Heating system fails to generate sufficient heat to defrost windshield or prevent ice buildup in the winter, also impacts the temperature of the cabin. No error codes are generated but it appears the PTC heater is not functioning as expected.
2023 Kia EV6 electrical complaints
Page 3 of 5: complaints 41 to 70 of 105, newest first, as owners wrote them.
10:00 am January 28th AFTER A DRIVE OF APPROXIMATELY 20 MILES TO THE GROCERY STORE, we parked the 2023 Kia EV6 Wind,in the parking area, then entered the store to shop. On returning, we placed the groceries in the trunk and proceeded to leave for home. The push button "START" provoked a notice on the dash that the 12 volt battery was "LOW". The drive circuits would not enable. Prior to going in the store the dash information reported the main battery was at 62%, all else is normal. We are now stuck 20 miles from home. We called KIA roadside assistance, via a cell phone. The Kia site told us it did not recognize the VIN number we had entered three separate times.. It would not proceed down the logic tree for us to be assisted by their service. We called :AAA"they sent a service truck with a jumper battery which allow us to get a small charge on the 12 volt system, enough to get us home. Immediately upon arriving I opened the hood, retrieved my "Fluke DVM" to measure battery voltage. 6.2 volts was the reading. The 12 volt battery was not charged by the voltage regulation system in our car. Fortunately, we were dressed well, being the temperature outdoors was 14*F at the time and we had access to the grocery store for safety. Yet still a major inconvenience due to breakdown. Later, I disconnected the negative battery terminal, then connected the 12 volt AGM battery charger I have purchased for home use. The battery was charged to full overnight to 13.2 volts. I removed the charger cables, then left the battery set for 12 hours disconnected from the vehicle. The voltage dropped to 12.6 volts dc, indicating a healthy battery. This morning January 29th, I called the Kia dealership to explain our problem, the scheduler has acknowledged a possible bad charge control unit, but told me if it was not a control unit problem, I would pay a fee of $135 dollars for the troubleshooting, even though the vehicle has approximately 33,000 miles. Schedule Feb 4th
ICCU failure. Was confirmed by shop car was towed to over phone. But no mention of it on invoice as of yet. I was at traffic light when I heard a pop and when I tried to go, got the warning message to pullover and the turtle icon. I made it to a towable spot. Super fortunate all in all. Can’t imagine if on highway in weather. No hints of failure before. Car was recently purchased month prior. I took it in for recall within first week, was told all good, software was updated. I kept between 20%-80% at all times, charged lvl2 at work daily and lvl1 at home sometimes. Had cheap voltage meter in car and was reading fine. Hope to get my car back soon.
While driving my Kia EV6 in the middle of a snowstorm, the vehicle experienced a sudden and severe power failure. I heard a loud popping sound from the rear of the cabin, after which the vehicle immediately entered reduced-power (limp) mode. Within approximately one minute, the vehicle shut down entirely and lost all propulsion and mobility. I was able to move the vehicle to a safe location only because I was not in traffic or on the highway at the time of the failure. Had this occurred at highway speeds or in active traffic, it would likely have resulted in a dangerous situation with a high risk of collision, especially given the severe winter weather, low visibility, and slippery road conditions. The vehicle has approximately 21,000 miles. This is the second failure of the Integrated Charging Control Unit (ICCU) in this vehicle. The vehicle was inspected by an authorized Kia dealer, who has officially diagnosed the failure as a failed ICCU and associated fuse. There were no warning lights or messages prior to the failure. The first indication of a problem was the popping sound, immediately followed by limp mode and then a complete shutdown without further warning. The vehicle is available for inspection upon request. The repeat nature of this failure, lack of advance warning, and sudden loss of propulsion represent a serious safety defect.
It seems as if the ICCU on my car failed. It will not charge and went into limp mode in order for me to drive it home a few blocks.
The vehicle ICCU failed on 18 January 2026. It previously had the ICCU inspected and updated as part of #24V‑867. Warnings on screen told me to stop driving and pull over. Had vehicle towed to Dealer where they confirmed ICCU failure and initially were going to charge nearly $4000 to repair. KIA Customer care spoke to dealership and ICCU repair is now being covered. It seems apparent that the earlier fix did not resolve the issue, and raises concerns over whether KIA truly understands the underlying cause. Will the replacement fail after 30k miles? Will I be stranded?
Without any warning the car dies on the interstate, it warns you once it fails. The ICCU fails. It left me stranded with my dog.
While driving at normal speed, my Kia EV6 experienced a sudden and complete failure of the ICCU system with zero warning. The vehicle instantly lost all propulsion power and all 12V electrical power, rendering the car uncontrollable and unsafe. I was unable to accelerate, unable to place the vehicle in gear, and unable to activate hazard lights. This occurred despite the vehicle being at approximately 99% battery charge. This failure created an immediate and severe safety hazard, as the vehicle effectively became a dead object in traffic without warning to surrounding drivers. There was no prior alert, no dashboard warning, and no indication of impending failure. This defect is well-documented and pervasive across the Hyundai–Kia–Genesis E-GMP electric vehicle platform and has persisted despite multiple recalls spanning several model years. Kia has acknowledged the issue through recalls but does not have a reliable or permanent fix. Even newer model year vehicles that are claimed to address the issue have experienced the same failure. If this defect occurred in an internal combustion engine vehicle — for example, a random, complete engine shutdown or fuel system failure while driving — it is highly unlikely that regulators would permit the issue to persist across multiple model years without resolution. The fact that this is occurring in an electric vehicle should not lower the safety standard. A sudden total loss of propulsion and electrical power is equally dangerous regardless of drivetrain. Critically, there is no assurance that this failure will not recur, even after replacement of the ICCU or related components. Owners are effectively being returned vehicles that can lose all power again at any time, without warning. It is deeply concerning that this issue remains unresolved after multiple recalls and multiple model years. Continued operation of these vehicles without a verified, permanent fix places the public at ongoing risk.
Got a Check electrical system error, car reduced speed and 12v battery stopped charging. Car was towed to the dealership and they confirmed that the ICCU needed to be replaced.
My Kia EV6’s ICCU failed while I was driving, leading the car to completely lose power while on a busy street.
Car said there was a 12V low battery danger and said to pull over immediately while driving. After taking it to the dealership, they said my ICCU went out. So they had to replace it. I've read that the ICCU on these cars are notorious for failing and needing replacement.
While driving, heard a pop and a check electric vehicle system error popped up on the dash. Car was not drivable except for very low speeds shortly after (impacted safety of the drive) until it eventually stopped being able to turn on at all.
The ICCU that charges the 12V on board battery failed to keep the battery charged and it made my vehicle a paper weight. Had to have it towed to my local Kia dealership to wait 2 weeks for an appt. Hasn’t been repaired yet and I’m sure it won’t be a short wait after they schedule the repair
ICCU FAILURE. Car would not drive
The vehicle experienced a total power failure resulting in complete inoperability (no start, no unlock, no electrical response). This is the second occurrence within approximately five weeks. The most recent incident occurred after the vehicle was fully charged and driven the day prior. There were no warning lights or messages before the failure. The vehicle was previously inspected by an authorized dealer and a manufacturer service campaign related to the charging/low-voltage system was performed, after which the problem recurred. This condition can strand the driver without warning and poses a safety concern.
First year of ownership rear engine needed to be replaced. The car literally stopped where I was on the road and had to be towed to dealer. It took a month to get the motor replaced. After that, my car stopped while I was leaving my house driving it out of my driveway. There were red warining lights and sounds and then it just suddenly died seconds later. It had to be towed to the dealer. They said it was fixed and that the 12v battery wasnt being charged. Then I was leaving church when my car died on me again. Same issue. Now, the third time in this vehicles 2 years of life, my car died while I was on the highway driving to work in the morning in the passing lane during rush hour. The dash went red and waring lights and sounds with a message get to safety quick check electrical system and it only gave me a few seconds the car suddenly just stopped running and I was coasting on the highway to try to get to safety. I was going 70mph in the passing lane during rush hour, I could not steer to the left to coast off the road because on my left it was just a ditch no side road to stop on, I saw in the right lane a car that was a length or so behind so I cut my wheel straight across the right lane where I coasted to a complete dead stop barely making it to the side of the road. The side of this highway was barely the width of my car so traffic flying next to me was just inches away from my drivers side door.... I called roadside assistance and had it towed to the dealer. They then told me about the recall - which I had already had it into the dealer to fix the last time it was there for this same issue. The car is 2 years old and so far I have had it stop dead in its tracks on me 4 times! I have such stress and anxiety about continuing driving this vehicle as it is completely unsafe! I almost died last week when this happened. My safety and others on the highway that day were at risk. This could have been catastrophic.
My 2023 Kia EV6 experienced a sudden ICCU and 12-volt system failure while traveling approximately 50 mph. Without warning, the vehicle instantly lost propulsion and all electrical power. This included loss of steering assist, braking assist, hazard lights, shift capability (unable to shift into Park), and even the ability to lock the doors. The failure effectively “bricked” the vehicle in motion. I was only able to get the vehicle off the roadway because the road happened to slope downward into a nearby lot. Steering required significant physical effort, the brake pedal went completely hard (“dead”), and the vehicle offered no functional parking brake or Park engagement once stopped. Because I was on a hill, we had to allow the car to roll to the bottom until it met a curb to prevent movement. After power loss, the doors could not be locked at all. This type of unrecoverable electrical failure creates an extreme safety hazard for the driver, passengers, and surrounding traffic. There is no pre-warning and no diagnostic indicator. The ICCU fuse appears to fail spontaneously and renders the vehicle uncontrollable in several critical respects. This is not an isolated issue. ICCU failures have been occurring across the Kia EV6 and Hyundai Ioniq 5/6 platforms for more than three years, including on brand-new 2025 models. The persistence of this defect across multiple model years indicates that the underlying design or component defect has not been resolved by the manufacturer. Given the suddenness of the failure, the total loss of vehicle control systems, and the long history of similar incidents reported by other owners, I am now hesitant to drive the vehicle due to the unpredictable and dangerous nature of the defect.
The vehicle can't be changed with a message "issue with electrical system". The message blinks very fast for 3sec and disappears. I have to turn on and off the car a few time to be able to read the message. The the car lost 12V secondary battery, it only shows 5.5V when measured. car is dead.. Replaced with new battery, car can start again but the car still can't be charged. Is it related to ICCU problem? KIA doesn't show any recall to this problem.
ICCU failure
On several occasions, when traveling over 55mph, once the battery hits a certain threshold (35% or 55% so far) the “power is limited” warning will appear on the dash and the vehicle will lose power. This has not occurred at lower speeds but only at higher speeds, and not every time. This vehicle was purchased so my husband could do his freeway commute, but it is on a remote highway where there is often no shoulder, so it especially dangerous to suddenly lose power with limited ability to safely pull over. On one such occasion, he drove the vehicle straight to Kia for inspection. They said the soonest available appointment was in 2 weeks and because they had no technicians available, they could not run the diagnostic that would allow us to get a rental car in the meantime. They suggested going to a different Kia dealership. We called ahead and they said they could try to see it that day or the next, but when we arrived (with, again, the power failing on the drive to the next dealership), they said we were misinformed and they would have to hold the vehicle for at least a week with no rental option. We have since been unable to use the vehicle for commuting due to its unreliability and incredibly dangerous power failure.
The contact owns a 2023 Kia EV6. The contact stated while attempting to unlock the driver's side door with the remote, the door failed to unlock. The contact manually unlocked the door with the key. In addition, while attempting to start the vehicle, the vehicle failed to start, with the message "12-Volt battery failure" displayed. The vehicle was towed to a local dealer; however, the vehicle was not diagnosed. The vehicle was not repaired. The contact referenced the federal safety agency Campaign Number: 24V200000 (ELECTRICAL SYSTEM); as a probable cause for failure. The manufacturer was notified of the failure. The approximate failure mileage was 30,000.
had 3 recalls on ICCU module, each time dealer said everything was OK. Last "repair" was in January. In April, car just "died" nothing worked, could not shift, no acceleration and limited braking, had to call a tow truck to move it as everything was locked up. dealer said ICCU shorted out, 3 week repair time, and this is down from 3 month repair time 2 weeks ago. The only warning we had was a dash message to check electrical system, meanwhile Kia app for car said everything was OK, no problems with any thing. dealer listed faults as, P1A9096 dc converter sensor fault, P1E3716 battery charger V2L low voltage, other low voltage comm codes as well but not listed
The ICCU in my Kia EV6 failed while driving. Thankfully I was not involved in a crash, but my speed was capped at 30 MPH, crawled back home, where the vehicle wouldn't start. I had to get it towed to the service center. All of this besides all recalls and software updates being addressed. There were multiple warning lights that went off during my drive: "Stop vehicle and check power supply" "Check electric vehicle system"
On April 6, 2025, while charging my car my Juicebox tripped a breaker. When I reset it the Juicebox was showing errors and was inoperable. I tried to use my backup charger (Blink) but it tripped a breaker and became inoperable too. I took the car a commercial charger (ChargePoint) and it would not charge the car. Kept getting a “charge interrupted” message. The first Kia dealer I went to did not have a Level 2 charger and could find nothing wrong and refused to help repair the car. The second Kia dealer had a Level 2 and confirmed it would not charge, but Kia would not authorize a warranty fix. That dealer suggested leaving the car for a few days and hope the car generates a fault that Kia will accept to authorize a fix. •What component or system failed or malfunctioned, and is it available for inspection upon request? The Level 2 AC charging no longer works. •How was your safety or the safety of others put at risk? The car tripping 240-volt breakers and making two 240-volt chargers inoperable is concerning. •Has the problem been reproduced or confirmed by a dealer or independent service center? One dealer has confirmed the Level 2 charging no longer works. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It was inspected by a Kia service shop •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? None
I want to disclose this is the 2nd time this has happened. I was on the highway when the system failed. Immediately and drastically forced my car down to 25mph on [XXX] going to Philadelphia in the far left lane with no warning. I had to make it across 3 rows of traffic and ride on the shoulder of the highway until I could find a safe place. One ruining the sport tires on the car and probably messing up suspension since these cars are very sensitive and the highway does have those perforated shoulders. While cars zip past me I am having to figure out how to pull over with no force. None of the functions were working. It was traumatizing. Especially to do it again after 6 months ago the same thing happened. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On January 27th I was driving home on I-495 in the far left lane going about 70MPH when the electrical warning light came on. Telling me to stop the car and take to the dealership. While I was trying to get over into my far right lane, the car went from 70mph to 25 mph in about 40 seconds! Cars were flying all around me! It was terrifying and incredibly dangerous! The dealership discovered my ICCU had failed. This vehicle has a fatal flaw that is going to get someone killed.
Integrated Charge Control Unit (ICCU) failed. Charging error appeared on 30 March 2025. Next attempted to drive vehicle on 2 April 2025. Accessory battery suddenly dropped from 12V to 8V. Vehicle displayed "Stop Vehicle and Check Power Supply." Was able to crawl home in "Turtle mode" before tow to dealer. P1A90(96) [0x1A9096] among the Diagnostic Trouble Codes stored. Dealer confirmed ICCU failure and estimates at least one month to repair. SC302 was applied on 13 May 2024 at 5,732 miles. SC327 was applied on 2 Jan 2025 at 10,506 miles. 12V accessory battery is original (sealed lead acid).
ICCU failure. Car was dropped off with Kia and the (second) recall they claimed to have performed did not fix the 12-v battery charging system error. They ordered in a new part, which was on national backorder and they provided no ETA. I had to purchase a replacement vehicle after 30 days of them having the vehicle without making the repair, providing an update, or having given me a loaner. Received message it was fixed after 37 days, but no information whether it is with a new part. Subreddit for the EV6 shows this is a widespread issue that has not been permanently resolved. When the ICCU fails, you are limited to 25mph "limp mode" and will lose ability to move car if 12V battery dies.
I have received at least two recalls on the ICCU component on my Kia EV6, which were taken to the dealership for repair per the recall. On April 4, 2025, my vehicle displayed the "Check Electric Vehicle Systems" and "Stop vehicle and check power supply" alerts. It had to be towed to the dealership, as it cannot be driven. They called and stated it was related and the part is on back order for the unforeseen future.
While driving my car a warning flashed stating "check electrical vehicle system." Pulled over, contacted Kia of Abilene and asked if we could drive the car to the dealership. While on the phone another warning flashed ""Stop vehicle and check power supply." Attempted to drive car, "Limp mode or turtle mode" occurred and the max speed for the car was 25mph, sudden loss of acceleration. Made it home, which was approximately 2 miles away, and it seems like the 12V battery was draining quickly. Eventually the vehicle stalled at home and became unresponsive, no power. Contacted roadside assistance and the vehicle was towed to Kia of Abilene. All of this occurred March 29th at approximately noon. The dealership finally contacted us today, April 2nd, and notified us it was an ICCU failure and the part wasn't available with no foreseeable time-frame for repair. The car is absolutely inoperable!
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Kia EV6?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history