While driving a vehicle swerved into my lane, to avoid hitting them I tapped my brakes, upon tapping my breaks the Jeep lost propulsion and it felt as though my brakes lost power as well. I had to coast into a parking lot where I didn’t even make it to a spot and had to be towed to the dealer. The Jeep would no longer start and gave a “service charging system” message. Upon inspection the dealer stated that Chrysler immediately shipped a power inverter module (pim) upon my Jeep being entered into the system. Since my issue, I have seen 3 other 4XE Jeeps pulled over and broken down in precarious positions. This is what prompted me to file this report, as I believe this may be an issue related to other 4XE Jeeps and if this is the case, it is only a matter of time before an accident that causes loss of life because of how severe and sudden the issue is. Thanks for looking out for our well being and everything y’all do at the federal safety agency.
2021 Jeep Wrangler engine complaints
Page 8 of 9: complaints 191 to 220 of 227, newest first, as owners wrote them.
Driving on highway at posted speed of 70 mph in state of Michigan and jeep quit running I had 3/4 tank of fuel and 37% battery power remaining got it restarted made it to a gas station shut off jeep filled with gas and jeep wouldn’t come back online said charging port malfunction so I open charge door and didn’t see any thing in the removed negative side of 12 volt battery underneath the hood waited for 3 mins reinstalled battery terminal and was able to get it started but the temp controls only work on extreme hot or extreme cold no in between drove back home approximately 150 with check engine light on after several power down and restart the check engine light went away and all went back to normal again
Jeep wrangler Sahara 2021 4xe is brand new leased and driven off the lot the previous day with 35 miles on the car and one full charge overnight. Car was going down a hill with Max Regeneration engaged. It lost power and said place in Park. It states service charging system and there is an engine fault and the car will not start will not go into neutral to move to a safe location and it stuck in the center of a busy road placing myself the driver at extreme risk.
While driving approximately 35 miles an hour while on E save with max regeneration enabled, the car cut all power, RPM went to zero, service charging system error displayed on dash. Once able to get car off of Road, was able to restart. The Uconnect app does show a charging system fault, once plugged in charging system does charge, per dealer new error codes report to substantiate failure of power.
Vehicle was purchased on 5/22/2021 from dealer as new vehicle purchases (lease). On 5/23 less than 24 hours after delivery with 76 miles on the ODO, I got a (CEL) and numerous errors (service hybrid electrical vehicle system, service 4wheel drive system, vehicle charge fault with a red charge cord light indicator). Vehicle was returned to dealer on Monday morning with notice of issues. They diagnosed the vehicle for 1 day and returned it to me to continue to drive while they ordered parts. Vehicle was diagnosed with a P0AA6-00 “Hybrid Battery Voltage System Isolation Fault.” Dealer stated vehicle was safe to drive and would contact when parts were received. On 6/08 vehicle was returned to service for incoming parts at 575 miles. Dealer stated FCA advised them to replace the Indicator lamp module but did not correct the issue and they could not return the vehicle to me as they stated "FCA said vehicle can not be placed back on road as it may catch fire or explode". Vehicle has been at the dealer with no return since 6/8/2021. They have changed 1 indicator lamp module, 2 battery heater/chiller modules, 3 PHEV main wire harnesses and have requested a 4th as they have not been able to make the previous 3 work/function. Vehicle has now been down 7months with now successful repair and parts not available until 1/02/2022 at the earliest. And vehicle now sits with 17 unresolved trouble codes.
My 2021 Jeep Wrangler with 1900 miles caught on fire and was a total loss, preliminary investigation believes the cause of the fire to be a gas leak. There were no indications or warning lights, saw black smoke coming from the engine compartment by the time I pulled over and got out of the vehicle it was on fire and within minutes the entire car was engulfed by flames and it was a total loss
I was driving normally along a busy road at 40mph. Suddenly, the car stalled and I could not accelerate. I coasted until it completely stopped in the middle of a busy road. I was unable to move the car, and instead had to put the car in park and turn off the engine. The "D" light on the gear shifter was blinking, and then the battery on the car went from 55% charge down to 47% charge. A red lightning bolt emergency sign came on but then went off immediately after. With the car off in the middle of the road, I restarted it hoping for the best. Luckily, it did restart fine and I could continue driving. However, I have heard on Jeep 4xe forums that this is an issue with many other owners, some even happening on the interstates. I am now too afraid to drive this car with my child or for long distances, because this issue was completely spontaneous and unpredictable. I took it to the dealer to be serviced, but they are unsure what is going on. And as a side note, this is a brand new car (2021 year) with 105 miles. I only had it for FIVE days before this happened. Prior to this incident I also noticed that the charge would not hold very long at all - for example, driving it today 3.4 miles from one point to the dealer, the charge went from 47% to 17% - this should not be normal. Overall this issue is unacceptable and this needs to be addressed immediately before people die. Thanks for your consideration.
I left my daughters house with my jeep wrangler and as I shifted into forward gear there was no power on my wrangler 4XE hybrid. I move the vehicle to the side of the road and towed it to the dealers. After a little over two weeks they got it repaired. After that I have read reports of this kind of thing happening in traffic. When I lost power the engine light and stability control light came on. It is now repaired but I’m having second thoughts about the safety of the vehicle since I sometimes transport my grandchildren in the vehicle.
The two main wire harnesses are faulty. It would not charge or hold a charge. Driving it was dangerous and would stop drastically at any given random moment. A jerking motion would occur while driving. Lights on dash would come on, engine, charging fault station. Charging fault. And lightening bolt warning signs. Sometimes it would say don’t drive call for assistance. The dealership has had my vehicle since June 4 2021. The parts I’m told won’t be available until end of January 2022. I purchased the jeep on April 30th 2021. It’s very scary when you’re on the road, w my family and it decides to lock up or sounds like the transmission is falling from the under carriage. Luckily we weren’t rear ended or pushed through an intersection.
While towing a <3000 lb. trailer up a long grade (2.5 to 3 miles) on the interstate at the posted speed, warning messages were displayed on the dashboard approximately 2/3 of the way up the hill. “Service Electronic Throttle Control”, and Check Engine light displayed while the vehicle speed dropped dramatically from 70 mph to approximately 35. This same error occurred every time I tried ascending a long grade with the trailer (under load). Initially reduced speeds ( below the posted limit) did not change the outcome. Trying to use the optional manual shifting, did not change the outcome. Recreated initial problem following 1st dealership service for the events.
The engine caught on fire after a short drive. The fire burned the entire top of the rear of the engine and completely through the wiring harness before I could extinguish it with a fire extinguisher and water. The fire appears to have started at the top rear of the engine where the fuel line enters the intake. The manufacturer, Stellantis, hired a special investigator from EAA/Bosch to look at it, and he agrees that it is similar to fires in similar engines that were recalled in October 2020, the federal safety agency Campaign number 21V‑665. Stellantis has not responded to repeated requests for resolution.
2021 jeep wrangler. Consumer writes in regards to fuel tank issue. The consumer stated while driving, the vehicle began smoking and went into limp mode. The vehicle was taken to the dealer who hadn't determined the cause of the failure after 6 weeks. The vehicle had 2,845 miles.
After driving to my destination with 47% battery on the 4xe and full tank of gas. Turned the car to stop and got a service hybrid system malfunction. Tried to start up the car but the car wouldn't start. Had to get it towed to the dealership. The service tech told me that there is a isolation fault in the 17kwH battery and the entire shut down due to safety concerns.
Charging Fault Error came on as my wife was driving home when her 2021 Jeep Wrangler 4XE suddenly shut off and came to a immediate halt. She was barely able to prevent a major accident, which could've caused serious injury to herself and others on the road. Vehicle would not restart and was not even able to put the vehicle in neutral to push out of harm's way. The moment it happened I received a message on my Jeep UConnect app that a Charging Fault Error occurred. I didn't know what this meant, but about 60 seconds later my wife called me in distress and told me what happened. She was terrified couldn't even drive the rest of the way home and had to stand in 100F heat for an hour waiting for a tow truck. Result: The Jeep Wrangler 4XE is still in the shop (it's been in the dealership for over 3 weeks now, and we've owned it for 3 months and 3500 miles. They have no diagnosis and say they are still ordering parts. Asked 2x to speak with upper management at FCA and was told someone would call in 24 hours, it' been over 72 hours now. Included file of Jeep case number and Jeep 4XE forum with multiple chats on this same issue.
As I approached a stop sign while braking, the Jeep seized up, shut off, and gave the Electronic Stability Control warning. I attempted to restart and it didn’t start or get out of park. It then gave Blind Spot Monitoring System error and Service Charging System error. I’m grateful that I was at a stop sign unlike some of the other reports of this issue that were on the highway. It was quite a jolt when the vehicle seized. The vehicle has been at the dealership since 8/24. It was thought the hybrid battery needed replacement. A new one gave the same errors to the service team. The vehicle remains with the service department awaiting another battery.
Veh shuddered while driving. Warning light on dash for Hybrid system malfuction/red lighting bolt on dash. Veh taken to dealer 3 weeks ago. Needs new Power Inverter module. Wont drive. Part eta is 3 months out.
Vehicle shut down in middle of road. All lights on dash came on and vehicle became disabled. It repeated it self two more times that week and i finally had it towed to dealer.
While driving on 131 northbound just before the Saginaw croton exit my Jeep lost power I was in the left lane had to merge across to the right to exit and all the lights were on noting charging system needs service I got off highway onto ramp and coasted to side of ramp and realized it was not even on anymore. I immediately shut it off checked my uconnect app for a service warning and it said charging system failure all the lights on the dash were alerting me until it shut down I sat for a bit and tried to start it and it did but was jerky when attempting to drive. I switched to esave and the engine kicked in but was also doggy. I had 60% battery so I’m not sure what happened. I attempted to plug in when I got home and it blew breakers anywhere I attempted to plug it in and made a very loud pop! I didn’t try it anymore at home as it scared me. Contacted the dealer and two weeks later it’s at the shop. They have no idea what is going on - it’s acting up but now doesn’t even put the info into the log according to my service technician at the dealer. They are waiting on Chrysler engineers to get back to them with what to do.
The vehicle all of a sudden shut down and the charging system alert came on and said service charging system - this was while starting to merge off 131 north at the Saginaw exit. I coasted to the side of the road put it in park I attempted to start again and at first there was nothing Then I did it again and it started I did not see the charging error but it went into my log. I drove home. When I got home I tried plugging it in and it blew every breaker I tried plugging into. Called dealership and there it sits. They have no idea.
Engine began leaking diesel fuel and smoking from the fuel hitting hot components. Possible fire could have occurred. So much diesel that it coated the trailer I was towing.
The car flashed a red icon and displayed a message saying power was lost and telling us to pull over safely and put the car on park. We were in the middle lane on the New Jersey Turnpike and people were driving around us at 80mph, and the car would not accelerate. We were able to pull over and restart the car and it worked as if nothing happened. I got an email on the UConnect system saying there was a charging issue, and then a second email saying I should get the car serviced. I took it to the dealership this morning and am waiting on a diagnosis.
While driving the Jeep on the freeway, it shut off out of nowhere and came to a very quick halt. It nearly caused a major accident on the freeway. A few moments after the Jeep encountered this issue and shut off, I received a message on mu UConnect app saying that there was a Charging Fault Error. The incident has been reported multiple times online in Jeep forums for the new 2021 Jeep 4xe. Many people have reported that the Jeep shut off while driving at high speeds on the freeway, and the vehicle comes to a sudden and dangerous stop. This is what happened to me.
This vehicle is a plug-in hybrid Jeep Wrangler. On July 31, 2021 while returning home from vacation and driving at highway speeds (65mph +/-), the powertrain of the vehicle completely failed. The screen flashed that there was an electrical system malfunction and to pull over. The vehicle was very difficult to control as I had to travel across three lanes of high-speed traffic to get to an exit ramp. Fortunately, we made it safely to the exit ramp, where the vehicle completely shut down. This was the second time this happened. While driving to vacation on July 22, 2021, a similar incident occurred. The first incident, however, was not a complete failure. The vehicle's screen flashed that there was an electrical problem, but the vehicle did not completely stall. After pulling over, the vehicle restarted. At that time, I scheduled an appointment with the Jeep dealership to investigate the issue. That appointment was scheduled for August 1, 2021 (the day after the catastrophic failure).
I was driving vehicle on HWY 610 in Houston, Texas at approximately 55-60 MPH. Suddenly, vehicle simply stopped working in the middle of driving. Everything on my dash was reading zero. Car were swearing to avoid hitting me. I also had a baby in the backseat of my vehicle. Suddenly, the dash started to read place car in park, Service Charging System. The P at my gear shift was flashing rapidly. I was able to slowly and dangerously coast to the emergency lane. Where I was able to turn the vehicle off. This is a very dangerous situation. At this point, Jeep has no idea what the problem is an this is very frustrating.
I was driving at night on a 4-lane highway at approximately 55 mph southbound in the left lane. My hybrid vehicle had less than 1% of battery power and was running using the gas engine. With no warning the vehicle suddenly experienced a sudden deceleration to less than 10 mph then a warning light came on stating "service charging system- place vehicle in P and start engine. Fortunately there were no vehicles in close proximity either in front, behind, or in the lane to my right, so I was able to make it over to the shoulder before it came to a complete stop. At that point I received an alert from my UCONNECT app that stated "Your 2021 Jeep Wrangler Unlimited was unable to charge." It also stated to "Get service immediately." I placed the vehicle in park and attempted to start the engine with no response. I repeated the procedure and the engine started after which I was able to drive home. I had the vehicle towed to the dealer the next morning where, after two days, the dealer returned the vehicle and told me they could find nothing wrong. no codes in the computer, and no information from Jeep on any similar problems, despite getting the aforementioned alert received from the UCONNECT app. My main concern is that this type failure, the sudden engine failure/deceleration with no warning either inside or outside (brake lights), especially at night, can easily result an accident. I was very fortunate that I was on a highway with other cars near me. A crowded street, highway, or freeway would be a totally different story.
The vehicle gave a Service Hybrid Electric System error and disabled the engine at approximately 60 mph when traveling in E-Save mode, with <1% battery, and half a tank of gasoline. After navigating the vehicle to the side of the road, it came to a hard stop at about 5-8 mph. After 10 minutes, the vehicle restarted in Hybrid mode as was able to operate without error until reaching our destination. Weather conditions were clear at 85 degrees. Issues occurred on a two-lane byway. No injuries, other damage, or police reports at this time. The vehicle will be delivered for service for recreation and diagnosis of the issue. Issue occurred with approximately 246 miles, direct from the dealership upon delivery. The vehicle has no aftermarket accessories.
The contact owns a 2021 Jeep Wrangler. The contact stated that while driving at approximately 41 mph, the hybrid mode failed to let the engine operate and the vehicle stalled without warning. The contact mentioned that the power steering also ceased. The vehicle was restarted later under E-save mode. The vehicle was taken to the dealer however, the mechanic failed to diagnose the vehicle. The vehicle was taken to another dealer where it was partially diagnosed that the Transmission Control Module was disabled. The vehicle was not repaired. The manufacturer was notified of the failure and provided a case number. The approximate failure mileage was 940.
The actual malfunctioning issue is UNKNOWN. However, my best explanation is as follows: While driving my new 2021 Jeep Wrangler Rubicon (which only has 1400 miles), on the highway at roughly 70 miles per hour and going up a hill, the vehicle felt as if it were trying to up-shift a gear but then immediately down-shift a gear. This up-shift and down-shift feeling continued in quick repetition over and over in a violent shaking manner that thrust the entire vehicle forwards and backwards as long as I continued the acceleration up the hill. Letting off the accelerator seemed to end the violent shaking. I pulled over on to the side of the highway to stop, and turned off the Jeep since the check engine light came on. I waited about five minutes and started up the Jeep again. The check engine light was still on, though. Any acceleration at any speed now causes the Jeep to violently thrust forwards and backwards like I experienced on the highway. I tried to get Jeep Roadside to tow the Jeep to a dealership, but learned how worthless this Jeep Roadside program truly was. Several days after this incident, and I still do not have my Jeep at a dealership for repairs, nor do I have a rental. Jeep Roadside refuses to tow my Jeep to a dealership that has a rental, and I cannot afford to pay the towing fee's to get to a dealership with a rental. The nearest dealerships tell me they are six to eight weeks out on loaner vehicles. I'm too worried to try and driving my Jeep the distance to reach a dealership with a rental, cause it is way too unsafe to operate this Jeep with the violent shaking. I'm curious if anyone else is having this same issue, or knows more.
It's over heating while drive at has 12000 miles on it and getting over 250 degrees derating and dash lights came on flashing red saying over heating to hot air shut off going 60 miles an hour. Had to pull off road because it had no gas pedal with cars behind me almost getting hit.
A charging system error caused engine to shut down. I was driving down the road at about 30-40 mph and the vehicle just shut down. I was stopped in the right lane of traffic. A red plug appeared on the instrument panel. The vehicle started back up after several attempts to restart it. The red plug disappeared. I was able to drive the rest of the way home with no issues (about 1 mile). When the vehicle stopped it was in electric mode, had about 50% battery left, and had slightly less than a quarter tank of gas. I called dealer and made a service appointment for today. The vehicle was at the service department for about 3 weeks previously for the service light being on. We picked up the vehicle 2 weeks ago and the issue was not resolved. We had been texting with the service advisor about it while it was there and as soon as we picked it up and noticed the service light was still on he quit responding to us and would not get back with us.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history