2002 Kia Sedona engine problems

Filed May 3, 2016 · Electrical, Engine · MO · fire

I was driving no less then than block from my house - when I notice smoke from the driver side fuse panel and next thing you know the whole panel became engulf in flames. I called the fire department and able to put fire out- but unfortunately, the car become total in the damage.

Filed Feb 22, 2015 · Engine · NE

I had my camshaft rear plug replaced after in came out and leaked oil everywhere in 2014. Now it's come out again doing the same thing. What can I do to keep it from happening again and again. Is it the plug or the camshaft that's blowing it out. I can't find any schematic to show me why or what to do.

Filed Feb 21, 2014 · Electrical, Engine · 130,500 miles · GA · fire

The car was parked in front of the house. A neighbor knocked on the door and told us that the kia was on fire. No one was in the car at that time. The engine compartment was totally burned up. The car gave me no other problems.

Filed Feb 13, 2013 · Engine · 105,000 miles · KY

Tl* the contact owns a 2002 kia sedona. The contact stated that while driving 35 MPH, she heard a knocking noise coming from the vehicle. The vehicle was inspected and it was determined that the threads for the crank shaft bolt were missing. The vehicle was taken to an independent mechanic for diagnosis and the contact was informed that the balancer and bolt would need to be replaced. The vehicle was not repaired. The failure and current mileage was 105,500.

Filed Jan 25, 2011 · Engine · 94,000 miles · IN

Tl* the contact owns a 2002 kia sedona ex. The contact was driving approximately 50 MPH when the engine stalled. The battery, brake and service engine warning lights were illuminated. The engine was restarted after several moments. The failure recurred at least eight different times. The vehicle was taken to the dealer three times for the similar failure. The technician was unable to duplicate the problem and the vehicle was not repaired. The failure mileage was approximately 94,000.

Filed Sep 29, 2010 · Engine · 60,735 miles · PA

Tl*the contact owns a 2002 kia sedona. The contact stated that the vehicle suddenly stalled. The fuel pump and battery were replaced but the failure continued. The dealer then replaced the air flow sensor. September 2010, the engine was shaking followed by the vehicle stalling again. The check engine light illuminated after the failure. The vehicle was towed to the dealer. The vehicle had not been diagnosed or repaired. The current mileage was 60,735. The failure mileage was 54,084.

Filed Nov 10, 2005 · Body, Brakes · 46,876 miles · PA

Consumer belts squeal, slidding door drags, pulley was replaced at 7744 miles. *ts ***no answer required*** the pulley and belt have been replaced 10 times. The alternator seized while the vehicle was being driven. The A/C fan made loud noises. The sliding door dragged. The emergency brake would not hold, the dealer adjusted it three times then finally replaced. An internal short in the fuse clock caused the vehicle not to start. The vehicle stalled intermittenlty but the dealer was unable to duplicate the stalling. The power windows would stick and make noise, the dealer lubed it and replaced the regulator. The rear hatch rusted around handle and had to be repaired/refinished twice. The exhaust manifold racked. Oil leaked from oil filter. The front and rear wipers failed. The sliding door handle broke. The dash lights illuminated due to broken bad switch contacts. The rotors warped. The A/C was blowing when it wasn't on and sometimes it blew out warm air. The rear seat arm rest will not stay down. The threshold on the left side is cracked.

Filed Oct 28, 2005 · Engine, Suspension · 32,000 miles · CA

One of the main concerns/failure is a front end bobbling noise when driving on uneven pavement. The dealer states they know of the problem but they don't know how to fix it. Originally they replaced the front struts and 2 engine mounts as these were cracked. The noise is still there and my dealer is at a loss on how to fix it. Kia-forums.com under kia sedona front struts is a forum devoted to people who are having this front end bobbling noise. There are about 5000 hits on this forum and each one of the car owners has been told kia knows of the problem but they don't know how to fix it. This problem is happening on all sedonas from 2001 to present.

Filed Jul 12, 2005 · Electrical, Engine · 180 miles · FL

2nd request ltr fm richard jorge (fl) re his defective 2002 kia sedona.*mr when the vehicle only had 180 miles it overheated and shorted out. Presently, the consumer is experiencing a recurring problem with the battery and alternator.

Filed Apr 21, 2005 · Engine · TX

While driving,the vehicle started shaking uncontrollably without warning. The driver was able to maintain control of the vehicle. Then stall. The driver tried to restart,but was unable to start. The vehicle towed to the dealer for inspection. The mechanic informed the driver that the problem can not be duplicate at this time. Please provide additional information.