Jeep Wrangler fuel smell problems

Filed Sep 16, 2026 · Fuel system · TX

As I was driving the vehicle this afternoon my entire jeep smelled like gas. I felt like I was breathing in fresh gas coming from my ac vents. I did vent my windows as I started to get a headache & I had to go home and get my husband’s vehicle before picking up my children because I could not expose them to such toxic fumes. Even though my vin shows zero unrepaired recalls, my hybrid jeep was part of the national recall of being of a fire risk and had all kinds of service lights on. When I took it to the dealer they told me if the battery didn’t fail, the jeep was fine. They cleared the codes and replaced the heater and I am not sure how that fixes the national recall? Prior to going to the dealer, there was no fix for this recall and the notice told me not to plug it in. But now the recall is cleared? Now I have gas fumes filling my jeep and there is no leak outside the vehicle. I have a witness to that. I FaceTimed my mom when I got home and we looked under the vehicle together. At this point, it says my vehicle is not safe to drive,

Filed Sep 12, 2026 · Engine, Fuel system · NV

My Jeep Wrangler currently has a very strong fuel smell, and when the AC is on the smell is very strong inside the cabin. My kids and I became Ill and had headaches. It's been parked for two weeks. Pending an inspection by an independent mechanic. We came across an article stating that a lot of 2020 Jeep Wranglers with 2.0L motors were recalled because of the same issue but my Jeep was not recalled and I'm having the same issue. Is there anything you can do to help me?

Filed May 11, 2026 · Engine, Fuel system · CA

On April 13, 2026, at approximately 67,312 miles, my vehicle experienced a fuel system failure when the main fuel supply line leading to the high-pressure fuel pump cracked and began actively leaking raw gasoline onto the top of the transmission in the engine compartment. There were no prior dashboard warning lights or error messages; the only symptom leading up to the failure was a extremely strong odor of raw gasoline coming from the engine bay area. I believed this fuel leak created an immediate, severe risk of an engine compartment fire. I immediately brought the vehicle to an authorized factory dealership, where certified technicians acting on behalf of the manufacturer inspected the system, confirmed the active leak emitting raw fuel odors, and successfully removed and replaced the failed supply line to resolve the issue. If needed, the vehicle is available for inspection upon request. Furthermore, my vehicle is factory-equipped with the 2.0L Turbo engine, meaning this failure is identical to the documented fire hazard covered under FCA Safety Recall Y10 (the federal safety agency Campaign 21V‑665). Even though my specific production sequence was not actively flagged under the manufacturer's recall lookup system, I believe the component failed in the exact same hazardous manner described in the official recall.

Filed Apr 27, 2026 · Fuel system · 120,000 miles · MO

The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at various speeds, there was an abnormal fuel odor entering the cabin of the vehicle. No warning lights were illuminated. Upon further inspection, the contact became aware of gasoline leaking from the fuel supply line onto the engine. The vehicle was taken to a local dealer to be diagnosed. The contact stated that the fuel leak was associated with the federal safety agency Campaign: 21V665000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 120,000.

Filed Feb 10, 2026 · Driver assistance, Engine · FL

Dealers: Lakeland Crysler Dodge RAM, FL; Second authorized Jeep dealer, Bartow FL Complaint: My 2024 Jeep Wrangler Sahara has multiple unresolved safety defects despite repeated warranty repairs, and I have no confidence in this Jeep at just 12,000 miles. Forward Collision Warning (FCW) not working — Lakeland Jeep failed to repair or document inspections. Fuel leak / gasoline fumes in the cabin — After repairs on Feb 4, 2026, strong fumes entered the cabin while my children were passengers. A second dealer confirmed the leak and retained the vehicle as unsafe. sensor failures — Reported since July 2024, still unresolved. Failure to document safety sensors — Repeatedly requested, ignored by dealer and Stellantis. Dealer GM and Stellantis negligence — Cases closed prematurely; repairs rushed without confirming the Jeep was safe to drive. The Jeep continues to pose serious risk to passengers, including my children, due to fuel fumes and non-functioning safety systems. I cannot trust this vehicle to transport my family safely, despite being only 12,000 miles. Documentation: Emails, texts, certified letters, and repair orders document repeated safety defects and communication with Stellantis and Lakeland Motors Jeep. Request: Immediate investigation and warranty repairs Written confirmation that the Jeep is safe before return Buyback under Florida Lemon Law due to repeated unresolved safety defects

Filed Feb 5, 2026 · Fuel system · 172,000 miles · CA

The contact owns a 1993 N/A Jeep Wrangler. The contact stated that there was a strong fuel odor coming from the vehicle after the vehicle was refueled. Additionally, the contact stated that the vehicle was experiencing rough idling and reduced power while driving. The vehicle was taken to the dealer, where the contact was informed that the VIN was included in the federal safety agency Campaign Number: 94V106000 (Fuel System, Gasoline); however, the dealer later informed the contact that the recall part had been discontinued. The vehicle was not repaired. The manufacturer was contacted and confirmed that the recall part had been discontinued. The contact requested that the manufacturer replace the entire fuel pump assembly. A case was filed. The failure mileage was 172,000.

Filed Nov 10, 2025 · Electrical, Engine · OH

2024 jeep 4xe constantly won’t engage in hybrid mode and will blow out thick white smoke from the exhaust (Not exhaust fumes) engine has become abnormally loud and idles very high. Oil percentage went from 90% to 0 just sitting idle in the driveway with in 10 mins resulting in 3 oil changes before 5,000 miles

Filed Nov 4, 2025 · Fuel system · MI

I am the owner of a 2020 Jeep Wrangler JL with the 2.0L turbo engine, and I am writing to report a fuel leak issue that I believe is related to Recall Y10 / the federal safety agency Campaign 21V‑665, which involves the high-pressure fuel supply line (Part #68297642AD). My vehicle is experiencing a strong fuel smell and visible fuel leak, and a technician confirmed the failure of the fuel line. However, my VIN does not currently show as included in the recall, and I have been told the repair is not covered under warranty. Given that my Jeep has the same engine, same part number, and identical symptoms described in the official recall — I’m requesting one of the following: That the dealer be allowed to inspect the fuel line’s date code and replace it under Recall Y10 if it falls within the affected range, or That Jeep/Stellantis cover the cost of the repair as a goodwill safety-related assistance, since the failure occurred outside the normal warranty but is consistent with the recall defect. I take safety very seriously, and I hope Jeep does too. Please let me know what documentation or diagnostics you need from my service provider to support this request.

Filed Sep 17, 2025 · Fuel system · WA

There was a crack, and subsequent leak, in the fuel line to the engine. My safety, and my passengers safety was absolutely put at risk as that could have ignited a fire at any moment. I took the vehicle to an independent mechanic who diagnosed the problem. No warning lamps appeared, however, the smell of gas was very strong in and near the vehicle.

Filed Jul 25, 2025 · Fuel system · MI

I am the owner of a 2020 Jeep Wrangler JL with the 2.0L turbo engine, and I am writing to report a fuel leak issue that I believe is related to Recall Y10 / the federal safety agency Campaign 21V‑665, which involves the high-pressure fuel supply line (Part #68297642AD). My vehicle is experiencing a strong fuel smell and visible fuel leak, and a technician confirmed the failure of the fuel line. However, my VIN does not currently show as included in the recall, and I have been told the repair is not covered under warranty. Given that my Jeep has the same engine, same part number, and identical symptoms described in the official recall — I’m requesting one of the following: That the dealer be allowed to inspect the fuel line’s date code and replace it under Recall Y10 if it falls within the affected range, or That Jeep/Stellantis cover the cost of the repair as a goodwill safety-related assistance, since the failure occurred outside the normal warranty but is consistent with the recall defect. I take safety very seriously, and I hope Jeep does too. Please let me know what documentation or diagnostics you need from my service provider to support this request.