1996 Kenworth K100 Problems: 0 Complaints, 3 Recalls

The worst 1996 Kenworth K100 problems

Ranked by number of owner complaints. Mileage and cost come from what owners wrote.

Tap a problem to see which part fails, at what mileage and in which other years.

Suspension: front: control arm: lower armReported February 20, 2001 · 209 vehicles affected

What is wrong: Vehicle description: vehicles equipped with 54" rear axle spacing configuration of the airglide 200 suspension with the service application identified as logger, dump truck, or tanker. The rear suspension is regularly subjected to extreme articulation, resulting in flexing of the joint.
Risk: Failure of the lower sway arm attaching bolts could result in loss of vehicle control.
Remedy: Dealers will replace the lower sway arm brackets. Owner notification began march 27, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kenworth at 1‑425‑828‑5000.

Recall number 01V051000 · Recall details

Electrical system: wiring: front underhoodReported June 11, 1998 · 9,500 vehicles affected

What is wrong: Vehicle description: heavy duty trucks equipped with caterpillar 3406e engines. The routing of the electrical and fuel lines can cause chaffing of the wiring harness on the fuel line.
Risk: This chaffing can cause fuel leakage and a potential for a fire in the engine compartment.
Remedy: Dealers will inspect, adjust, and repair, if necessary, the fuel line and electrical harness.

Recall number 98V129000 · Recall details

Exterior lighting: turn signal: switchReported April 3, 1996 · 617 vehicles affected

What is wrong: The wires that correspond to the vehicle's rear turn signals were reversed when installed in the electrical connector.
Risk: This condition will cause the rear turn signals to flash opposite from the direction intended by the driver increasing the risk of a vehicle accident.
Remedy: Dealers will inspect the turn signal switch and, if necessary, replace the turn signal switch.

Recall number 96V056000 · Recall details

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

Is the 1996 Kenworth K100 reliable?

Owners have filed 0 complaints about the 1996 Kenworth K100.

What is the most common problem with the 1996 Kenworth K100?

There are not enough complaints to tell.

How many recalls does the 1996 Kenworth K100 have?

3 recalls, covering suspension, electrical system and exterior lighting.

See the problems and recalls for an exact car

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.