger rear wheel making vehicle unstable and un- usable.

Filed Jan 5, 2019 · Body, Brakes · 69,000 miles · GA

I have a 1998 jeep wrangler. I've owned my jeep for 15 years. It has been garage kept. We were changing the shocks a few weeks ago and noticed severe rust damage. The frame is rusting from the inside out. It's severe. Years before I was traveling down a 2 land rd and had to press my brakes harder than I usually would due to a car pulling out in front of me. At that moment I blew a brake line. I could not get my vehicle stopped. Luckily it's a 5 speed. I geared down as fast as I could and managed to pull it off the main road onto a hill to get it stopped. After inspecting my vehicle I found severe damage. The motors mounts are barely there. The part where the frame mounts to the body is actually missing one due to rusting completely out. Every single bolt and nut is rusted. Every single square inch of the frame is rusted. The problem is that jeep poorly designed the frame with side holes for water and dirt to enter but did not design it with drainage holes on the bottom of the frame. Water and dirt enter and never leave. It's extremely unsafe to drive. I've read thousands of complaints online and this is a very common problem.

Filed Dec 27, 2017 · Suspension · 96,000 miles · PA

"tj wrangler frame rust" - severe rust occurred in the frame of my 1998 jeep wrangler. Vehicle would no longer pass pa state inspection. Rust was due to no drainage hole and frame rusted from inside out. Rust occurred on both driver and passenger sides just in front of the rear control arms and extended front to the transfer case mounting points. I have researched this issue and it is very common and many poor jeep owners are parting out perfectly good jeeps due to them not being able to pass state inspections - luckily no one has been harmed due to this frame damage that I am aware of - some videos on the internet show the entire frame rusted away! This needs to be brought to the attention of jeep as this is obvious a design flaw and owners should be compensated. If there is any doubt of how severe this is simple do a google search! Toyota took care of their customers!!!

Filed Jul 3, 2015 · Body, Suspension · 100,000 miles · MI

The rust is so bad on the jeeps it's ridiculous it's not safe your going to kill someone when there rear axle shoots out from under them this is a issue you should fix not the consumer I will not be buying this product again if it is my fixed. 98 tj jeep wrangler

Filed Apr 29, 2015 · Body, Suspension · 99,945 miles · PA

Due to excessive rot that is common on this vehicle, while traveling I hit a bump and snapped my driver side control arm. This consequently made for a dangerous ride. While attempting to repair it I noticed how bad the frame was rotted, but unlike normal circumstances where the outside and inside would have equal corrosion. The inside was rotted much worse, and parts of the frame easily crumbled.

Filed Mar 29, 2015 · Body, Suspension · 128,000 miles · WV

The frame around the control arms are rusting, this could be a serious problem that needs addressed and there are more 97-06 wranglers with rusted frames than not.

Filed Mar 18, 2014 · Body, Suspension · 112,000 miles · IN

Noticed a noise while driving home the other day thought it may have been my exhaust rattling around, so I got under vehicle to inspect the noise, and what I found was that the rear part of the frame has rusted away and the brackets for the rear trailing arms had detached from the frame allowing the arms to drop, and on this particular side the brake lines are attached to this control arm. I know that toyota had a similar recall on the truck frames for rust perforation, and that jeep had one on the liberty for the rear lower control arms rusting and breaking. I am an automotive technician and my personal jeep is not the first one I have seen with this potentially dangerous condition. I also googled this problem and found that its very common in these vehicles as well.

Filed Apr 3, 2013 · Body, Suspension · 107,000 miles · NY

The frame is rotten out, and this is a common problem with the jeep tj's. I have a hole on my tail section of frame and on the rear control arm area.

Filed Oct 28, 2012 · Steering, Suspension · 150,000 miles · CA

Death wobble, front end shakes violently at higher freeway speeds. Very fearful to drive on other than streets. Has happened several times the last 2 years. Purchased jeep used 5 years ago but only started to have wobble last 2 years since im retired and don't drive long distances very often and not don't want to drive anywhere that requires me to use freeways.

Filed Jul 13, 2012 · Steering, Suspension · 104,251 miles · CA

Jeep death wobble. Scary!