Kia Rondo fuel pump problems

Filed Oct 18, 2019 · Engine, Fuel system · 229,000 miles · CT

My check engine light is on. When I refuel my vehicle it has difficulty restarting. Over the course of the last couple months, it has started to stall. Looking at forums I found quite a few people with the same "issue" but no solutions. I have had my vehicle on a diagnostic machine and it comes back with an evap code. The codes have been cleared but come right back on. I see the fuel pump has been recalled, I have had my car since the fall of 2009 and to my knowledge I haven't had this repaired, but for some reason this does not show up when I do the recall search. Has it already been repaired prior to my purchasing the vehicle?

Filed Oct 9, 2019 · Engine, Fuel system · 150,000 miles · ME

Tl* the contact owns a 2008 kia rondo. While driving at an unknown speed, the vehicle suddenly stopped moving and shut off. The contact was unable to restart the vehicle. A passerby inspected the vehicle and stated that the fuel pump or alternator may have failed. The passerby banged on the fuel tank a couple of times and the vehicle restarted. The vehicle was driven to the contact's home and was then towed to an independent mechanic who diagnosed that the fuel pump failed. The contact researched the failure online and found many unknown recalls on other vehicles. The contact attempted to call the manufacturer, but all lines LED back to roadside assistance; therefore, the contact was unable to speak with a live representative. The contact called bill dodge kia (3 saunders way, westbrook, me 04092, (207) 854-3200) and they initially hung up on her. They later stated that their website was down and promised a call back. The contact had not yet heard back from the manufacturer. The vehicle was not repaired. The failure mileage was 150,000.

Filed Sep 22, 2019 · Fuel system · 75,182 miles · GA

The fuel pump is not operating properly resulting in not enough fuel getting to the engine. Poor engine starting and engine hesitation. The check engine light is on because of this.

Filed Jul 11, 2017 · Fuel system · 144,000 miles · RI

Tl* the contact owns a 2009 kia rondo. The contact stated that the fuel pump failed to pump fuel to the engine. The failure occurred without warning. The vehicle was taken to the dealer (grieco honda located at 1880 hartford ave, johnston, ri 02919; (877) 428-5614) where it was diagnosed that the entire fuel pump unit needed to be replaced. The vehicle was not repaired. The manufacturer was contacted at 800‑333‑4542 and stated that the VIN was not included in a recall. The failure mileage was approximately 144,000.

Filed Aug 14, 2016 · Fuel system · 123,000 miles · SC

I have 2007 kia rondo. I purchased this used in 2010. In the last 2 years I have had to replace my fuel pump 3 times. It just stops working. I have dealer parts on my car and keep track of all services done to my car. It will just stop pumping fuel even though it sounds ad if pump is coming on. This has to be a defect because I have never had to replace the fuel pump on 3 times on any car I have ever owned. This really needs to be investigated as I've just replaced it again on july 18,2016.

Filed Sep 6, 2015 · Engine, Fuel system · 98,074 miles · AZ

The fuel pump assembly stop working, it would only work long enough to get it moving then stall. This is a hazard because it can stall in the middle of the road.

Filed Aug 24, 2015 · Fuel system · 60,000 miles · NC

Purchased a 2007 kia rondo from concord honda, concord, n.c. Sept.,2014. Vehicle had only approx. 56,000 miles on it. While driving car started jerking forward and back. While coming to a stoplight or stop sign and decelerating(letting your foot off the the gas pedal) the engine would stall, then you could start the engine right back up. Now at 75,000 miles car will not keep running everytime you stop.engine light has come on,extended start and no acceleration...when you push accelerator it does not accellerate. Had engine light code checked and dealer tech diagnose is that here again it is the the fuel pump!!! Cost to replace is $650.00 plus tax...factory deffective....somebody wake up !!!!!

Filed Dec 28, 2014 · Airbags, Brakes · 130,000 miles · LA

Vehicle was taken to premiere kia of kenner, and also contacted kca/irvine 7:40am call; issue car sputters when gas pedal applied; car does not start after fueling, requires multiple starts; car stalled twice on hwy nov. 20, 2014 issues began. Kia dealer representative refused service of the federal safety agency campaign recall # 08v459000 recall date sept. 17, 2008, subsequently contacted kia consumer affairs in irvine, ca. Call center the phone call outcome csr stated would contact the local district manager for approval of recall would expedite process, csr stated would contact local dm within two hours and get back; received denial letter in mail. Recalls shows 6,680 ?potential units affected for this recall 08v459000 fuel pump sub assembly, whereas campaign recall # 12v014000 shows 145,755 units affected for ?airbag clock spring assembly? And recall # 13v114000 shows 623,658 units affected for ?stop lamp switch may function intermittently.? On the surface seems kia is only including full recalls for vehicles only if it poses the least financial harm to the corporate company profit as shown in the number of recalls of ?easy to fix? Issues but those such as the fuel pump assembly have the least amount of issued recalls representing a negligible amount of total vehicles. Is kia sacrificing safety for profit with these corporate decisions? Kia has denied a recall of the same issues that my vehicle is experiencing as stated in the recall bulletin: ?the fuel pump may not supply enough fuel to the engine, causing hard starting, engine hesitation, or other potential impairment. Unusually severe hesitation or other impairment could expose the driver to the risk of a crash. Dealers will replace the fuel pump sub-assembly with an updated part.? Kia has neglected to resolve faulty issue. Please advise kia to rectify the situation by repairing the faulty fuel pump assembly.

Filed Jan 16, 2013 · Fuel system · 60,000 miles · MD

In 2010, check engine light came on. The vehicle would not restart after refueling. I would have to pump the gas before the car would restart and it would make sounds and the RPM will rev. I had a diagnosis performed by several mechanics but unable to detect what was causing the problem. Had guesstimates as to o2 sensors, fuel pump to canisters replacement. This has gone on since 2010. Currently, the car does not turn over on the first attempt after fueling. I took car in to the dealership and was told that I needed to replace the fuel pump assembly. As I researched the recommended repair, I learned that kia recalled other 2008 rondo's, so I called them and was told that my vehicle is a v6 and not part of the recall campaign. I am having the same problem as the vehicles in the recall campaign and think that this matter should be further investigated.

Filed Nov 9, 2012 · Fuel system · 71,000 miles · AZ

In september 2011, check engine light came on. The vehicle would not restart after refueling. I would have to pump the gas before the car would restart and it would make a sound like it was trying to suck up gas through a straw that had a hole in it. I had a fuel injection flush and dye added but unable to detect what was causing the problem. This went on for several months. Currently, the car does not turn over on the first attempt. It takes approximately 3 attempts for the car to start. This is in addition to the car not starting after refueling. I took car in for repair and was told that I needed to replace the fuel pump assembly. As I researched the recommended repair, I learned that kia recalled other 2008 rondo's, so I called them and was told that my vehicle is a 2.7 liter and not part of the recall campaign. I am having the same problem as the vehicles in the recall campaign and think that this matter should be further investigated.