Fuel pan rusted out. Valvoline would not service the car until the oil pan was replaced.
2008 Kia Rondo fuel system complaints
Page 2 of 2: complaints 11 to 22 of 22, newest first, as owners wrote them.
It takes 2 or 3 attempts to start my car after getting gas. Recently, after getting gas, the car stalled while I was driving on a busy main road going approx 40mph. Today, the car stalled 2x while driving. Everything turned off, had to use the emergency brake to stop the car.
Vehicle was taken to premiere kia of kenner, and also contacted kca/irvine 7:40am call; issue car sputters when gas pedal applied; car does not start after fueling, requires multiple starts; car stalled twice on hwy nov. 20, 2014 issues began. Kia dealer representative refused service of the federal safety agency campaign recall # 08v459000 recall date sept. 17, 2008, subsequently contacted kia consumer affairs in irvine, ca. Call center the phone call outcome csr stated would contact the local district manager for approval of recall would expedite process, csr stated would contact local dm within two hours and get back; received denial letter in mail. Recalls shows 6,680 ?potential units affected for this recall 08v459000 fuel pump sub assembly, whereas campaign recall # 12v014000 shows 145,755 units affected for ?airbag clock spring assembly? And recall # 13v114000 shows 623,658 units affected for ?stop lamp switch may function intermittently.? On the surface seems kia is only including full recalls for vehicles only if it poses the least financial harm to the corporate company profit as shown in the number of recalls of ?easy to fix? Issues but those such as the fuel pump assembly have the least amount of issued recalls representing a negligible amount of total vehicles. Is kia sacrificing safety for profit with these corporate decisions? Kia has denied a recall of the same issues that my vehicle is experiencing as stated in the recall bulletin: ?the fuel pump may not supply enough fuel to the engine, causing hard starting, engine hesitation, or other potential impairment. Unusually severe hesitation or other impairment could expose the driver to the risk of a crash. Dealers will replace the fuel pump sub-assembly with an updated part.? Kia has neglected to resolve faulty issue. Please advise kia to rectify the situation by repairing the faulty fuel pump assembly.
After smelling a strong smell of gasoline in our garage, we took our kia rondo to firestone to have it checked out. They found that a seam on the gas tank had separated and there was rust in the area that they believed was caused by road salt applied to our roads during the winters we have had the car (st. Louis). We took the vehicle to kia and they have refused to cover the replacement of the gas tank, which is only 6 years old. This gas tank is metal and is defective and should be recalled on all 2008 kia rondos.
In 2010, check engine light came on. The vehicle would not restart after refueling. I would have to pump the gas before the car would restart and it would make sounds and the RPM will rev. I had a diagnosis performed by several mechanics but unable to detect what was causing the problem. Had guesstimates as to o2 sensors, fuel pump to canisters replacement. This has gone on since 2010. Currently, the car does not turn over on the first attempt after fueling. I took car in to the dealership and was told that I needed to replace the fuel pump assembly. As I researched the recommended repair, I learned that kia recalled other 2008 rondo's, so I called them and was told that my vehicle is a v6 and not part of the recall campaign. I am having the same problem as the vehicles in the recall campaign and think that this matter should be further investigated.
In september 2011, check engine light came on. The vehicle would not restart after refueling. I would have to pump the gas before the car would restart and it would make a sound like it was trying to suck up gas through a straw that had a hole in it. I had a fuel injection flush and dye added but unable to detect what was causing the problem. This went on for several months. Currently, the car does not turn over on the first attempt. It takes approximately 3 attempts for the car to start. This is in addition to the car not starting after refueling. I took car in for repair and was told that I needed to replace the fuel pump assembly. As I researched the recommended repair, I learned that kia recalled other 2008 rondo's, so I called them and was told that my vehicle is a 2.7 liter and not part of the recall campaign. I am having the same problem as the vehicles in the recall campaign and think that this matter should be further investigated.
2008 kia rondo. Consumer writes in regards to defective part *tgw the consumer stated she had difficulty starting the vehicle after filling the gas tank and the check engine light was constantly on due to an issue with a defective valve on the charcoal canister. The consumer discovered a recall had been issued for the exact part, she was having a problem with. The consumer made an appointment with the dealer after describing the problem. However, when she arrived and her vehicle identification number was entered, she was then informed her vehicle was not included in the recall. The consumer referenced recall # 08v459000
I have a 2008 kia rondo, for the past few months I have been having issues when I get gas. It is the 2.7l engine and when I stop to get gas it won't start. I have to push the gas to get it to crank and then have to hold it down for approximately 2 minutes before it will stay cranked. If I do not keep the gas pressed down for that length of time it cuts off or hesitates then cuts off. I have inquired with the kia dealership about the recall for the 2.4l engines and was informed that my car did not qualify for that recall. However, my car is having the same issues as the ones that were recalled.
Tl* the contact owns a 2008 kia rondo. While driving approximately 35 MPH, the contact noticed a sputtering noise and a hesitation while accelerating. The check engine warning light illuminated on the instrument panel. The vehicle was taken to the dealer for diagnostic testing where the technician stated that a coil would have to be replaced but the contact was not aware of the exact repair needed. There was a recall under the federal safety agency campaign id number: 08v459000 (fuel system, gasoline:storage) that could have been related to the failure. The manufacturer was made aware of the failure and advised the contact that the VIN was not included in the recall. The vehicle was not repaired. The approximate failure mileage was 65,000.
I have a 2008 kia rondo, for the past few months I have been having issues when I get gas. It is the 2.7l engine and when I stop to get gas it won't start. I have to push the gas to get it to crank and then have to hold it down for approximately 2 minutes before it will stay cranked. If I do not keep the gas pressed down for that length of time it cuts off or hesitates then cuts off. I have inquired with the kia dealership about the recall for the 2.4l engines and was informed that my car did not qualify for that recall. However, my car is having the same issues as the ones that were recalled.
I own a 2008 kia rondo with a 2.7 liter 6 cyl engine. I have been having identical problems that the 2.4 liter 4 cyl has had that caused a fuel pump recall. It stalls because it can not get sufficient gas. It does not want to start after getting gas, and it is having a gas starvation issue. I have taken the car to a mechanic, who indicated it should have been recalled with the 4 cyl. I contacted kia and they are refusing to repair the issue as a recall. At one point the car stalled while I was driving and I almost wrecked.
My 2008 kia rondo 2.7 always hesitates after I fill the gas tank, and recently it cuts off while I am driving, when this occurs I lose my ability to steer the car.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Kia Rondo?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history