The car seized operating, shut down with zero warnings. It has been a reliable car and maintained. We towed to a mechanic who said it was engine failure. Thankfully we had just exited off highway and on a side street when it became inoperable or it would have been detrimental.
2012 Kia Optima engine complaints
Page 2 of 15: complaints 11 to 40 of 418, newest first, as owners wrote them.
On or around October 17th 2025 I purchased a 2019 Kia OPT un aware that the vehicle had recall problems. Once I realized the vehicle had problems I took it to get it checked out. I only had the vehicle for 2 days before the problems occurred. The Kia service center fixed the recalls all except the bearing failure. They had my car for almost 30 because we went back and forth over this issue. This reason they gave me the reason they couldn’t fix my bearing problem was because I didn’t get it checked out before I had the problem. I didn’t know the vehicle had a problem until the recall came to my attention. I just don’t understand this explanation because it just doesn’t make any sense to me. This model vehicle had a premature bearing wear long before I had this vehicle. It’s a manufactured problem and just because it wasn’t reinstated before the vehicle had the problem Kia will not stand behind the problem with this vehicle and I don’t understand that explanation. Please, please help me get this issue fixed for me please. This has really taken a toll on me and I can’t afford to just junk this vehicle so please help me. Thank you so much for trying to help me with this problem.
Subject: RECALL VIOLATION: Kia on the Boulevard (Philadelphia) - Refused Remedy, Charged $199, Returned Unsafe Vehicle Vehicle Information: [Year] Kia Optima Hybrid Dealership Name: Kia on the Boulevard Dealership Address: 11295 Roosevelt Blvd, Philadelphia, PA 19154 Complaint Description: 1. The Safety Incident: While operating the vehicle, I experienced a catastrophic engine failure. Thick smoke poured from the engine compartment, followed by immediate stalling. This presented a severe fire risk and safety hazard. 2. Dealer Misconduct & Illegal Charges: I towed the vehicle to Kia on the Boulevard (11295 Roosevelt Blvd, Philadelphia) for the active engine recall remedy. The dealership: * Refused to perform the recall repair free of charge. * Forced me to pay a $199 "diagnostic fee" just to look at the recall-related defect, which should be covered by the manufacturer. * Threatened me with $45/day storage fees if I did not pay the $199 and remove the vehicle immediately. 3. Current Status: Under the threat of accumulating storage fees, I was coerced into paying the $199 and towing the vehicle back to my residence. The dealership knowingly released a vehicle with a catastrophic engine failure (smoke/fire risk) back to the owner without performing the federally mandated remedy. The unsafe vehicle is now sitting at my home unrepaired. 4. Conclusion: I request an immediate investigation into Kia on the Boulevard's refusal to honor the recall and their practice of charging customers for recall-related inspections.
To: Administrator the federal safety agency 1200 New Jersey Avenue SE Washington, DC 20590 USA Subject: Formal Safety Defect Claim Regarding Unaddressed Recalls — 2012 Kia Optima Hybrid (VIN: [XXX] ) From: [XXX] Email: [XXX] Phone: [XXX] Vehicle Information: - VIN: * [XXX] ** - Make / Model: 2012 Kia Optima Hybrid - Mileage: approx. **250,000 miles** - Current Location: Moldova (vehicle manufactured in Korea for the US market) --- ## Summary of the Problem I am writing to file a **formal safety defect claim** regarding my 2012 Kia Optima Hybrid, VIN * [XXX] **, which, despite having documented recall campaigns, has never had critical parts replaced. As a result: 1. **Internal scoring and scratches (zadir)** have been detected within the engine, consistent with **metal shavings / debris** circulating in the oil system. 2. There is **metallic residue (shavings)** found in the oil pump, which strongly suggests that worn or damaged components (likely from a manufacturing defect) were never replaced during the recall. 3. Given the extraordinarily high mileage (≈ 250,000 miles), the continued use without the required recall repairs poses **significant safety risks** and potential for further engine failure or fire. 4. I was not provided with a proper remedy when recall notices were issued — in my case, the relevant parts were not replaced in a timely fashion (or at all), despite the recall campaigns being active, leading to the deterioration of the engine. --- ## Legal and Technical Basis ### Recalls Applicable to My Vehicle - the federal safety agency Recall **20V750** for the 2012 Kia Optima Hybrid: This is a recall related to engine defects, including risk of engine fire. [oai_citation [XXX] ] [XXX] ) - the federal safety agency Recall **23V652**: This relates to the Hydraul INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
June 26th 2025 my Kia optima 2012 EX quit on interstate 65 in Alabama was towed to dealership 10 days later was requested that I turn in maintenance records which I did. 10 days after that I was contacted and I was told that they could not read some of the records i so resubmitted. No official diagnosis was told they just informed me that the motor would be replaced. They've since removes it from the dealership to a third location. Spoke with Kia consumer affairs in a three-way call to the dealership we were hung up on three times. Trying to find out where the car had been towed to. The car is now at Monrovia towing in Alabama at $40 a day. I have takwn good care of this Kia it falls under all the criteria there were no lights no warning signs it just shut down. Not only was the dealership evasive about their decision or the decision they made me feel as if I had done something wrong when I've only had the car 3 years taken very good care of it had the oil change by fiance the records and receipts of purchase oil. Devastating. Lengthy and financially crippling. I was lead to believe early on that it was a done deal to replace the engine . They accused of fraud in regards to the records. Untrue. This has caused so much stress and anxiety in my life. I am now without transportation. I have a special needs daughter and this car was a lifeline for us. I did nothing wrong I loved this car . I'm now having to let the car go because the towing company is going to auction the car.
Driving car on the highway then the car started smoking and shut down completely. IT would not turn on or anything. It smell burnt.
I am submitting a formal complaint regarding my 2012 Kia Optima, which experienced an engine fire directly related to the defects identified in Kia Safety Recalls SC147, SC200, and SC201. On XXX, my vehicle’s engine failed and caught fire. This is the exact condition covered by the above recalls, which state that affected engines may seize, stall, or ignite. I have been in contact with both a Kia dealership and Kia Consumer Affairs for close to a month without any resolution. The dealership has confirmed that my car requires a complete engine replacement, but Kia has refused to address the recall issue, claiming that other unrelated recalls were not performed. When I previously contacted dealerships to schedule recall repairs, I was told that parts were not available, which prevented me from completing them. In addition to the engine failure, the fire also caused my starter to fail. I was forced to purchase a replacement starter out of pocket, which has added to my financial hardship. I believe I am owed compensation for this expense, as it was a direct result of the safety defect. This situation has caused me severe financial strain, as I relied on my vehicle for work and currently have no income due to its inoperability. Kia has not provided a timeline for repairs, towing coverage, or written confirmation that they remain obligated to remedy this federally mandated safety defect. I am requesting that the federal safety agency investigate Kia’s refusal to fulfill its recall obligations and intervene to ensure that my vehicle is repaired or replaced in compliance with federal recall requirements. My vehicle details are as follows: •Year/Make/Model: 2012 Kia Optima •VIN: XXXX •Recalls involved: SC147, SC200, SC201 •Incident: Engine fire, vehicle no longer drivable; starter also failed due to fire Please advise on next steps. Thank you for your time and attention to this matter. Sincerely, XXXX XXXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Bearing wear resulted in the engine seizing.
See attached document for complaint.
On August 25th around 7:00 PM, the vehicle suddenly caught fire while parked after a short test drive. The car had just been purchased a few days prior and was taken to a mechanic for a precautionary inspection. During the test drive, the mechanic parked the vehicle in a residential driveway. After backing in, smoke was observed coming from the engine bay. When the hood was lifted, the engine area was already on fire. The fire department was called immediately and was able to extinguish the flames before the fire spread to surrounding property. The fire completely destroyed the vehicle. The vehicle had no warning lights, unusual performance issues, or prior signs of trouble, and it appeared to be in good condition prior to the incident. This fire posed a serious safety hazard and could have resulted in injury or property damage. Component or system that failed: The engine area, likely associated with the Hydraulic Electronic Control Unit (HECU) fuse/fire risk. The vehicle may or may not be available for inspection, as it is severely burned. Safety risk: The fire posed a serious hazard to the mechanic, surrounding property, and anyone nearby. Rapid ignition could have caused injury or significant property damage. Problem confirmation: The fire was observed firsthand by the mechanic. The open recall related to the HECU fuse/fire risk indicates a known defect consistent with the incident. Inspections: The fire department responded and documented the incident. The vehicle has not yet been inspected by the manufacturer or insurance representatives, but the recall status is verifiable through official records. Warning signs: There were no warning lamps, messages, or other symptoms prior to the failure. This incident appears consistent with the conditions described in the open recall for the HECU fuse/fire risk, suggesting a possible link between the recall defect and the fire.
I took my car to the KiaOfLynchburg dealership for get the recalls done and diagnostic test on my engine as it was knocking and they had it since may 06, 2025. The dealership said at first I had a code to get the engine replaced no cost. Now got a phone call on June 19, 2025 saying how my car was on fire but the fire department made it on time to put it out. So did the claim on it they denied me saying it’s due to a aftermarket but tell me it cause of oil leak. And I do not have no aftermarket hook up in the vehicle. Now they won’t take responsibility for the damage they did to my car
My 2012 Kia Optima experienced engine failure due to a dropped valve. The dealership (Kia of Des Moines) performed a borescope inspection but stopped after discovering the broken valve. This means rod bearing failure was not ruled out. Two separate service reports conflict, one citing Cylinder 2 and another citing Cylinder 3. Kia denied coverage, citing that the failure was unrelated to the settlement and outside the mileage warranty
Driving home from an oil change. All of a sudden all power was lost. Luckily a wide spot in the road was right there. Car would not start back up. Checked oil- it was good. Had car trailered to a mechanic. He took off oil filter and cut it in half- was full of metal shavings. Said needs new engine. We trailered the car back home, where it currently sits. If the wide spot in the road wasn’t there, they’re likely would have been an accident being this was right on a sharp corner.
The contact owns a 2012 Kia Optima. The contact stated that while driving at 30 MPH, the contact pressed on the horn, and the horn failed to function as intended. No warning lights were illuminated. The contact stated that on a separate occasion, upon starting the vehicle and attempting to adjust the driver’s side mirror, there was an abnormal clicking sound coming from the side-view mirror motor. The contact stated that several days later, the abnormal clicking sound ceased, and the driver’s side mirror failed to function as intended. On a separate occasion, the passenger’s side mirror motor was making an abnormal clicking sound. Several days later, the clicking sound ceased and the passenger’s side mirror failed to function as intended. No warning lights were illuminated. The contact stated that while attempting to close the sunroof, the motor failed to function as intended and the sunroof was half closed. The contact had to place a tarp over the sunroof to protect inside the vehicle from the elements. No warning lights were illuminated. Recently the vehicle received maintenance and there was an abnormal knocking sound coming from the engine. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that while driving at slow speeds, the vehicle stalled. The contact was able to coast to the side of the road. No warning lights were illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that an unknown part had failed in the engine. The contact was unsure what part of the engine had been replaced. The failure recurred, and the contact had safety concerns about the vehicle. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
The contact owned a 2012 Kia Optima. The contact stated that while driving 60 MPH, the vehicle jerked, with an abnormal hissing sound coming from the front of the vehicle. The contact stated that there was smoke coming from the rear of the vehicle and entering the cabin of the vehicle through the A/C vents. The contact stated that several warning lights were illuminated. The contact pulled over to the side of the road and the vehicle was towed to an independent mechanic. The contact was informed that there was a hole in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The contact notified the insurance company; however, no claim was filed. The failure mileage was approximately 160,000.
Car simply started for me after work this past Thursday @4 pm I dove down the street and for about 5 mins and had to turn around due to me leaving something at work. When I arrived back at work I parked and cut my car off as I normally do and when I returned to start it back up it never did. I have previously been having to add 5 quarts of oil frequently at least once or twice a month for the past 7 months since last year. Was told my car had an oil consumption problem by a previous mechanical shop last year. Noticed that these cars have recalls on them and that my car and year do fit the requirements. I do owned my car with the Title in hand. It’s NOT a salvaged title. I have a service appointment on the 24th of June next Tuesday at Kia of Gastonia located in Gastonia, NC. I have to get my car towed to this establishment on Monday or the morning of my appointment. I’m asking that this situation can be properly investigated and properly and honestly handled under KIA policy. My name is [XXX] my # is [XXX] thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2012 Kia Optima. The contact stated that while his daughter was driving on the highway at 65 MPH, the vehicle lost automotive power, with the check engine warning light illuminated. The vehicle was towed to an independent mechanic where the vehicle was diagnosed, and the contact was informed that the internal bearings had failed, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 200,000.
Subject: Recall Denial Due to Salvage Title – 2012 Kia Optima (VIN:[XXX]) I am submitting a complaint regarding Kia Motors’ refusal to perform a recall repair on my 2012 Kia Optima (VIN: [XXX]) due to the vehicle having a rebuilt title. My vehicle is equipped with the 2.4L GDI Theta II engine, which has been recalled for known safety defects including risk of engine seizure and fire. I brought my car to a local Kia dealership for the recall repair, but they refused service based solely on the vehicle having a branded (salvage) title. I then contacted Kia Consumer Affairs and was again told that the recall does not apply to salvage vehicles—even though the engine defect clearly stems from poor design and is unrelated to any prior accident or title status. I am concerned that Kia is ignoring its obligations under federal recall law and putting drivers like myself at risk. Denying a recall based solely on a salvage title—especially when the defect has nothing to do with the car’s condition—undermines public safety. I respectfully ask the federal safety agency to investigate Kia’s refusal and consider whether policies like this should be permitted under federal recall enforcement standards. Sincerely, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I was driving home at night around 8pm. I was merging into the slow lane and my car completely lost power. A semi truck was right behind me. Luckily I was able to get over to the emergency lane safely. My car had no acceleration at all or any control of the steering. Prior to this incident there was no problem or warnings of any lights on dash or car having problems. It’s a daily driver for me to work. It’s never gave me any problems prior to this. I’ve had the routine maintenance done on along with the recommended mileage maintenance done. It’s been over a month now and my car still won’t start I haven’t had time to get it towed to a dealer ship or repair shop because I work 17 hour days. Everything I’ve researched about my make and model is starting to indicate that the engine seized up. I really hope that’s now the case because my car will be paid off in 3months. It has 165k miles on it I need help on weather the engine is part of a recall.
The contact owns a 2012 Kia Optima. The contact stated while driving downhill at approximately 40-45 MPH, the vehicle shut off. The battery, oil, and check engine warning lights were illuminated. The brake pedal was depressed, but the pedal was firm. There was an abnormal clicking sound coming from the vehicle. There was smoke coming from the engine. The contact attempted to turn off the vehicle; however, the transmission failed to shift to park. The vehicle was towed to the residence. The dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 154,782.
On the evening of December 5, 2024 my 2012 KIA OPTIMA's engine completely seized out of no where while traveling on a very busy road where the speed limit is 50mph putting my life and other drivers that share the roads life in danger. Thank god I was able to succesfully merge over into a safe place as the car came to a hault. Previous to this incident the car was running perfectly fine with no dash lights on what so ever. Once I was in a safe place I called KIA headquarters immediatly, I was told that I have to pay to have the vehicle towed to the nearest dealership and that I would be reinbursed depending on the issue of the vehicle after being diagnosed. The very next morning I called KIA corporate to open a case for the vehicle, in which i was told that my specific year, make and models engine was under a lifetime warranty. I then recieved a call from the dealership Decmember 6, 2024 and i was told my optima would be diagnosed and if the issue is due to the KIA engine class settlement that the engine would be replaced free of charge and if it is not then I would have to pay $380 to have the engine repaired under the lifetime warrantly & that the car could not be looked at until December 16, 2024. Once December 16, 2024 came around I recieved a call from the KIA dealership and I was told that my vehicle could not be diagnosed due to the time frame in which i bought the vehicle and that I needed to have my car moved from their lot or I would get charged $80 a day storage fee so I had to have my vehicle towed back to my home where it is currently just sitting. To this day (January 22, 2024 I am still dealing with trying to communicate with KIA CORPORATE AMERICA to have this matter resolved for I am very aware of the engine recall issue for my specific year make and model. My vehicle has yet to be inspected and the only time the warning lamps came on was once the engine completely seized, all of the dash lights popped on.
While driving 2012 Kia Optima GDI home from work, the power suddenly stopped without warning with the engine, oil, and battery lights flashing on all at once. I was unable to accelerate whatsoever, so with the momentum of the vehicle I parked safely in a parking lot. There I discovered the car would not start and would give a loud clunking sound. A mobile mechanic confirmed that the engine was seized, and I had it towed to the nearest KIA service center. They were able to also confirm it was an engine seize, but insisted KIA would not replace the engine despite a recall notice of the motor of this vehicles make and model in 2017 (SC147).
The contact owned a 2012 Kia Optima. The contact stated that while at a stop light, smoke and flames were suddenly present coming from the engine compartment. The fire department was called to the scene and extinguished the fire. During the incident, the vehicle was destroyed and later towed to an inbound facility. No report was taken and no injuries were reported. The cause of the fire was not determined. The local dealer and manufacturer were not yet contacted. The contact was informed that the VIN was included in the federal safety agency Campaign Number: 23V652000(SERVICE BRAKES, HYDRAULIC). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 151,000.
Power train and engine failure and causing my Kia to catch on fire at 11:30 coming back home from work. I was Driving home and smell smoke and car was shaking and when I stopped at the highway to open and look fire was on while driving and I had to call 911 and stop the fire. I had some fire extinguisher in the car I stopped the fire and towed the car and I replaced engine and powered train For over $9000 between repairs and labor and transmission and engine
The contact owns a 2012 Kia Optima. The contact stated while driving at various speeds, the vehicle went into LIMP Mode and failed to exceed 61 MPH. The RPM failed to exceed 2,000 RPM. Additionally, the contact stated that the vehicle failed to exceed 45 MPH while driving uphill, and the vehicle failed to exceed 55 MPH while driving downhill. The contact scanned the vehicle with a vehicle scanner and retrieved codes indicating an oil control valve failure. The contact replaced the oil control valve; however, the failure recurred. The vehicle was taken to the dealer where the fuel rail system, the fuel tube clamps, and the bolts were replaced under the federal safety agency Campaign Number: 18V907000 (Fuel System, Gasoline, Engine); however, the failure persisted. The vehicle was taken back to the dealer several times. The dealer replaced the battery, the engine oil, and other unknown parts; however, the failure recurred. Additionally, the contact stated that the vehicle was experiencing excessive fuel consumption. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 157,000.
Car went to limp mode and has code p1326. Car was towed to kia and waiting on determination of kia in korea to cover engine. Car has 63,000 miles
Driving on highway at about 60mph when the engine started knocking and the power decreased significantly. I pulled to the side of the road and called my day who came and brought his OBD 2 tester. The code was P1326 which is Knock Sensor. We had the car towed to a KIA dealer nearby and they updated the software. We picked up the car the next day. It seemed fine at first. Within two weeks the the same thing happened and we, once again had it towed to KIA. Within a few days, the service writer called and said that the engine needed to be replaced, but that KIA was denying an engine replacement. They said that they found sludge in the engine that in their opinion showed a lack of maintenance. We sent in receipts for oil changes every 5-6K miles. At this point, we do not have an answer regarding an engine replacement.
The engine caught fire and exploded after I parked it and exited the car and the recall repair was done on the engine July 5 2024 by Kia dealership.
I started the car up no lights on, started fine, no warning symptoms like loss of power, no oil consumption nothing! Started an hour and a half drive to visit family and I started hearing a weird sound almost like plastic was flapping around on the bottom. Turned down the music and it was only making this weird sound every 5-10 seconds. Pulled off of the road shut the car off and checked under the hood, the oil everything seemed fine. Started it up and heard the sound again and suddenly became worse and came to the conclusion it’s a rod knock. Had to get off the busy road so continues for maybe 1 mile and every dash light came on shut it off waited for a trailer, once we got it on the trailer the lights were gone. The dealership near me is saying they can’t do anything due to a recall update not being done but I had a newly programmed ECU that was put in in March of 2023 and I was some research and i found a few things stating the ECU would be completely up to date but kia is fighting me on it. I have also been update to date on maintenance records. Since its been at the dealership I’ve asked for the other 2 recalls that are open on it to be done while I figure out what to do with it and they bypass me asking everytime.
I was driving down the highway on my way to work and all of a sudden I lost power. The car was still on but it wouldn't go very fast and started smoking. Then a knocking noise started. I had to get it towed home. Car is not running. KIA refuses to take responsibility even though there is a known issue with this vehicle.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2012 Kia Optima?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history