2026 Kia Carnival Hybrid electrical problems

Filed Oct 20, 2026 · Electrical, Engine · CA

While I was driving, the car's engine shut off, and I could no longer accelerate. The car went into neutral and the brakes felt harder to press; the steering wheel did, too. Luckily, it happened after I turned into a mall parking lot. Since the car came to a stop and I couldn't accelerate, I turned it off and back on. Then I parked the car and turned it off. After 30 mins I started the car again and drove back home. The instrument cluster showed all types of warnings and failures when the issue happened. Since I panicked when it happened, I did not think about taking photos. Tomorrow I plan on taking the car to the dealer. This is a new car, driven only around 3500 miles. I am afraid this will happen again, and in a worse situation, like on the freeway.

Filed Oct 11, 2026 · Electrical, Engine · CA · fire

On XXX my nearly new 2026 Kia Carnival Hybrid SX Prestige, with approximately 5,650 miles on the odometer, caught fire while I was driving in [XXX]. The fire originated in the engine compartment, where components of the hybrid electrical system, including the Hybrid Power Control Unit (HPCU)/inverter assembly, were subsequently found severely damaged. The incident occurred unexpectedly during normal vehicle operation and created an extremely dangerous situation. A vehicle fire while driving presents a serious risk of injury or death to the driver, passengers, and other road users. Following the incident, I sought emergency medical attention due to smoke inhalation. I was evaluated at an emergency department, including blood testing for carbon monoxide exposure. The vehicle was subsequently transported to an authorized Kia dealership. Kia America was notified of the incident and subsequently offered to repurchase the vehicle under California’s Song-Beverly Consumer Warranty Act. However, the manufacturer has not provided me with a definitive technical explanation of what caused the fire. I am extremely concerned that this incident may involve a potentially serious defect in the hybrid electrical or power management system that could affect other Kia Carnival Hybrid vehicles. I respectfully request that the federal safety agency review this incident, evaluate whether similar fires or electrical failures have been reported, and determine whether further investigation into a potential vehicle safety defect is warranted. I have photographs documenting the fire and resulting damage, medical records from my emergency department visit, and correspondence with Kia America. These materials can be provided upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 29, 2026 · Electrical · NJ

2026 Kia Carnival Hybrid SX. The digital instrument cluster intermittently flickers, goes blank, and displays “NO SIGNAL” while driving, potentially causing loss of access to speed, gauges, warning indicators, and other safety information. The failures occur unpredictably. I initially noticed the issue after the vehicle had been parked in the sun and the dashboard was very hot, but I do not know whether temperature is related. I first brought the vehicle to an authorized Kia dealer in August 2026. The dealer documented and verified my complaint. The repair order states that moving the monitor caused it to flicker and display “No Signal.” The dealer identified Kia campaign SC361R1 as having an update for this concern and performed the update. The display flickered again while the technician was re-securing it. I was told to return if the problem persisted. It did. The instrument cluster screen goes blank for several minutes at a time while the car is running or it flickers on & off for extended time (up to minutes) and resets to normal randomly. I returned the vehicle for further diagnosis. The dealer again verified the blank/flashing/“NO SIGNAL” condition. Kia Techline directed diagnostic testing and then advised replacement of the instrument cluster. The dealer installed a replacement cluster, but it also went blank and displayed “NO SIGNAL.” Techline then approved replacement of the main dashboard wiring harness. During teardown, the dealer discovered an aftermarket amplifier had previously been spliced into the OEM harness. The dealer now states it is “likely” the amplifier was disrupting the cluster signal and is denying warranty coverage. The exact cause remains UNKNOWN. The vehicle is currently disassembled at the Kia dealer, and the original harness/splice is presently available for inspection. The replacement harness has not yet been installed. Kia America has been notified under Customer Care Case #26389879.

Filed Aug 25, 2026 · Electrical, Seats · CO

Ac compressor has now failed twice and this will be the third compressor they are going to install. The car was completely shutting off at lights and having other electrical errors that they said was all related to the ac system. The part is now on back order with the company

Filed Aug 18, 2026 · Electrical · 100 miles · CA

The contact owns a 2027 Hyundai Palisade. The contact stated that while initiating vehicle operation, the messages "Check Hybrid System" and "Stop Vehicle and Check Power Supply" was displayed. The failure was a recurring failure. The dealer was contacted and received the same messages. The dealer stated that the failure was associated with the 12-Volt battery in the vehicle that was low due to being in port for a while; however, the failure persisted. The dealer was contacted and stated that the corporate office was working on the remedy, but there was no estimated date when the remedy would become available. The manufacturer was not made aware of the failure. The failure mileage was approximately 100.

Filed Aug 14, 2026 · Electrical · PA

Car will not start after being parked in my garage for 24 to 48 hours. The battery is drained and needs to be jumped. This has happened three times. I am sure that no fob is left in the car, no interior lights are on, no door is ajar, and nothing is plugged into any USB ports.

Filed Aug 7, 2026 · Electrical, Engine · NC

I am writing to formally express my serious concern and disappointment regarding my Kia Carnival Hybrid. Shortly after purchasing the vehicle, with only approximately 6,000 miles on the odometer, the vehicle suddenly stopped operating while I was driving on the freeway. This created a dangerous situation for my family and other motorists. The vehicle had to be towed to an authorized Kia dealership for diagnosis and repair. No warning or message had appeared before the issue. The dealership retained the vehicle for approximately one week and informed us that a PCB (Printed Circuit Board) component had failed and needed to be replaced. After the repair was completed, we were assured that the issue had been resolved and that the vehicle was safe to drive. Unfortunately, after driving only about 50 additional miles, the exact same issue occurred again. The vehicle once again became inoperable, leaving us stranded and raising significant concerns about the reliability, safety, and quality of this vehicle. We towed the vehicle on 6/22/26 and Kia dealership had it till today 8/7/26 and corporate keep saying they working on it but unresponsive.

Filed Aug 7, 2026 · Brakes, Electrical · TX

Detailed information is in the attached pdf file, but in a nutshell, Kia is covering a safety defect in their vehicles by claiming the process is “proprietary”. On several occasions we have lost propulsion, which means we had no control over our vehicle, and Kia’s explanation is simply, “the vehicle is performing as intended “! These incidents always happened at low speeds, just accelerating from a stop, but left us in a precarious situation as we were left in the middle of a busy intersection with no control over our vehicle! Propulsion would eventually return. After surviving several of these failures, I learned the proper thing was to let both pedals return to their idle position and then the vehicle would recover. This is a most difficult thing to accomplish when surrounded by angry drivers! The failures were identified by Google AI as a Brake Override System, also known as Brake Throttle Override. However, Kia already has a very functional Brake Over Accelerator process, so why would they have two similar functions? Kia knows the answer but is refusing to divulge any information regarding the intention or purpose of this mysterious process which makes our vehicle unsafe!

Filed Aug 2, 2026 · Body, Electrical · AZ

The floor railings above the battery, that allow the second row seats to slide, get hot. Extremely hot to the touch. Burning my children’s feet. Not sure if it’s related but the a/c does not stay cold when driving long distance and the HV battery just died last month for no reason. Brand new car.

Filed Jul 30, 2026 · Acceleration, Electrical · GA

While driving on an interstate during a heavy summer thunderstorm, the vehicle suddenly displayed a warning stating, "There may be a problem with the Battery Management System," along with a "Check Hybrid System" message. At the same time, the check engine light illuminated and the hybrid system stopped functioning without any prior warning. Approximately 10–15 minutes before the incident, I had driven through approximately 4 inches of standing water on a surface street at a speed of about 25 mph. After entering the interstate and traveling at approximately 65 mph in heavy rain, the hybrid system suddenly disabled itself. Cruise control was not engaged at any point during the trip. Immediately after the warning appeared, the vehicle experienced a significant loss of power and entered what appeared to be a reduced-power (limp) mode. The gasoline engine continued to run, but acceleration was severely limited, making it difficult to maintain speed or accelerate with surrounding highway traffic. This occurred at night, during heavy rain, on a busy interstate.The unexpected reduction in power created a hazardous situation and increased the risk of being struck by other vehicles while attempting to merge or pull over. After I was able to safely stop and restart the vehicle, the "Check Hybrid System" and Battery Management System warning messages disappeared. The vehicle has approximately 6,000 miles and was purchased new. This vehicle is used to transport my family, including my wife and our three young children. I believe this presents a significant safety concern because the sudden loss of power occurred without warning while traveling at highway speed in adverse weather conditions. Even though the vehicle remained drivable, the reduced acceleration made it difficult to safely maintain traffic flow or move to the shoulder, increasing the risk of a collision. I request that this issue be investigated to determine whether there is a defect affecting the hybrid system.