When filling the fuel on the 2007 jeep wrangler, after the automatic shut off of the pump, fuel spills out of the filler neck covering the side of the jeep.
2007 Jeep Wrangler fuel system complaints
Page 4 of 5: complaints 71 to 100 of 114, newest first, as owners wrote them.
Fuel tank overflows when filling the vehicle with gas. The rollover check valve does not engage to stop the gas pump.
When filling up, gas overflows out of filler neck. Does not matter about fuel flow being fast or slow.
Just purchased this jeep used, excellent condition few days ago jan. 2012. Major fuel spitting back upon filling the tank. The pump shuts off as expected and then there is a huge gush of gas that comes out after all over me, the side of jeep, and all over the ground. This is a huge safety issue and a fire concern! The second attempt at fueling I tried slowing the speed of gas and not filling all the way --- same thing happened. Jeep dealer acts they've never heard of this. A lie. I've emailed chrysler and they also are acting like they don't know anything about it even though I have a copy of a letter they have sent to previous owners about it stating they would repair this fuel spitback issue. Apparently, my previous owner did nothing! I've now read all of the reports and claims. Too bad we didn't know this before. I am afraid to put my family in this jeep and we haven't even had it for a week. You don't think it's a recall? I need this fixed! What will it take for you to issue a recall? A fire, explosion? Or do you need to wait for a death first? Would you like a video of this fuel spitting back out of the side of my new jeep? I would be glad to film it for you as proof! It's not just a little fuel --- it's a gush! Wake up, okay? I am a new owner and nobody and no internet sites or social media b.s. Is influencing me. I need help and so does everyone else with this extremely dangerous issue.
I just bought jeep used. First time I filled up the pump cut off and then there was a surge of gas that spewed out. On second refill today at a different station with new pumps same thing happened gas spewed under such force it would have gotten in eyes had I not had sunglasses on. Spillage was over a liter and was all over clothing and attendant had to spread absorbent.
The gas tank overflows every time it is filled and spills gas on operator and ground.
During fueling, after the auto-shutoff of the fuel pump stops the fuel dispensing, fuel overflows (approx. 1/2-1 gallon) from the fuel tank past the still in-place pump handle causing fuel to spill on the side of the vehicle, the ground, and on anyone standing directly beside the fuel inlet.
Fuel overflows from tank when filling vehicle.
When filling the gas tank, the tank will overfill every time that the fuel hose handle is allowed to cut off automatically. Gas will then splash down the side of the jeep and on to the ground.
Bought this jeep used in feb 2011. It spills fuel everywhere during fill up at gas pump when nozzle cuts off. It happens every time and at multiple stations. I have to usually only put 15-18 gallons in to prevent it from spilling over. There have been numerous times it has spit and spilled on myself or my wife during fueling.
This vehicle has had a problem with the gas tank overflowing since it was almost new. Jeep has refused to recognize that this is a design flaw and refuses to take responsibility for the environmental and safety hazard that this flaw causes each and every time these jeeps are fueled up. At the point of filling up, the gas tank overflows sending large amounts of gas on the side of the jeep and onto the ground. This is a terrible fire and environmental hazard that could lead to public injury and even death if it caused a fire. I would be happy to provide a video of this problem occurring if needed to get this addressed. Absent action being taken here, I am not sure where to turn other than mainstream media to get action to be taken.
Fuel overflows every time I visit the gas station. Each gas station pump auto shutoff works properly but fuel always spills over. It is dangerous and should be addressed.
Vehicle was just purchased certified pre-owned. Vehicle came with a full tank of gasoline. While re-filling at a gas station for the first time, the tank filled normally. As soon as the fuel reached the nozzle end I heard the nozzle click off. Then approximately half a gallon of fuel sprayed out the end of the fill tube. The fuel ran all over the side of the jeep and also sprayed onto my pant leg and shoe. I have since looked this issue up online in jeep owner's forums and found this to be a huge problem among so many of these models. Not only is this a tremendous safety issue, but also an environmental issue as well. It is obvious that the tank is not vented properly. This issue needs immediate attention before a tragic event occurs. Earlier in this form I was asked if a fire occurred I answered no. Thank god this time there was not. This defect not unlike throwing lit matches at a gas pump.
When filling the gas tank at the pump the tank overfills before the pump shuts off. This problem occurs at almost every pump with any angle and depth of nozzle. I have seen many complaints about the same issue on many jeep forums.
Tl* the contact owns a 2007 jeep wrangler. The contact stated that when the vehicle was full with gasoline fuel it would spill out abnormally. The failure was not inspected by a dealer nor was the vehicle repaired. The failure mileage was unknown, but the current mileage was 54,713.
Tl* the contact owns a 2007 jeep wrangler. The contact stated that while refueling, fuel would spill out from the filler neck. An authorized dealer and the manufacturer were notified, but denied any assistance with repairs. The vehicle was not repaired. The failure mileage was 75,000 and the current mileage was 92,000.
Tl* the contact owns a 2007 jeep wrangler. The contact was driving approximately 50 to 60 MPH when the steering began shaking violently. The contact had to continuously apply the brakes in order to maintain control of the vehicle. In addition, when refueling the vehicle, fuel would spill back out from the fuel tank. The vehicle was not taken to the dealer for diagnosis or repairs. The manufacturer was contact but denied assistance with repairs. The failure mileage was 50,000 and the current mileage was 59,000. Form returned no change
While filling jeep with gas for the first time since I purchased used, gas overflowed from tank, gas pump did not shut off until gas was spilling out. I informed the gas station attendant, thinking it was a gas pump problem. Since then, I have filled up at several different stations, and the problem has happened every time unless we slowly pump the gas in as the tank fills.
Fuel splash back when pump set on auto shut off, lowest setting. Will loose 2 - 6 oz. Fuel on to side of vehicle and often enough to splash on drive. Dealer doesn't seem to know anything about ongoing problem.
My vehicle spills fuel out of the filler area every time I fill up. The fuel gets on me, the vehicle, and the ground. I have contacted chrysler about the matter, and they advise me because I am outside the time frame for their tsb, any repairs would have to be paid by me. After thoroughly researching the matter, it seems this is a wide spread concern. Chrysler has addressed the issue for some, but not others because "we're outside the window". Please see your code #pe10032. Also, my vehicle consumes or burns oil at the rate of one quart per 1000 miles. Again, research shows this is another wide spread matter attributed to faulty motor construction of some 2007/2008 engines. Owners who have had the repair done under warranty found that on three pistons, ring gaps where in a line, the other three where close, all six oil expander rings and piston rods where installed upside down. Chrysler will address the matter only if you are still under warranty. I do not understand why the cost should be bared by the consumer when both matters are so common and wide spread as to indicate design flaws in the product. Why should I pay for their inability to build a component correctly?
While pumping fuel to the vehicle. The gas nozzle clicks and shuts off fuel when gas tank is full. The vehicle will burst fuel back out. Spilling all over side of vehicle and on to the floor. When I pump gas I have to make sure I don't fill gas tank to full or the problem will continue. It happens all the time and in different gasoline stations.
When refueling the vehicle, the automatic shutoff does not engage from the vehicle itself. Fuel (about a quart) continues to flow and out and all over the side of the vehicle. It also sprays out and on the personnel fueling the vehicle. There is a tsb 14-001-11 from jeep about the issue, and I request this be repaired under warranty. It is unsafe for the operator to have fuel sprayed on them, and have fuel spillage on the ground.
My build date on my jeep sahara was 10/2006. It started shooting gas back out the fill pipe app. A year after I purchased it and it is still doing it almost every time I fill it up regardless of the gas station or the speed the pump is pumping (slow medium or fast).it has shot gas out as far as a foot from the jeep, spraying on me a couple different times. I have been informed that some jeeps after a build date from march 2007 thru 2008 are being repaired by the dealer. I would like to know why the earlier build dates are not since it is the same problem.
Every time I fill up my gas tank the fuel will overflow as much as a quart out of the fuel inlet down my rear fender, bumper, and to the ground after releasing the gas spout handle stopping the flow of fuel.
Gas tank overfill. When fueling, after the gas station pump clicks off, large volumes of gasoline are ejected from the gas tank onto the side of the vehicle, onto the pump handle itself, and onto the person doing the fueling (me). Again, this happens *after* the gas pump clicks itself off.
When fueling at automatic cut off gas pumps fuel will splash back out of filler neck on persons , fender and ground before tank is full and pump cuts off
Every time I fill up the gas tank no matter where I am spillage occurs after the automatic shut off. Jeep was around 2 years old when this started happening.
Gas surges out of gas tank shortly after the automatic shut-off on gas pump activates. Several cups of gasoline pour down the side of the car and puddles on the ground. This happens every time I fill my car at every gas station. I now only fill my car to approximately 3/4 full. It started happening fall of 2010 with approximately 37,000 miles on the car. This has happened about 10-12 times.
This is a recurring problem that I face when I fill the vehicle up at any gas station. While filling the vehicle with gas, the auto stop clicks, and immediately the tank starts spilling gas. The gas spills out and runs down the side of the vehicle and onto the ground creating a puddle. This problem isn't attributable to trying to "top off" the tank because the by the first time the auto stop clicks, the vehicle is already pouring out gasoline. I have spoken to many other owners regarding this problem and they have said the same thing. I have investigated through the federal safety agency, and they have an ongoing investigation into this matter (action number : pe10032).
When refueling, a significant amount of gasoline spilled out after the pump automatically shut off. Within a second or 2 of the pump shutting off gas then flowed out of the tank filler tube. It splashed all over my pants and shoes along with the car itself.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history