My engine blew up and started smoking while driving
2016 Kia Optima engine complaints
Page 3 of 16: complaints 41 to 70 of 445, newest first, as owners wrote them.
Car stop accelerating when I went to get my oil change the shop reported my engine eating up my oil found out kia have a recall on engine
Engine sludge and failure. Engine part failure p0010 began happening within 1 year of Kia engine replacement. It is available for inspection. This creates a problem with acceleration in the vehicle, putting my family's and my safety at risk. This problem has been confirmed by the dealer. The check engine light is one. This part failure and engine sludge (despite consistent maintenance) has caused engine failure again, just 3 years after replacement.
The car is burning oil rapidly causing potential issues with the transmission and engine. The oil burns and does not leak after a few hundred miles and has to be refilled continuously causing alot of money and potential issues with other components of the car. I notice jerking when accelerating and smoke if dont fill every 1 to 2 weeks.
Engine Is knocking that happened when I took my car 3 times to emission test and my car didn't pass after that I took it to my mechanic for the diagnostic and he told me you have to take it to kia dealer but I was shocked the way how they treated me and they completely refuse to replace my engine they came up with too many excuses and I have recall repair active I have right to fix my car but they didn't with bad attitude
Engine began jumping during driving and loss power. No dashboard illumination warning lights and the temperature gage showed normal operating temperature. Car was not accelerating properly. Had to maneuver carefully to prevent being ran over. Engine light illuminated showing misfire. Replaced ignition coil pack and spark plugs. Driving again, car stalled. No dashboard warning lights. No high temperature on gauge. Narrowly missed being hit by a semi as there was absolutely no warning and we were on an Interstate bypass ramp with nowhere to pull over!! Towed car to dealership for diagnosis. Results: engine blown, turbos gone, and the catalytic converter is holding oil. Dealer is stating this is not covered under the extended warranty from Kia as its not connector rod bearing issues and that the piston rings failed. However, they stated the turbos got "too hot" and they failed. The gauges have never shown that the car was running hot. I have a sworn statement from my mechanic stating this is absurd and a valiant attempt to not pay for what would be the second warranty replacement of my engine. The piston rings failed as a result of the connector rod bearing failure. The "too hot" temperature that damaged the turbos was likely caused by the same bearing issue. The heat from the bearings unseated the piston rings and allowed the engine to dump its oil causing the engine to fail. I highly recommend that you open an investigation into these issues. The car not accelerating and losing power at interstate speeds is a very serious and dangerous issue.
The contact owns a 2016 Kia Optima. The contact stated that while driving approximately 75 MPH and attempting to accelerate to overtake a semi-truck, the vehicle suddenly started losing automotive power and then stalled. The vehicle was towed to the local dealer, who diagnosed that the engine had seized and needed to be replaced. The vehicle was not yet repaired. The contact indicated that prior to the failure, the check engine warning light illuminated and remained illuminated, and the engine experienced excessive oil consumption. The manufacturer was not yet notified of the failure. The failure mileage was 45,000. The VIN was not available.
I am filing this complaint to urgently bring attention to a serious safety and mechanical defect with my Kia vehicle's engine and fuel system. My engine is excessively consuming oil, to the point where it poses a significant risk of engine failure, which could result in a loss of power while driving and create a hazardous situation on the road. Details: I consistently have to add 5 quarts of oil approximately every month. During regular oil changes, there is barely any oil recovered from the engine, suggesting the oil is being consumed or burned internally. I took the vehicle to AutoZone for diagnostics, and they confirmed the engine is burning oil. They also mentioned it could be related to a rod or piston ring issue. There are no visible leaks under the vehicle, and the oil is not being expelled externally—it's being consumed by the engine. This issue is not normal wear and tear. It's a systemic engine defect that is causing rapid oil loss and is likely to lead to engine seizure or failure if not addressed. This level of oil consumption is not just expensive—it is dangerous. A sudden loss of engine power could cause an accident, especially at highway speeds. I am deeply concerned for my safety and the safety of others on the road. Urgency: I am requesting the federal safety agency to investigate this issue and consider initiating a recall for affected Kia vehicles. I am not the only one facing this problem—online forums and consumer reports are filled with similar complaints from other Kia owners. This is a critical engine/fuel system safety defect that must be addressed immediately before someone is injured or worse due to engine failure while driving. Thank you for your time and attention to this matter. I am available to provide service records, photos, and further documentation upon request. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The engine is starting to fail causing issues such as being able to accelerate. When driving on the freeway it caused a safety issue it began slowing down on the interstate. The vehicle has been inspected by mechanics. No warnings prior to problem. They appeared day before due for an oil change. The car also burns oil really fast sometimes causing car to smoke. I have a GDI turbo engine and have been told that the engine i have has been recalled a few times on different models cars.
The contact owns a 2016 Kia Optima. The contact stated that while driving at 45 MPH, there was a misfire coming from the engine, and the vehicle was shaking. There was no warning light illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The vehicle was diagnosed with engine failure due to piston rings failure, causing coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The contact stated that the ignition coil, cylinder #1, and spark plugs were replaced. The dealer was contacted, but had not diagnosed or repaired the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
My 2016 Kia Optima EX (VIN [XXX] , 2.4L I4 DI) suffered sudden engine bearing failure and complete engine seizure after approximately three months of use. After inspection, the Kia Scottsdale dealership confirmed that my vehicle’s VIN was eligible under the engine replacement warranty and submitted a request for assistance.However, Kia America denied the request. This defect is identical in nature to the known dangerous defect covered under Kia Safety Recall SC147 (the federal safety agency 17V‑224) and related recalls for earlier Optima model years, involving connecting rod bearing wear leading to engine seizure. In my case, the defect caused a total loss of motive power, posing a serious crash risk. Kia Motors America has refused to repair or replace the engine, claiming my vehicle is ineligible due to being purchased from an auto auction (Sierra Auction) and having multiple prior owners. This refusal ignores that the defect is a safety-related manufacturing flaw identical to those already acknowledged by Kia and subject to federal recalls. I request the federal safety agency investigate Kia’s refusal to extend the same safety remedies to my VIN and consider whether the scope of SC147 and related recalls should be expanded to include vehicles with the same defect pattern. Supporting documentation available upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I have pictures
No FireNo Injuries0 Deaths0 I’m experiencing severe oil consumption and spark plug fouling, which are known problems with the GDI engine. This is affecting driveability and may indicate piston ring or valve seal failure. My engine code starts with G4KJ which falls under the current recall, but my vin does not show up. Why isn't my car eligible? I have called Kia and their response was to call my local dealership. Started noticing the issue on [XXX]. Called dealership at that time and they said my car doesn't qualify. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Complaint Message – 2016 Kia Optima Engine Failure Without Oil Light Warning I am the owner of a 2016 Kia Optima (VIN: [XXX] ). My vehicle suffered complete engine failure due to oil starvation — without any prior oil warning light or indication. The engine died while driving, and it was only afterward that I discovered the engine oil was extremely low. The oil pressure light never illuminated at any point to warn me. I am aware that Kia previously recalled earlier model years (2011–2014) for similar engine issues under Recall SC147 and others, related to the Theta II engine and oil pressure-related failures. Many owners reported the exact same symptom — catastrophic engine failure without oil light warnings — that I am now experiencing in my 2016 Optima. Although my model year is not included in the existing recall, the failure pattern appears identical. I believe this presents a significant safety issue that should be investigated. A critical warning system (oil pressure light) failed to function properly, which directly led to engine damage. I am requesting that this issue be reviewed and investigated by the federal safety agency and Kia for potential expansion of the recall or warranty coverage to include the 2016 Optima. I have already contacted Kia and am pursuing further review through the dealership and customer support. Please note that other 2016 Optima owners have reported similar complaints online and in forums, and this issue may affect a broader number of vehicles than currently acknowledged. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I’m experiencing severe oil consumption and spark plug fouling, which are known problems with the GDI engine. This is affecting driveability and may indicate piston ring or valve seal failure.
Engine issue, it’s knocking loud and misfires. Engine light flashing and Car went into limp mode , will not go over 60 mph . I have changed the spark plugs, knock sensor, and had an oil change nothing has fixed my issue.
Several safety-critical systems failed on this vehicle. The engine (Theta II 2.4L GDI) failed due to rod bearing wear, causing sudden power loss on the highway. The vehicle entered limp mode, once at 50 mph in 2018 and again at 70 mph in 2025, and had to be pulled over quickly to avoid collision. Additional issues: all four windows failed at different times, leaving them stuck open and creating safety risks in weather or emergencies. The trunk latch failed, causing unsecured cargo risk. ABS, TPMS, and traction control warning lights illuminated repeatedly, indicating possible loss of critical safety systems. A loose wiring harness caused the turn signal bulb to burn out repeatedly, reducing visibility and signaling. The dealership performed the KSDS software update after I reported engine trouble but did not resolve the issue. The engine soon failed completely while driving. Other issues, such as the fuse box blowing fuses from a standard USB charger have also been documented by a Kia dealership but not always fully repaired. The most recent engine failure and electrical defects are being inspected by a Kia dealership, and Kia Consumer Affairs is reviewing the warranty claim. Prior to the engine failure, I smelled burning oil and topped it off monthly due to excessive consumption. The oil level light and check engine light only appeared during limp mode right before the failure. These repeated safety-critical defects, particularly sudden engine failure at highway speed, created a significant safety hazard for myself and others on the road. At the time of this report, I am in the process of seeking warranty coverage for the catastrophic engine failure through Kia. The failure behavior (limp mode, flashing check engine light, and rod knock) is consistent with the safety defect described in the Theta II engine settlement. I am concerned that despite this being a known issue, there may be delays or denials in honoring the safety-related warranty repair.
The vehicle went into limp power mode while driving
A month in after purchasing the check engine light came on. My car did not want to accelerate, started shaking and having jerking movement while driving on the freeway with my newborn and 3 other children in the car with me. Got stranded 3 hours away from home. Car has been in the shop going on 30 days. Spark plugs changed, coolant thermostat changed and now the engine was reported that it has failed. Still in the shop currently.
Engine failed at 52.350 miles due to excessive oil consumption confirmed by a Kia dealership. Car was driving fine on 5/1/25, on 5/2/25, car started to stall with loud clicking noise, and wouldn't move fast, which then activated the check engine light.
I went to the Garden Grove Kia to get my new 2016 kia optima repaired for their knock sensor settlement repair. By their own terms of the agreement all original and subsequent ow ers can get vehicles repaired. They took my vehicle information, I gave them all details of my ownership of the vehicle and they said they would fix it. The next day I rented a trailer to take the vehicle to get repaired (vehicle still runs but don't think it's safe to drive like that) and upon arriving, a worker comes out and tells me that they will not repir the vehicle because I just purchased the vehicle. Craig, the manager, also refused to see ownership documents but gave me 2 things; legal advice saying that I should sue where I bought the vehicle from and a paper that said they will not fix cars owned by dealers and auctions. I am neither am neither nor. Craig, also stated that Kia wont cover the repairs.
The check engine light came on in the car. Upon having it checked at a local automotive shop, we discovered that the thermostat assembly is malfunctioning. This can cause the engine to overheat and shut off at any time which of course would be a severe danger. Additionally, a bad thermostat assembly in Kia vehicles can lead to engine overheating or overcooling, potentially causing engine damage and even a fire risk. Upon searching, this appears to be a common issue with the 2016 Kia Optima.
Valve 3 does not have compression sent to private mechanic. Sent to KIA was told this is not covered under warranty for new engines went to say that intrest rates are down for new used cars. After some research this could be caused by engine recall.
Car has been consuming way more oil than usual which caused engine failed and I’ve filed several complaints with Kia America few years before engine failure with concerns of how much money I was spending in oil
The car caught on fire while I was driving. No warning lights came on and the car didn't show it was running hot. I tried to engage the brakes, and they malfunctioned. I coasted the car to the side of the highway, where the fire and smoke plumed from under the car. I immediately exited the car and ran. As I was running from the car the grass was on fire. The car was totally destroyed by fire. The car has not been inspected by my insurance or Kia. Kia has a class action settlement for car fires the year, make, and model of mine.
The contact owned a 2016 Kia Optima. The contact stated while coming to a stop, the vehicle leaned forward as if the engine had moved abnormally too far forward out of position. The contact stated that her boyfriend attempted to roll down the passenger’s side window; however, the window failed to open as intended. No warning light was illuminated. In addition, the contact attempted to take the vehicle to the local independent dealer where it was purchased; however, the vehicle experienced a loss of automotive power. The vehicle was towed to the local independent mechanic, where it was diagnosed that the engine was blown and there was a hole in the engine. The contact was informed that the engine needed to be replaced. In addition, the contact diagnosed the failure and related the failure to the motor mount, alternator bracket, and in need of an intake manifold replacement. The local dealer was not contacted. The vehicle was not diagnosed or repaired by the local dealer. The vehicle was given back to the local independent dealer and the vehicle was repaired and put up for sale. The manufacturer was not made aware of the failure. The failure mileage was approximately 68,086. The VIN was not available.
I was driving on 295 and my engine light came on. My car started shaking when I was accelerating and when I don’t accelerate it stops. When I come to a complete stop the car jerks back and forth acting like it wants to stall… I’m waiting on a call back from my mechanic on their diagnostic results
1. Burning Oil Issue: I began noticing excessive oil consumption in my vehicle at approximately [130,000], with the need for frequent oil top-offs. I made multiple visits to my local dealership and reported the issue, but no lasting solution was offered. This burning issue is a known issue due to position ring failure. 2.Catalytic Converter Failure: Due to the excessive oil burning, the oil eventually began to damage the catalytic converter. This caused significant issues with the performance of my vehicle, including [specific symptoms such as loss of power, poor acceleration, engine misfire, etc.]. 3.Engine Failure: As the oil-burning issue continued, the damage to the catalytic converter worsened, leading to a total engine failure. I am left with a car that is no longer operational, and I believe that these issues are the result of a persistent defect in the engine that should have been addressed under warranty or a recall.
Vehicle has been burning oil excessively for the last 3 years until engine finally went out
The contact owned a 2016 Kia Optima. The contact stated while driving at an undisclosed speed, the contact noticed smoke coming from under the hood. The contact stated that the passenger, who was seated in the rear passenger's seat, advised the contact to stop the vehicle. The contact stopped and parked the vehicle. The contact and the passenger exited the vehicle. The contact stated the engine was on fire. The Fire department arrived and extinguished the fire. A Fire report was filed. No police report was filed. No injuries were sustained. The vehicle was towed to a local tow yard. The vehicle was condemned as a total loss. In addition, the contact stated that two days before the failure, the vehicle was serviced by an independent mechanic. The independent mechanic replaced the engine sensor and the valve cover gasket. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 66,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Kia Optima?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history