In June 2025, while driving my 2023 Kia K5 (VIN: [XXX] ) at highway speeds on [XXX], the fuel tank suddenly imploded. A loud bang caused the rear seats to lift, startling me and my passengers. The car lost power, and braking too hard risked leaving us stranded in fast-moving traffic. I narrowly avoided a crash while trying to maneuver us to safety. This vehicle was previously recalled by Kia in April 2024 for a fuel tank defect affecting ~236,000 vehicles. I took it to Gunther Kia in Davie, FL for inspection, and they claimed it was fixed. In March 2025, I returned to Hollywood Kia because of popping sounds and a check engine light. They diagnosed and “repaired” a purge control valve but failed to address the underlying defect. Despite these repairs, the catastrophic failure still occurred. The vehicle is now completely inoperable and irreparable. Kia later offered to buy back the vehicle but failed to respond to over 200 calls and dozens of emails from me, allowing their offer to expire without explanation. This left me paying for a vehicle I can no longer use. This defect poses a serious danger not only to me and my passengers but also to thousands of other K5 owners nationwide. I urge the federal safety agency to investigate Kia’s recall handling and ensure affected vehicles are properly repaired to prevent injury or death. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2023 Kia K5 fuel system complaints
Page 3 of 3: complaints 41 to 56 of 56, newest first, as owners wrote them.
My 2023 Kia K5 GT (VIN: [XXX]) is experiencing a dangerous complete power loss at highway speeds. I was driving at the speed limit on [XXX] when the vehicle lost propulsion, entered limp-home mode, and illuminated every warning lamp. This has happened six times since purchase. The car is currently parked, and I am not confident enough to drive the car; I nearly missed a crash pulling into the emergency lane from the leftmost lane to the rightmost lane. After losing power in the engine, that was a traumatizing experience. I tried to explain this to people multiple times at different service centers, but they care less: "We can't fix it unless we can reproduce it," but this happens randomly; I cannot make it happen at the service center. This matches the recall SC250 symptoms exactly, though my VIN is excluded. I have tried with Multiple dealers before, but they cannot fix it. They say, "We cannot fix it unless we can reproduce it." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On Friday 5/16/25 my check engine light was on when I went to leave for work and when I began driving I felt excessive air flow coming from my back seat. I stopped and noticed that the back seat had popped up. I then noticed my gas gauge was showing empty, but my digital reading was correct.. The car was sluggish and my son's father told me that the gas tank was swollen and to stop driving it. I called Kia on Saturday morning and was told I could bring it in today at 9am. I left the car and was given a loaner, but I do not feel it would be safe to ever drive that car again. They immediately knew what the problem was and said it was a recall, but I was never notified about it. It was extremely scary driving it to Kia this morning because they are over 50 miles away from where I live.
While driving, thankfully not with my [XXX] son, the vehicle made a real big bang noise and lost power. Looked back and the whole back seat was lifted. Towed to dealer and tech found that fuel tank had expanded and exploded seat back. Incident happened in November 2024, and to this day, Kia has been the most difficult to deal with. They offered to buy vehicle back, but we have been waiting for a long time for answers and resolution of this issue. Its impossible to get someone on the phone and we keep getting the run around with a loaner/rental while trying to continue to live normal life going to work and dropping kid at school INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2023 Kia K5. The contact stated that while driving at 65 MPH in hot weather, a loud popping sound came from underneath the vehicle. The vehicle lost motive power. The check engine warning light was illuminated. The contact coasted into a ditch and inspected the vehicle, but no exterior damage was found. The vehicle was restarted and driven to a gas station. The check engine warning light was no longer illuminated. The vehicle was taken to the dealer, but the cause of the failure could not be determined. The failure persisted and the fuel gauge level dropped while driving. The contact pulled over and placed a bag under the vehicle to check for fuel leaks, but found none. The contact stated that the vehicle failed state vehicle inspection due to an unknown emission code. The vehicle was taken back to the dealer, who performed an oil change and updated the computer system. The failure recurred while driving with three minor children in the rear seats. The fuel tank made a loud explosion, and the rear seats propped up, pushing the children forward while the seat belts restrained them in their seats. The child seated in the rear passenger seat received medical attention for injuries to the back of his legs caused by hot fuel fumes from underneath the seat, as well as black specks stuck on his legs. The contact's husband opened the fuel tank, and loud air pressure was released. The fuel tank was bubbling. The vehicle was towed to Classic Kia of Carrollton (2920 N Interstate 35E, Carrollton, TX 75007), who determined that the fuel tank needed to be replaced and requested that the manufacturer send an engineer to inspect the vehicle. The vehicle was towed to the third dealer, Huffines Kia Corinth (6940 S Interstate 35, Corinth, TX 76210), where an engineer determined the vehicle was non-repairable due to the fuel tank expanding in multiple locations and bending the sub-frame. The contact was informed that the fuel tank was manufactured without a pressure release valve. The vehicle was not repaired. Up
Component or System Failed: The fuel tank exploded, causing the vehicle to become undrivable. The explosion was so severe that the back seat was completely blown off. The vehicle is currently not in my possession, as it has been with the dealership for over three months. I have photos and proof of the damage, and I am willing to provide them for inspection. How Safety Was Put at Risk: I have a [XXX] son who sits directly above the fuel tank in the back seat. When the explosion occurred, the back of his seat was completely blown off, and had he been in the car at the time, he could have been seriously injured or killed. This was an extremely dangerous defect, and I am deeply concerned that this could happen to other Kia vehicles, putting more lives at risk. Beyond the immediate danger of the explosion, I have been left without a working vehicle for over three months, and Kia has provided no resolution. Despite confirming that the vehicle is not repairable, they have stalled the process, forcing me to continue making payments on a car I do not even have. Problem Reproduced or Confirmed by a Dealer or Independent Service Center? Yes, the Kia dealership confirmed that the vehicle is not repairable and that the fuel tank failure was severe. However, they have not provided any solution or compensation. Has the Vehicle Been Inspected? Yes, the vehicle was inspected by the Kia dealership, which determined that it was not repairable. I do not know if it has been inspected by any third-party mechanics, insurance representatives, or other authorities. Warning Lamps, Messages, or Symptoms Prior to the Failure? There were no warning lights, messages, or other symptoms prior to the explosion. The vehicle was operating normally before this occurred. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Heard and felt extremely loud BANG under the car while driving then check engine light came on. Vehicle had low power and the gas was decreasing severely fast. The backseat had moved with our 2yr daughter in her car seat above it. Took it to dealership and they said the gas tank expanded and couldn't be fixed. They offered bottom dollar to buy it back
Engine came on and off twice, car was smelling like gas and driving rough. Tried to put gas in car and it would not take the gas, it wasted all over car. I checked my back seat and felt it was hard and sitting right so I looked under and the seat was lifted. After doing research, I learned I have an expanded fuel tank. Not only that but there has been a recall on it that I was unaware of, I took the car immediately to the nearest dealership and they acknowledged there’s a recall and I can’t drive the car because the backseat can explode anytime now.
The contact owned a 2023 Kia K5. The contact stated that while her son and daughter-in-law were driving, three loud bangs were heard coming from underneath the vehicle. The vehicle was pulled over to the side of the road and inspected; however, no cause for the banging sounds were found. The vehicle was then taken to a gas station to be inspected, but no cause for the sounds were found. The contact’s son then added fuel to the vehicle, but the fuel spilled from the filler neck. The vehicle was taken to the residence. The vehicle was then taken to a dealer where it was determined that the gas tank had expanded and damaged a part underneath of the vehicle. The vehicle was taken to be inspected after being deemed a total loss. The manufacturer was notified of the failure. The failure mileage was unknown.
Ive a 2023 Kia K5 GT-Line AWD with 73000 mileage. I was having a trip from New Jersey to Massachusetts for a wedding. I had 208 miles to go and 223 miles range. Than suddenly it went down to 93 miles. I stop by a gas station. I could not pump gas. It was kicking the nozzle. I atop by another gas station miles later. I couldnt pump gas either. It kickes the nozzle and my gas tank looks full. Than i start the car and check engine light and P045100 code came on. Than i checked the closest KIA but it was Saturday. They couldn’t service i was at Rhode Island. I called one of the KIA and they said as long as CEL is on i can drive. If its keep flashing i shouldnt drive. I said it smells gasoline and i cant fill up my tank and i asked if they have a suggestion and they said idk and closed the phone. Than i heard a clicking noise and it smelled a lot more gasoline. I saw that my rear seats popped up. I saw that one of the gas tank or whatever it is was up and my tank was expanding. I had to leave my car to another dealer nearby airport at Rhode Island. They will check my car at Monday. I rent a car from airport enterprise. I guess ill need to wait and see. I knew that there is a recall. But i went for an oil change at 60000 mileage and my local dealer told me that there was a recall and they checked and thats why it took long and im good to go. So they checked the recall and it was fine and now its not fine. I had the recall done but it still happened. My car stayed at dealer from 10 days. They couldnt fix it and someone from Kia Tech came to check, while they are checking the gas tank had a mini explosion as they said. Kia is going to buy my car back and they confirm that i can either get a replacement or buyback. They confirmed that there is no permanent fix for it. They do not know how to fix it.
Ive a 2023 Kia K5 GT-Line AWD with 73000 mileage. I was having a trip from New Jersey to Massachusetts for a wedding. I had 208 miles to go and 223 miles range. Than suddenly it went down to 93 miles. I stop by a gas station. I could not pump gas. It was kicking the nozzle. I stop by another gas station miles later. I couldnt pump gas either. It kickes the nozzle and my gas tank looks full. Than i start the car and check engine light and P045100 code came on. Than i checked the closest KIA but it was Saturday. They couldn’t service i was at Rhode Island. I callled one of the KIA and they said as long as CEL is on i can drive. If its keep flashing i shouldnt drive. I said it smells gasoline and i cant fill up my tank and i asked if they have a suggestion and they said idk and closed the phone. Than i heard a clicking noise and it smelled a lot more gasoline. I saw that my rear seats popped up. I saw that one of the gas tank or whatever it is was up and my tank was expanding. I had to leave my car to another dealer nearby airport at Rhode Island. They will check my car at Monday. I rent a car from airport enterprise. I guess ill need to wait and see. I know that there is a recall. But i sent for an oil change at 60000 mileage and my local dealer told me that there was a recall and they checked and thats why it took long and im good to go. So they checked the recall and it was fine and now its not fine. My gasoline tank expanded. My car is located at Bold Hill Kia in Warwick, Rhode Island. I was scared to drive but i had no other choice and the serviceman in one of the dealer told me to drive so i drive to another KIA.My vehicle was inspected for the SC288 Recall [XXX] ) There was a check engine light with the obd code of p045100. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2023 Kia K5. The contact stated while driving at an undisclosed speed, the contact heard a loud ticking sound coming from the fuel tank. The check engine warning light was illuminated. The vehicle was taken to the dealer where the vehicle was diagnosed as a failure with fuel tank expansion. The contact was contact informed that the fuel tank expansion needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 270,000.
I was driving and it was a loud noise. My son flew up with seat belt on hit his head on roof , gas tank blew up / or swelled up and my back seat is sitting about 10-12 inches above then normal. Very scary and worried
Gas tank expanded and bent the undercarriage up so much it blew off the fuel pump cover and pushed up the back seat.
I was driving on [XXX] Orlando Florida on [xxx] doing approximately 70 miles an hour when a large explosion occurred out and within my car the whole car shook this happened twice within a 5 mile radius. The car was eventually brought to Kia city in Orlando, where they determined that the fuel system had failed . the valve had failed, and the fuel system tank and fuel pump had swelled and blew .This could lead to catastrophic explosion in the vehicle, and or someone catching on fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2023 Kia K5. The contact stated that the interior of the vehicle had an abnormal gasoline odor. The contact stated that the gasoline odor was inside and surrounding the outside of the vehicle. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated the vehicle was previously taken to a dealer a month prior, but the failure could not be duplicated. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was unavailable.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Kia K5?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history