68C recall software update has caused some form of loss of power, doesn’t fully power off, it feels as if it is throttling the electric motor causing the engine to suddenly start and rev high (5-7k RPM) bypassing the warm up time that’s built into the software for the engine. Now on 09/14/2026 (Monday) the vehicle through a DTC code “P0BBE-00” High Voltage Battery Voltage Variation. It went into limp mode while attempting to drive up the roll back (flatbed tow truck). Currently awaiting Dealer diagnostic.
2022 Jeep Wrangler fuel system complaints
Page 2 of 4: complaints 11 to 40 of 75, newest first, as owners wrote them.
Post the 68c recall the acceleration profile of the vehicle is inconsistent and at times significantly delayed. To the point where when making left hand turns or merging into freeway traffic becomes dangerous. One specific instance while making a left I started to go but the accelerstion was extremely slow. Pressing the pedal nearly all the way down with traffic bearing down in me the enging finally kicked in at nearly full throttle. Causing a very chaotic turn. This is particularly noticeable while driving in electric mode, and usually shows up after driving for a little while. However I have had it happen very shortly after starting a drive. It does seem to be related to either battery or motor temperature, but it is very inconsistent. Typically when it does happen you try to accelerate and the normal response of acceleration doesn't occur. You keep pressing the pedal until it is nearly all the way to floor before the engine kicks in and suddenly is floored and you get more acceleration than you were trying to get. Not necessarily a safety issue, but further evidence that battery or electric power has been restricted. Since the 68c recall my fuel economy has reduced a out 8 mi/gal. I make the same road trips on a regular basis and the same trip prior to the 68c recall I got nearly 100mi more per tank of gas. It seems the battery charging and electric assist has been retarded from the original performance. Again this is more dramatic in all electric and causes precarious situations as described above. There are no warning lights or error messages, the dealer either can't reproduce the issue or calls it normal operation. I have over 90k miles on my vehicle and it is only the 10k or so since the 68c recall that I have noticed this issue. It is not performing "normally".
I believe this has to do with a Recall software update 68C that Jeep put out to resolve issues with the high voltage battery. This is a plug in hybrid Jeep Wrangler 4xe and since the software update the vehicle does not perform the way it did before and is a definite safety issue. When running in electric mode the vehicle sometimes does not respond as it should, like a hesitation, then the gas engine will suddenly start and accelerate much faster than was intended. You will be pressing on the pedal more and more then suddenly, zoom ! This is very dangerous when merging or pulling into traffic. The dealership will just tell you there are no fault codes and the vehicle is operating normally. There are no warning lamps or messages The only way to safely operate the vehicle now is gas engine mode (E-Save). There are certain conditions that bring this on but it can be random .
2022 Jeep Wrangler 4xe always had good power on electric mode as well as hybrid mode (electric/gas). There were no issues merging with traffic on highway, freeway, climbing hills, staying with the flow of traffic in electric mode. Was able to stay in Electric mode 99% of the time. When and if Jeep called for more power, engine came on smoothly with engine idling low having time to warm up and then kicking up revs to create stable propulsion. However, on 12/30/2025 Jeep Dealership performed the 68C recall with updates to the Jeep. Now the jeep has no power in electric mode and is constantly going into gas mode with an ice-cold engine revving at high revs to create propulsion. I am no longer able to safely merge with traffic on highway, freeway, climbing hills, staying with the flow of traffic in electric mode. I am concerned for my safety as well as the engine being asked to kick on in high rpm's not up to appropriate operating temperatures.
As I was driving the vehicle this afternoon my entire jeep smelled like gas. I felt like I was breathing in fresh gas coming from my ac vents. I did vent my windows as I started to get a headache & I had to go home and get my husband’s vehicle before picking up my children because I could not expose them to such toxic fumes. Even though my vin shows zero unrepaired recalls, my hybrid jeep was part of the national recall of being of a fire risk and had all kinds of service lights on. When I took it to the dealer they told me if the battery didn’t fail, the jeep was fine. They cleared the codes and replaced the heater and I am not sure how that fixes the national recall? Prior to going to the dealer, there was no fix for this recall and the notice told me not to plug it in. But now the recall is cleared? Now I have gas fumes filling my jeep and there is no leak outside the vehicle. I have a witness to that. I FaceTimed my mom when I got home and we looked under the vehicle together. At this point, it says my vehicle is not safe to drive,
I am reporting repeated premature failures of the factory charge air cooler (turbo intercooler) hoses on my 2022 Jeep Wrangler EcoDiesel (3.0L V6). Within 73,000 miles, both the primary and secondary turbo charge hoses have hardened, cracked, and failed under standard boost pressure. Safety Risk: When these turbo charge hoses split, the engine experiences an immediate and complete loss of boost pressure (limp mode / Code P0299), severely restricting acceleration and vehicle speed. This sudden, unannounced loss of engine power occurs while driving at highway speeds, creating a severe rear-end collision hazard in heavy traffic. Failure History & Repair Documentation: First Hose Failure: Replaced by an authorized Jeep dealership at under 60,000 miles (November 2025). Second Hose Failure: Replaced by an authorized Jeep dealership at 73,000 miles (August 2026). Stellantis/Jeep treats these recurring structural hose splits as non-warranty "wear and tear," forcing out-of-pocket repairs despite the severe highway safety hazard caused by sudden power loss. I am requesting the federal safety agency open a safety defect investigation into the material failure rate of 3.0L EcoDiesel charge air hoses.
RE: SAFETY COMPLAINT FOLLOWING RECALL 68C (the federal safety agency Recall Number 24V‑111 / Mopar 68C) I am the owner of a 2022 Jeep Wrangler Rubicon 4xe. Prior to having safety recall 68C performed, the hybrid system functioned flawlessly. Immediately upon receiving the vehicle back from the dealership after the 68C software flash, a severe drivability and safety hazard emerged. When driving in standard Hybrid/Electric mode, the vehicle experiences a sudden loss of power, hesitation, and a physical 'bogging down' sensation. Following this lag, the vehicle violently surges into gasoline mode, causing a sudden and unpredictable acceleration lurch after the vehicle hesitates to accelerate. This behavior occurs randomly at both low neighborhood speeds and highway speeds, making it impossible to smoothly modulate throttle input. This creates an immediate safety hazard when attempting to pull out into cross-traffic, merge onto highways, or maintain a safe, predictable following distance. The vehicle hesitates when throttle is demanded, creating a risk of being rear-ended, followed by an uncommanded surge. The dealership states the vehicle is 'operating as designed' according to a regional Jeep field engineer, implying this dangerous lag-and-surge behavior was intentionally introduced into the vehicle's management software by the manufacturer to mitigate, the recall notice noted above, battery thermal risks at the expense of occupant driving safety. The manufacturer’s recall remedy has traded a fire risk for an active moving traffic hazard." Several forums and AI searches show this is a common problem the manufacturer has created to avoid a costly recall by addressing the real issue with the battery’s fire risk. Instead they have intentionally reduce the battery’s performance causing a safety issue with the vehicle’s acceleration and operation.
When driving down the road my jeep goes into an uncomfortable death wobble. It has already been to a dealer to fix this once but it isn’t . There is a weld defect in the driver side front and passenger door frame . When the electronics get hot from the summer heat they black out . The digital display is not calibrated to the odometer of the vehicle . The Jeep surges violently and almost caused a collision.
After the latest 68C recall fix, Jeep has adjusted the behavior of how the vehicle's electric mode operates. When the battery gets to a certain temperature when driving, the engine is supposed to turn on (to prevent the fire risk hazard). However, instead of the vehicle making the powertrain switch, the vehicle power will just stop. The pedal will go to the floor but no forward movement. It is dangerous in many driving situations, like the highway or among other vehicles when mine unexpectedly stops. Jeep has tried to fix this exact issue in 3 separate recalls, but it still occurs. They should buy back the vehicles as they seem to not be able to fix and they are not safe to drive.
My Jeep will not operate correctly in the electric mode after a software update that was required to resolve a recall. The vehicle loses power in the electric mode and surges into the gasoline mode suddenly. This occurs after the vehicle has been driven a while and when the battery level drops below 50%. See these forums for others experiencing the same issue. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Multiple recalls on jeep 4xe starting with the hybrid system from charging to the battery. Ultimately not fixable per Stellantis. Now electrical components in steering that present possible fire hazard at anytime. Not to mention the fact that if it can cause a fire, then the steering could fail in some unexpected way while driving, leading/contributing to an accident with serious injury or death. These combined make the car generally unreliable, potentially unsafe, and increase depreciation.
While driving any speed most of the time slowing down "Performance limited service fuel system". Dealership looked at it 2 different times and said it was just the clamp of some sort..took it on again and they said it could be the high pressure fuel system. Nothing has been replaced as they do not know what is going on. The message pops up randomly and goes away very quickly. This Jeep currently have just over 19,000 for a 2022 model When we first noticed the message it had just over 12000 miles
The issues lies in the Hybrid systems electric only function. When climbing grades, the vehicle experiences severe power loss which can be felt by the driver and is displayed by the vehicle on the dashboard information cluster. Power output from the hybrid system drops to or below 50% output even when pressing the accelerator to maximum. This issue occurs almost every time climbing a steep grade regardless of exterior temps. After losing speed and power on a steep grade while working the accelerator to or near maximum application the engine is activated abruptly without warning and without the proper hybrid warm up sequence and causes startling shifting by the powertrain and jerks the vehicle. This behavior began after Recall 68C was performed and hybrid Battery replacement.
My 2022 Jeep Wrangler has an ongoing issue involving an oil and diesel leak, which creates a hazardous driving condition and poses a fire and safety risk. The vehicle has been taken in for repair multiple times (4 repair attempts) for the same issue, and the problem remains unresolved. Due to the severity of the leak, the vehicle is unsafe to operate and requires towing to the dealership. Despite repeated repair attempts, the manufacturer has failed to provide a permanent fix and has denied further assistance based on procedural reasons (vehicle not currently at dealership, mileage, and warranty concerns). I am concerned this is a broader safety defect that could affect other vehicles.
My 2022 Jeep Wrangler 4xe experienced a sudden loss of power while driving on Interstate 285 in Atlanta during rush hour traffic. The vehicle began shaking and lunging forward unpredictably while I attempted to exit the highway. With hazard lights on, I slowly crept the vehicle to the dealership because it could barely move. The vehicle is currently at the dealership for Recall 68C related to the hybrid battery system. This incident created a dangerous situation on a major interstate and could have caused a serious accident.
"Performance Limited Service Fuel System"- showing while slowing down/coasting to a stop ion a 2022 Wrangler 2.0 Dealer can not help- they mentioned there is no recall and that they can not do anything about it.
On 3/3/2026, I brought me JEEP 4XE to the Jeep dealership in Paris, Kentucky to have the 68C recall performed. The Jeep dealership used version #7 of the 68C recall instructions to updated all software modules and then to perform a 7 mile test run to engage the electric engine and to stress the vehicle per the instructions documented in the recall instructions. Document is identified as: * High Voltage Battery * Reference: 68C/the federal safety agency 25V‑741 * Revision: 7 * Edition: February 2026 * Details: Additional DTC added to the end of Section B. BPCM software update After picking vehicle up from dealership, I proceeded home via a state highway Route 68 (Paris Pike). The roadway is a 4 lane divided highway and has a speed limit of 55mph. I set my vehicle to HYBRID mode and then placed it on cruise control as I had done numerous times over its 25,000 miles. During the drive there were occasional rolling hills and inclines. I gauged the hills to be about a 1% grade on average but never exceeding 2% grade. During these inclines, the gasoline engine engaged and the RPM gauge on the instrument cluster registered 3000RPM. This excessive engine RPM had NEVER occurred before the 68C factory recall procedure. In all other instances of the engine engaging, the RPM would engage at 2000RPM. I contend that the the engagement of the gasoline engine on these small inclines was NOT warranted and that the excessive RPM's of 3000 is not normal and was never experienced prior to the 68C recall fix. I am submitting this information for review and documentation. Video of the instrument cluster gauge showing the RMP gauage and the display panel showing the engine and battery kW used were taken to document the process. I believe that the engagement of the gasoline engine at 3000RPM will cause excessive wear of the engine and is a direct result of one of the software updates that was used to complete the 68C recall.
After 68C recall fix in January, the following has occurred: -Check engine light on immediately -Replaced electric coolant heater -Sluggish in both hybrid and electric modes -FORM indicators - constant fuel oil refresh mode -Change oil required indicator on -Engine revving high at low speeds -Jumping when putting into drive / idling / shifting issues --Replaced all 4 shocks And just yesterday on 2/27/26: Complete and total loss of power while driving on the highway. Major safety issue and a near crash.
Our vehicle has been. Undriveable since recall 68c/25v‑741 and has been at the jeep dealer (friendship jeep chrysler in forest city nc) since 1/5/2026 with no guidance as to when to expect a fix and return to us. Between car payments, insurance payments, and accelerated depreciation we have lost thousands of dollars and we are not able to use the vehicle.
The vehicle poses a fire risk not allowing the vehicle to be parked under structures and the vehicle cannot be charged even though it is a plug-in hybrid vehicle. There is an active recall and this is not the first one. The fix for the recall is a software update that can shut off the high voltage battery if an issue is encountered which leaves the vehicle in limp mode, which is dangerous when traveling on the highway. If a new battery is required, the same faulty style batteries are exchanged. Stellantis is not addressing the car issues appropriately
I have experienced at least five times in which my vehicle does not start and a "service charging system" error message shows on the dash resulting in the vehicle having to be towed to Newport Jeep in Middletown RI for service. Every recall that has been issue has been "fixed"- my hybrid battery has been replaced, my high voltage wire has been replaced. I tried to pursue a buyback request and was rejected in March 2025. I am aware of the 68C safety recall and that there is no repair at this time. Again on 12/9/25 my vehicle would not start, the "service charging system" error message was on the dash and my vehicle has had to be towed back to the dealership. They are not able to diagnose the issue. I want to pursue a buyback as this vehicle is defective and unsafe.
I received the recall of my leased vehicle and I immediately called Chrysler Stelantis and was told that there was nothing they could do. This recall materially restricts the safe use of my leased vehicle. I request early termination of my lease without penalty OR a replacement vehicle. I am a 100% disabled veteran and cannot comply with the recall’s conditions They stated that they will take back my lease but I will be penalized for the early termination and also for any recoupment of the vehicle when it goes to auction. This is unacceptable and has placed myself, my family,, my residence and other vehicles in danger. I cannot abide by the recall.
The contact owns a 2022 Jeep Wrangler. The contact received notification of the federal safety agency Campaign Number: 25V741000 (Electrical System); however, the part to do the recall repair was not yet available. The check engine warning light was intermittently illuminated. The vehicle was taken to a local dealer, where a fault code related to the gas cap was cleared. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.
My Jeep Wrangler 4xe displayed a ‘Service Charging System’ warning immediately after unplugging from charging. I began to drive and noticed the warning right away. I then parked and attempted to restart the vehicle, but it would not start and became completely inoperable. The vehicle had to be towed. The dealer confirmed this issue is related to the current hybrid safety recall, but Stellantis has stated that no repair is available, and it may not be available until the end of the year or the first quarter of next year. The vehicle is undrivable, and I cannot safely use or move it. Stellantis is only offering reimbursement for a rental, which I cannot access because I cannot afford to pay for a rental vehicle upfront. Reimbursement for what could be an unlimited or months-long period of rental fees is not a reasonable or accessible remedy. This leaves me without any safe or practical transportation option. I have now been without transportation for over 48 hours, and the manufacturer is not providing a reasonable remedy or safe transportation while the recall repair remains unavailable. I am filing this complaint so the federal safety agency can document the delay, the lack of an accessible remedy, and the manufacturer’s failure to provide a safe, timely solution for an undrivable recall-affected vehicle. The vehicle is undrivable and I cannot safely park or use it. Stellantis is only offering reimbursement for a rental, which I cannot access because I cannot afford to rent a vehicle upfront. I have now been without transportation for over 48 hours, and the manufacturer is not providing a reasonable remedy or safe transportation while the recall repair remains unavailable. I am filing this so the federal safety agency can document the delay and lack of an accessible remedy for an undrivable recall-affected vehicle.
I own a 2022 Jeep Wrangler 4xe (VIN: XXX) subject to Recall 68C for the high-voltage battery. Jeep Customer Care advised me in writing not to charge the battery and not to park the vehicle inside or near structures, but could not define a safe distance or provide any specific measurable guidance. I live in a residential community where all parking is adjacent to homes, so these instructions are impossible to follow. FCA also stated they are unable to provide a loaner or alternative accommodation, even though their written guidance effectively removes the vehicle from normal home use. Additionally, FCA repeatedly instructed me to bring the vehicle to a dealership to determine if it is “unsafe to drive,” despite confirming that no remedy exists and that dealers have no diagnostic test or inspection procedure that can detect or reduce the risk of thermal runaway associated with this recall. The dealership cannot change the risk until a remedy is available. I am requesting the federal safety agency review FCA’s interim guidance for clarity and adequacy, as owners cannot comply with instructions that are vague, contradictory, and not operationally feasible in residential environments. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving to an appointment on 11 August 2025 the yellow CEL light came on and the Jeep Wrangler 4xe stopped operating in hybrid mode. A few miles later the Jeep went into limp mode with a red turtle, red wrench, and red battery light. Pulled into the left center turn lane to allow faster traffic to pass and then made a left turn off of a busy 4-lane highway. I then proceeded down the hill and at the next traffic light I was turning right when the Jeep stopped and the gas engine completely shut down and the Jeep stopped moving halfway through the intersection. Putting the vehicle in park, I attempted to restart the vehicle while it sat in the middle of the intersection but it wouldn’t restart. I then turned on my flashers and exited the vehicle so I could call a tow truck. After the vehicle was towed to the nearest Jeep dealership I learned two days later that the hybrid battery pack had failed and it needed to be replaced. As of 18 September and the vehicle is still at the dealership awaiting authorization from the Jeep engineering team so the technician at the dealership can order a special part!
The vehicle experienced multiple serious fuel system failures, including a failed fuel injector and high-pressure fuel pump. After these components were replaced, it was confirmed that fuel was still entering the engine crankcase. At no point did the vehicle trigger a “Check Engine” light, oil dilution warning, low oil pressure alert, or any hybrid/electric powertrain. This represents a critical safety & reliability issue. Fuel dilution of engine oil can: severely degrade lubrication, increase crankcase pressure, and/or lead to internal engine failure or fire The lack of any warning or diagnostic code suggests either: a software calibration issue in the ECM/BCM that failed to detect the problem, a sensor failure, and/or a defect in the onboard diagnostic system itself. This could indicate a broader defect affecting the safety of the 4xe platform and request investigation. This failure delayed necessary service and put both vehicle and occupants at risk.
We have 2 2022 Jeep vehicles with the EcoDiesel engines in them (a Gladiator and Wrangler) that we purchased in 2022. I am filing a case for each of them on this site. In April 2023 there was a recall of the fuel pump on the 3.0 EcoDiesel and to date the problem has not been rectified for either of my vehicles. We have made notification to the dealership that we want to get this done but they say they do not have the parts in stock to do it. The dealership said they only get 1 fuel pump a month to replace and we are waiting and have been waiting for about a year since we notified the dealership for this safety issue to be rectified. I am filing this complaint as directed by the federal safety agency website because I feel this issue has not been handled in a timely fashion and I believe that it is irresponsible of Jeep to not rectify this in a much quicker fashion. Each time we call the dealership we are told they do not know when it will be rectified.
While braking (in hybrid mode, with max regen braking on), the car begins to lurch forward with significant force as it comes to a stop. This seems to be an issue with max regen, as acceleration and braking is overall much smoother with the feature off. This has happened sometimes before, but is difficult to replicate on demand. No warning lights on dash, and has not been confirmed by a dealer. There were no warning lights or messages, and has happened since purchase of the vehicle in June 2022. This instance was so severe that the vehicle almost crashed into the house, as i was pulling into the driveway and braking. Upon researching online, others have reported this issue, with some involved in motor vehicle crashes because of it. Clearly a safety issue that requires attention.
Wife was going to work. Started to notice difference in the feel of the drive. Then the check engine light came on. When she started to accelerate the vehicle jerks. When the vehicle is at a stop then accelerates the it takes about 5 seconds for the car to start moving. Today the vehicle turns on but can’t switch gears to put it in reverse or drive. Vehicle is a paper wait and the earliest time I can take in to a certified mechanic is 1 month. I’ve had multiple issues with this car. Death wobble, electric recalls. And a recall that stated part not available park your car not in your garage and don’t charge your hybrid…. How can this car be allowed on the streets with this many issues under 2 years
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history