2006 Kia Sedona steering problems

Filed Dec 1, 2020 · Steering · 112,000 miles · TN

Tl* the contact owns a 2006 kia sedona. The contact stated that while making a turn, a popping noise occurred coming from the rack and pinion steering. No warning light was illuminated. The vehicle was taken to an independent mechanic and was diagnosed that the rack & pinion steering needed to be replaced. The vehicle was repaired with a new rack & pinion however, the failure recurred. The technician informed the contact that there was a problem with the rack and pinion. The technician informed the contact that a kia dealer rack & pinion was tested and failed, and was unable to correct the failure. The contact mentioned that six months ago, when the vehicle was purchased, the rack and pinion was replaced. Neither the dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 112,000. The VIN was not available.

Filed Oct 6, 2020 · Steering · 35,000 miles · MA

Power steering pump has had to be replaced 4 times in past 4 years. Needs replacement about every year bit last 2 were 6 minths apart. Something is causing friction and ruining pumps. Makes fluid instantly pour out and car is uncontrollable. So dangerous

Filed Jan 12, 2018 · Brakes, Driver assistance · 200,000 miles · FL

In march2016 brakes replace with new pads/rotor due to screech sound. Today when brake pressed steering wheel vibrates. Abs/ESC off light came on the other day. Front wheels still vibrate on the highway. Transmission sometimes jerks and stalls the car. A/c not work, but heater always working.

Filed Sep 22, 2016 · Electrical, Locks · 125,000 miles · TN

Tl* the contact owns a 2006 kia sedona. Immediately after the contact exited the vehicle, the doors and the steering wheel locked automatically and the alarm system sounded without warning. Whenever the contact drove over 55 MPH, the steering locked. Each time the failure occurred, the vehicle was pulled over to the side of the road, turned off, and then restarted. The vehicle was taken to a local dealer who was unable to diagnose the failure. The dealer did not test drive the vehicle to see if the failure could be duplicated. The failure recurred several times. The manufacturer was made aware of the failure and stated that they had never heard of such a failure. The failure was not remedied. The contact received notification of the federal safety agency campaign number: 16v389000 (latches/locks/linkages). The failure mileage was 125,000. Parts distribution disconnect.

Filed Apr 25, 2016 · Steering, Suspension · 127,000 miles · OH

Tl* the contact owns a 2006 kia sedona. While driving 25 MPH, the lower control arm on the front passenger side failed. The contact heard an abnormal noise and the steering wheel could not be steered. The contact also noticed that the ESC warning light illuminated. The contact pulled the vehicle over and had it towed to a dealer. The vehicle was diagnosed that the lower control arm needed to be replaced. The repairs were not performed. The manufacturer was not made aware of the failure. The failure mileage was 127,000.

Filed Apr 22, 2016 · Steering, Suspension · 103,000 miles · MI · 1 injury

I was driving the vehicle at approximately 35 MPH. All of a sudden I heard a loud thud. The wheel jerked violently to the left and my vehicle began careening left toward the side of the road. I immediately began braking. I was able to stop the vehicle and exit safely. Upon inspection of the vehicle, I noticed that the front wheels were pointing in slightly different directions, and the front left wheel was moved significantly back in its well toward the rear of the vehicle. Upon inspection of the suspension components, it was immediately clear that the front left lower control arm broke while the vehicle was in motion. There has been a recall (campaign number 13v550000) on the lca for this vehicle, located in michigan, and the recall was performed by a dealership. This failure was after the recall had already been performed. Apparently this lca didn't meet the criteria for replacement, and was "rustproofed" instead. The rustproofing did not prevent this lca from failure. The vehicle has less than 104,000 miles. Had I been traveling faster, or had there been an oncoming car, the outcome could have been significantly worse or even fatal. I did receive a mild injury to my right wrist when the wheel jerked violently. The tendon is hyper-extended and requires that I wear a wrist brace.

Filed Nov 10, 2015 · Steering · 70,000 miles · CO

Steering becomes tight, at low speeds small female cant navigate car existing problem you all never handled property guess you want jobs at dealer or manufacturer - the federal safety agency action number : pe08033 and we are not in salt state

Filed Aug 17, 2015 · Steering, Suspension · 150,000 miles · NC

In march 2014 we received a recall notice kia recall #sc100. This was concerning the lower front control arms being subject to rust and failure for northern vehicles. The vehicle was taken to paramount kia, hickory nc. According to kia the control arms were inspected and found to be in satisfactory condition. Approximately two months later the front passenger side control arm broke in two. I had the vehicle towed the a local garage and the arm was changed out with a used like new control arm. On friday august 14th 2015 the drivers side control arm broke into. I called kia and was told that because it was inspected in march 2014 and nothing was done then that there was noting that could be done now. Needing the vehicle for transportation elected to have it towed to the garage that fixed it the last time to get it fixed again. Kia is aware of the problem with these control arms however has elected not to do anything with the ones on my vehicle. I do feel that I should be reimbursed for the cost of having the vehicle towed twice and the cost of parts and labor to have the arms replaced. I complaint has been filed with kia also.

Filed Aug 20, 2014 · Steering · 100,000 miles · PA · crash

The drivers side lower control arm severed causing the vehicle to be uncontrollable yielding substantial damage.

Filed Feb 7, 2014 · Electrical, Steering · 109,799 miles · NY

After parking vehicle, went to exit and could not remove ignition key. Key turned off vehicle but would only go as far accs, which means while motor was not running, power was still on. Made sure dash indicator was in park, yet could not remove key. Spoke to a locksmith and added lube to around ignition key without any results. Left inside semi-heated garage overnight in case of frozen components without results. While dash indicator seemed to show proper gear selections, while in park, key could not removed, steering wheel would not lock, and vehicle could be moved forward and backward by manual pushing, in the meantime it was using up the battery. Kia dealership determined "shifter assembly failure", and after $600+ and 6 days for the special ordered part, vehicle was returned, but the failed part was returned to the supplier for a core charge. So if vehicle was parked in a parking lot and ignition key cannot be removed the car could be stolen, if parked on an incline car could roll away because it's truly not in park, and or your battery is dead. There was prior warning of any failure and owned since new.