My 2018 Kia Optima has the Theta II 2.4L engine. In February 2026, the dealer performed an engine/powertrain computer reprogramming. In August 2026, the engine failed and the vehicle was taken to an authorized Kia dealer, where the engine was replaced under the Theta II engine warranty. The vehicle was at the dealer from August 8 until the repair was completed on September 29, 2026. When I picked up the vehicle on October 9, it felt shaky and vibrated on the drive home. On October 11, the vehicle began giving off a distinct, unfamiliar smell that is not like burning fuel or oil. On October 21, I found the vehicle leaking an opaque, milky tan fluid onto my garage floor. The type and source of the fluid are UNKNOWN. I have photos of the leak. My family and I have stopped driving the vehicle because we believe it is unsafe. We were driving it with our children before these symptoms appeared. Given the history of Theta II engine failures, we are concerned about the risk of engine failure, stalling, or fire while driving. The new symptoms have not yet been diagnosed or confirmed by a dealer. I am arranging for the vehicle to be towed to a Kia dealer for warranty diagnosis. The vehicle and leak are available for inspection. I have reported these issues to the manufacturer under an open customer case.
2018 Kia Optima engine problems
144 complaints (62% of all complaints for this car). Typical mileage when it fails: 72,800. 1 crash reported.
- owner complaints
- 144
- of this car's complaints
- 62%
- typical mileage
- 72,800
- crashes
- 1
- recalls
- 0
Which part fails
- Engine: oil/lubrication2
- Engine: engine control module (ecu/ECM)1
At what mileage
Complaints by mileage at the time of the problem.
Kia Optima engine problems in other years
Specific symptoms reported on the 2018 Kia Optima engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Oil consumption 54Check engine light 39Engine failure 30Stalling 29Knocking 23Misfire 11Loss of power 10Won't start 6
Related recalls
No recalls on record for this model year.
Related investigations
Loss of Motive Power
the federal safety agency received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to the federal safety agency which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. Â There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in the federal safety agency's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, the federal safety agency does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing the federal safety agencyâs reasons for denial of the petition will be published. The reference numbers for the complaints to the federal safety agency cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to
DP22003
What 2018 Kia Optima owners say
Most recent owner complaints, unedited.
The contact owns a 2018 Kia Optima. The contact stated that upon starting the vehicle, the vehicle jerked abnormally. The failure persisted while driving, and the vehicle lost motive power. The contact was able to restart the vehicle; however, the failure persisted while driving. The vehicle was towed to a dealer to be repaired under an unknown recall for an engine software update and key fob replacement; however, the dealer failed to honor the recall repair and recommended purchasing a new vehicle. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 126,000. The VIN and License plate number were unavailable.
The contact owns a 2018 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate and failed to exceed 52 MPH. The vehicle shut off. The contact stated that the engine was running rough while stationary and the vehicle shut off without warning. The vehicle was taken to an Auto Parts Store, where it was diagnosed, and it was determined that the vehicle was in LIMP Mode with knock sensor codes displayed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 136,000.
See attached document for complaint.
I’ve had my 2018 kia optima for round about two years.I only got this car because they refused to replace my previous engine on my 2015 Kia optima,even though I had a warranty but that’s another story(Kia on the Blvd).This car have given me problems from the start.Going through oil in less than a month,which they can never find a leak,not being able to go over a certain speed before I start to hear noises.Ive complained about noises,they act like they can’t hear,and said nothing is wrong with the engine when previously checked.My check engine light has came on twice and both times the car was malfunctioning on the highway resulting in me have to get a tow.First it was plugs replacement now I need a whole new engine.I really don’t know what to do at this point.I believe they sold me a faulty car
The car burns oil within a week of getting an oil change. It was only driven a 200 miles before all of the oil was burned out. This has been a consistent issue with this car that the oil burns at an extreme rate. This is a safety risk as it could lead to engine overheating, the engine could stall out due to the fast burning of the oil, or a potential fire hazard while driving. The oil light will come on for a second and at that point, the oil is already EXTREMELY too low. I brought the car to the mechanic and they have told me multiple times that there is no leak or anything. The mechanic says that the car simply is burning oil too fast.
The contact owns a 2018 Kia Optima. The contact stated that while driving at an undisclosed speed, there was an abnormal odor and a knocking sound coming from the engine. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the issue. The vehicle was not repaired. The issue persisted. The contact stated that the vehicle was later returned to the dealer to be repaired under a service campaign involving the engine control unit (ECU). Shortly after the vehicle was repaired, the ECU failure message was displayed. The vehicle subsequently became inoperable. The vehicle was not repaired. The manufacturer was notified of the issue. The approximate failure mileage was 1,500.
The contact owns a 2018 Kia Optima. The contact stated that while attempting to accelerate from a standing start the vehicle had experience sever jerking and hesitation. Also, the vehicle has experience oil consumption problems and the contact constantly added engine oil. The cause of the failures were not determine. Also, the hood latch had malfunctioned and the hood could not opened to add oil to the engine. The cause of the failures were not determined. The local dealer and manufacturer were notified of the failures but no assistance was offered. The failure mileage was 121,000.
2018 Kia Optima LX, 2.4L GDI Theta II engine. Approximately 128,000 miles. Reporting severe internal oil consumption that has progressed to engine misfire and shaking, consistent with late-stage Theta II connecting rod bearing failure. The vehicle is now unsafe to drive and has been parked. Timeline: Purchased as a Certified Pre-Owned vehicle in December 2021. Excessive oil consumption began shortly after purchase. For approximately 4.5 years I have added about 1 quart of oil every 2 weeks to keep the engine from running dry. No external leaks have ever been found by any mechanic. Multiple independent mechanics attempted diagnosis and repair over this period. None resolved the issue. The vehicle has now developed a pronounced shake and apparent engine misfire, the textbook progression to rod bearing failure documented in the federal safety agency investigation PE19-004 and prior recalls/campaigns 17V‑224, SC147, and SC172. Safety concerns: Sudden engine seizure or stall at highway speed creates a serious crash risk for me and surrounding traffic. Theta II 2.4L GDI rod bearing failure has been associated with under-hood fires. The defect develops gradually with no warning to the driver beyond elevated oil consumption, which is frequently dismissed as normal until catastrophic failure occurs. I am filing this complaint to document the failure and to add to the federal safety agency's data on the Theta II GDI 2.4L engine in 2018–2019 Optimas. This model year was excluded from the original 2017 recall but is included in the Hyundai and Kia Engine Litigation class settlement and the lifetime engine warranty extension. My vehicle's symptoms match the defect pattern exactly. I will pursue warranty engine replacement, but I want this safety failure on the federal record regardless of how Kia responds.
Consuming fuel to the amount of roughly 1/2 quart per 150 miles. Vehicle has been inspected by mechanic and the oil pan, oil filter, and PCV valve has been replaced and engine oil UV dye added and cycled with no leaks found. The risk is that if not rigorously checked often, the engine will malfunction because the car runs out of oil. I have had my mechanic checking this car since I purchased it in January 2026. We have had to replace the oil pan and do two full oil changes with three separate quarts of oil being added in between all of that to keep it topped up. My mechanic agrees that the engine is consuming oil at an extremely high rate. My mechanic and a mechanic at the dealership where I purchased it are the only one who has inspected the car for this issue so far. The mechanic at the dealership is who recommended we replace the oil pan to see if that fixed the leak, which my personal mechanic did. Yes the critical engine failure lamp illuminates on the dashboard when the oil ran out the first time while I was driving it. This was how I discovered that there was an oil leak. This specific incident occurred three weeks after I purchased the car which I bought in mid-January of 2026.
Questions about the 2018 Kia Optima engine
Does the 2018 Kia Optima have engine problems?
Owners have filed 144 complaints about the engine of the 2018 Kia Optima, 62% of all its complaints, more than any other problem.
At what mileage do 2018 Kia Optima engine problems start?
The typical (median) mileage in owner complaints is 72,800 miles.
Is there a recall for the 2018 Kia Optima engine?
There is no recall for this problem on this model year.
Other 2018 Kia Optima problems
Electrical 33Transmission 19Brakes 17Lights 14Fuel system 13Steering 12Acceleration 10Airbags 9Body 7Driver assistance 7Seat belts 5Locks 1Suspension 1Tires 1Visibility 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Kia Optima?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history