I am the owner of a 2020 Jeep Wrangler JL with the 2.0L turbo engine, and I am writing to report a fuel leak issue that I believe is related to Recall Y10 / the federal safety agency Campaign 21V‑665, which involves the high-pressure fuel supply line (Part #68297642AD). My vehicle is experiencing a strong fuel smell and visible fuel leak, and a technician confirmed the failure of the fuel line. However, my VIN does not currently show as included in the recall, and I have been told the repair is not covered under warranty. Given that my Jeep has the same engine, same part number, and identical symptoms described in the official recall — I’m requesting one of the following: That the dealer be allowed to inspect the fuel line’s date code and replace it under Recall Y10 if it falls within the affected range, or That Jeep/Stellantis cover the cost of the repair as a goodwill safety-related assistance, since the failure occurred outside the normal warranty but is consistent with the recall defect. I take safety very seriously, and I hope Jeep does too. Please let me know what documentation or diagnostics you need from my service provider to support this request.
2020 Jeep Wrangler fuel system complaints
Page 2 of 3: complaints 11 to 40 of 43, newest first, as owners wrote them.
There was a crack, and subsequent leak, in the fuel line to the engine. My safety, and my passengers safety was absolutely put at risk as that could have ignited a fire at any moment. I took the vehicle to an independent mechanic who diagnosed the problem. No warning lamps appeared, however, the smell of gas was very strong in and near the vehicle.
I am the owner of a 2020 Jeep Wrangler JL with the 2.0L turbo engine, and I am writing to report a fuel leak issue that I believe is related to Recall Y10 / the federal safety agency Campaign 21V‑665, which involves the high-pressure fuel supply line (Part #68297642AD). My vehicle is experiencing a strong fuel smell and visible fuel leak, and a technician confirmed the failure of the fuel line. However, my VIN does not currently show as included in the recall, and I have been told the repair is not covered under warranty. Given that my Jeep has the same engine, same part number, and identical symptoms described in the official recall — I’m requesting one of the following: That the dealer be allowed to inspect the fuel line’s date code and replace it under Recall Y10 if it falls within the affected range, or That Jeep/Stellantis cover the cost of the repair as a goodwill safety-related assistance, since the failure occurred outside the normal warranty but is consistent with the recall defect. I take safety very seriously, and I hope Jeep does too. Please let me know what documentation or diagnostics you need from my service provider to support this request.
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at undisclosed speeds, there was an abnormal fuel burning odor coming from the engine and entering the vehicle through the A/C vents. There was no warning light illuminated. The vehicle was taken to an independent mechanic where the vehicle was diagnosed, and the contact was informed that the fuel supply line was faulty and needed to be replaced. The contact related the failure to the federal safety agency Campaign Number: 21V665000 (FUEL SYSTEM, GASOLINE). The manufacturer was made aware of the failure. The failure mileage was approximately 22,000.
The contact owns a 2020 Jeep Wrangler. The contact stated that occasionally while driving at various speeds, there was an abnormal gasoline odor entering the cabin of the vehicle. There was no warning light illuminated. The vehicle was taken to a local independent mechanic where the vehicle was diagnosed, and the contact was informed that the fuel supply line was faulty and needed to be replaced. The vehicle was not repaired. The contact referenced the federal safety agency Campaign Number: 21V665000 (FUEL SYSTEM, GASOLINE); as a possible cause for the failure. The manufacturer was not made aware of the failure. The approximate failure mileage was 58,000.
Digital display that shows speed and fuel level stops working and goes black while driving. Happened in 2024 and the display was replaced at my cost. New display experienced the same blackout in January 2025. Manufacturer is unable to deliver a new replacement display to their dealership to fix the vehicle. It has been almost 5 months without any resolution in sight. Other owners who have used my carwash have mentioned similar experience
The instrument panel cluster in the 2020 Wrangler Sahara seems to have failed. As such, the driver cannot read the gas gauge, tire air pressure, and other vital metrics. There is a recall on this issue (30B), however my VIN is not included. I would kindly ask to see if my VIN should be included. The Wrangler has approximately 57,000 miles. This problem has been diagnosed by Capitol Garage in Willimantic, CT, Gary Bennett (Service Advisor). 860‑786‑4759 Jeep Customer Care Case # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Had gas leak on lower part of engine leaking gas from the high pressure fuel line took it to a dealer ro so the repairs Jan 29th 2025 and my jeep is still not right ..it had no mechanical problems at all except the leak and now they have had to replace the reservoir for coolant due to broken damaged line and the vehicle has no power at all since the dealership has had possession of my vehicle ...it is the 2.0 liter turbo
I am experiencing a recurring issue with my vehicle’s gas cap. The check engine light continues to come on due to the gas cap, and this has happened multiple times. This is the third occurrence this year, and despite ensuring that the cap is properly secured, the issue persists. I am concerned that this may indicate a defect in the gas cap or an issue with the sealing mechanism. I would appreciate any assistance in determining whether this is part of a known recall or if there is a recommended fix.
In the document (ZD8), although my VIN does not appear, I have unfortunately encountered the SAME EXACT problem. My Jeep first exhibited this issue back in 2022, and I managed to repair it at that time without being aware of the existing recall. As it stands, my vehicle is now at the dealership again, plagued by the SAME recurring issue. In trying to resolve this, I have tirelessly reached out to every dealership within a 75-mile radius of Katy. However, none of them have the requisite part(s) available in their inventory. To worsen the situation, I have been informed that I would be placed on an exceptionally lengthy waiting list. I strongly urge you to conduct a thorough reevaluation since it's apparent that this issue extends beyond the limited number of VINs currently covered in the document. At one distressing moment, this defect triggered a heart-stopping warning while I was driving on the highway: “Find a safe place to pull over; your vehicle is about to turn off.” Furthermore, this is the second occasion on which I have been compelled to address and replace the same issue. This situation is increasingly untenable, and it's vital that comprehensive action is taken to address this widespread problem rather than limiting focus to just the few VINs listed in file (ZD8).
Smelling raw gas..took to mechanic and it has a cracked fuel line and bad connector on it ..it is pouring gas oit and has been undrivable for over 4 weeks it has the 2.0 liter motor In it ...
Loss of power. Vehicle went into limp mode. Codes P00AF, P24B1 and P1DB1. Vehicle only has 28,500 miles and is having constant electrical issues.
Dealership diagnosed leaking fuel line to engine - exact same issue as Y10 Recall, but my VIN is not covered. I would like my VIN included in the Recall.
Fuel supply connect locking device failure. Attempted to start vehicle and fuel leaked beneath mid section of vehicle about a gallon. Engine was cold as well as exhaust and caticlic converter. Safety Hazard to occupants fire/explosion. Vehicle towed to Oak Harbor, Washington dealership for repair. Safety retaining clips missing which allowed fuel lines to open and leakage.
I have been on multiple wait lists to have the recall correction for the HPFP, but the dealers I have contacted in the Fresno area have told me they have not received the parts to make the correction. I’ve been on these waitlists for well over a year with no updates.
Strong gas smells inside and outside if the vehicle.
The fuel supply line leading from the gas tank, along the passenger side of the transmission, and over the top of the transmission bell housing has failed and is leaking gas onto the transmission and then onto the ground. This is a dangerous fire hazard and placed my safety at risk. I have not yet taken the vehicle to a repair facility as I live over 30 minutes away from the nearest dealership. I am the only person that has inspected the vehicle and observed the leak using a remote camera as of the filing of this complaint on 7-18-24 at 1:30 pm. There were no warning lamps or messages associated with this part failure. I could smell a strong odor of gasoline fumes from within the vehicle which prompted me to inspect what the source was. As I understand, a previous recall for this part failure was issued in 2021, but did not include my VIN.
The contact owns a 2020 Jeep Wrangler. The contact stated that when the vehicle was started, there was an abnormal gasoline odor detected. The contact inspected the vehicle and became aware that gasoline was dripping underneath the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with a faulty fuel hose that was connected to the rear of the engine. The contact was informed that the fuel hose needed to be replaced. The contact was advised to take the vehicle to the dealer for the repair. The vehicle was not repaired. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,200.
An internal defect in the 2014-2020 Jeep Wranglers with the 3.6L Pentastar V6 engine affects its rocker arms, lifters, and related valvetrain components, including the engine control module (ECM) software that controls the precise timing and function of the lifters. Specifically, the rollers of a Pentastar engine’s rocker arms prematurely wear down, become loose, and then drop, which shifts the rocker arm out of alignment. The rocker arms then come into contact with the cam, scraping both components and creating metal debris. This Pentastar V6 engine defect creates an audible ticking sound that stems from metal particles and debris from the failed rocker arms and other components, contaminating the engine oil and circulating throughout the engine. This defect also causes engine misfires, resulting in bucking and surging, decreased engine performance, hesitation, loss of power, premature wear on internal components, and eventually catastrophic engine failure. The check engine light came on in my 2020 Jeep Wrangler with 69,000 miles. After having it read by a dealer, it showed the P219A code, Bank 1 air/fuel imbalance. The dealership told me that if the Jeep was running fine, I did not have to worry about it, as it was likely an O2 sensor. The code was cleared, and the P219A code returned the following day. It was driven approximately 500 miles before noticing that it began idling roughly and had an engine tick, which the dealership confirmed to be a valvetrain issue. The rocker arms, lifters, valves, and camshaft components of the Pentastar V6 engine in my 2020 Jeep Wrangler with 70,000 miles have failed. Three Jeep dealerships in my area and MANY online forums stated that this is a common occurrence with this engine, which has escalated my concern about this problem.
Vehicle started to get extreme smell of gas fumes, interior and exterior, to the point it would make you nauseous. My vehicle was taken to a dealer where the tech noticed that a fuel pump was leaking and a fuel line behind the engine had a small hole in it and was leaking on the top and was unlikely debris hit it, to get at the line the whole motor has to get dropped. After reading the description of the fuel line/pump issues with the 2020 2.0 L, this seems that it would be related and part of the effected parts.
The contact's partner owns a 2020 Jeep Wrangler. The contact received notification of the federal safety agency Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2020 Jeep Wrangler. The contact stated while his son was driving approximately 35 MPH, he turned on the air conditioning and the blower filled the cabin with a gasoline odor. The contact stated no warning light was illuminated. The contact stated was made aware of the issue by his son. The contact checked underneath the vehicle and became aware that there was a fuel leak running down the length of the fuel supply line and was dripping on the driveway. The contact had not taken the vehicle to a local dealer; however, the contact called the dealer and was informed there were no available appointments for two months. The vehicle had not been repaired and had not been driven. The contact researched online and related the failure to the federal safety agency Campaign Number: 21V665000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 32,500.
The contact owns a 2020 Jeep Wrangler. The contact received notification of the federal safety agency Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
I just purchased my 4th Wrangler last month from a dealership - a 2020 Certified Pre-Owned Unlimited Sport Willys 2.0L with Automatic transmission. Within the first days, I noticed odor of fuel or exhaust that would be more obvious some times than others, and not constantly strong or apparent. At first I thought maybe it was from being in garage at dealer and something on a mat, but then it continued and was more apparent if I had the windows closed and the heat on. Called the dealer two weeks ago and got an appointment to have it checked this past Friday. First I was told I’m probably not used to it if it’s my first “turbo” (which made no sense), then they came back to tell me it’s probably dirty air filters (which they should’ve checked/changed when they inspected it before selling it because it was at 31,200mi). Then they decided to take it for a ride and, lo and behold, they smelled what I have been smelling. They put it back on the lift to look again. Diagnosis: Fuel leak from the connector to the high pressure fuel line. I see there were some JLs with 2.0L manufactured the same year recalled for this, but they insisted mine wasn’t. Search online confirms it’s not included in the recall. I had no luck getting anywhere when I called Jeep customer service either. The dealer wants to charge me my extended warranty deductible when I haven’t even made my first payment on it yet. (According to vehicle records, 3 years for manufacturer warranty was up Nov 2022, and it has less than 32,500mi.) They insisted they keep it while waiting for the part for repair because it’s unsafe to drive, and put me in a rental (which they told me they didn’t have available when I asked for the appointment). I think this is clearly a safety issue consistent with other recalls for this model and should be repaired at no cost to me. Perhaps the initial recall didn’t include all the vehicles it should have.
I am having a stalling issue when driving down the road. its not a constant issue but will occasionally stall/stop accelerating. you will have to let off the pedal and push down again. it will gain power back right after and be fine. believe it possibly a fuel pump issue or tps problem.
I was driving my vehicle on the expressway and a dash light with an “A” and a circle came on. My car began to slow down on its own and would not allow me to accelerate. I managed to coast off the expressway to an exit. I immediately smelled gas and my eyes began to burn. I tried to restart my car but it was sputtering. I checked under the hood and the car smelled like strong gas. After this my eyes were burning as if someone sprayed pepper spray in them. I had get assistance to get a tow. I went to a nearby urgent care to get my eyes checked out because after all of this they were blood shot red….I see that some 2020 2.0L Jeeps have a fuel line recall but my recall isn’t showing up. This vehicle should definitely have a recall. I also have issues with my radio saying “overheating” then the volume goes out and the radio shuts off.
The contact owns a 2020 Jeep Wrangler. The contact stated that there was a strong fuel odor inside and outside of the vehicle. There was no warning light illuminated. The contact stated that the fuel odor had become stronger over time. The vehicle was taken to an independent mechanic, where it was diagnosed that the fuel supply line connector was fractured and leaking fuel. The mechanic related the failure to the federal safety agency Campaign Number: 21V665000 (Fuel System, Gasoline). The dealer and the manufacturer were notified of the failure and informed the contact the vehicle could not be repaired under the recall as the VIN was not included. The vehicle was not repaired. The failure mileage was approximately 84,000.
Fuel line ruptured above fuel tank causing diesel fuel to pour out while driving. Driver was unaware of the issue. Rear of vehicle and spare tire were covered In diesel fuel. No impact caused this issue and could have caused a fire.
Our jeep has smelled of gas since our first week. We were told is was normal, when the tank is just filled or nearly empty, However It happpens all the time and I see that 14,000 2020 jeep wranglers were recalled. Not mine as I guess I have the larger engine. We do not smell it when the windows are up, but in good weather with windows down or top off, is it extremely disconcerting at stop lights. And we cannot park in a garage to be safe,
The contact owns a 2020 Jeep Wrangler. The contact received notification of the federal safety agency Campaign Number: 21V665000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history