2015 Kia Sedona: check engine light

Filed Aug 5, 2026 · Engine · CA

The check engine light illuminated with diagnostic code P0018 (crankshaft/camshaft position correlation, Bank 2), first recorded on a scan XXX. The vehicle was taken to a franchised Kia dealership in [XXX] on XXX at 88,719 miles. The dealer performed an engine teardown and provided a written diagnosis on XXX: metal debris on the exhaust camshaft position sensor, damaged camshaft phasers, a sheared camshaft pin, and metal contamination throughout the engine. The dealer states the engine requires either a major timing-system repair or complete engine replacement. This failure mode can cause sudden loss of motive power while driving. There was no crash, no injury, and no fire. The engine remains disassembled at the dealership and is available for inspection upon request. The problem was confirmed by a franchised Kia dealer in writing. the federal safety agency previously examined loss of motive power in this 3.3L V6 engine family in PE23-019, which named 2015-2021 Kia Sedona vehicles with 3.3L engines as peer vehicles. Warning prior to failure: check engine light only. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 12, 2026 · Engine · KS · fire

Was driving down the road with zero issues known, no check engine light, and only 114K miles. There was a sudden noise that was quiet so I turned down the radio, and then within 2 seconds or so a loud bang occurred, followed by a lot of smoke. I looked in the side mirrors and noted flames coming from underneath the van. Pulled over and got my family out.

Filed Oct 16, 2025 · Engine · WA

Engine burned up all oil. No check engine lights. No active leaks confirmed by dealership. Engine is now damaged

Filed Feb 7, 2025 · Engine · NJ

A few months ago we became aware that our Sedona was burning through coolant and oil very quickly. We began to monitor closely and were adding coolant and oil frequently. We did not see any oil leaking on the engine or driveway. We brought the car into the Cherry Hill Kia service center to get checked. We were aware of a recall involving coolant and oil and thought this could be related. I told the mechanic we were checking the coolant and oil every week because it would run low and the check engine light would come on. We would add both oil and coolant and the check engine light would go out soon after. The Kia mechanic told us we needed new radiator hoses and an alternator. I pressed the mechanic because I did not understand how that would affect the oil consumption. We paid for the diagnostic and oil change and took our car to another mechanic and they replaced the entire radiator and alternator. This was in October, 24. In January of 25 we were driving on a 45 mph road with no shoulder when the lights on the dashboard lit up and we began to lose power. The vehicle stopped and we could not even get the hazard lights to function. My children were in the car. The police had to be called to stop traffic so we could safely push the car off the road until it could be towed. The vehicle is currently at Burlington Kia and we have been informed we need a whole new engine. We have always been diligent about maintaining our cars. I have no doubt that this is the result of poor engineering and design and puts families like ours in danger. Please help us and by holding Kia accountable.

Filed Jan 24, 2025 · Engine · AL

All of a sudden my vehicle has started consuming large amounts of oil. My wife was driving with my two small children when a check engine light went on and she pulled over and there was no oil left in the engine! i am unsure of the scale of the problem or if any significant damage has occurred. I worry that the car is at 149k that I will go over the 150k and be out of luck for a recall claim. I know that this was a complaint with other kia engines, but the 3.3 GDI Lambda seems to have the same issue. Please take care of it!

Filed Oct 24, 2024 · Electrical, Engine · CO

Complete engine failure, knocking like crazy, fuel smell in the oil, The shop said the fuel in the oil broke it down and allowed the motor to fail. We were driving down the highway when it happened with family and kids which was not safe at all. No warning message at all, no check engine light, the shop has inspected and said it’s failed. The kia dealership has said many of the Kia’s have been recalled for engine failure but not ours? But others with the same motor have been.

Filed Aug 16, 2024 · Engine · IL

While driving through an intersection with my family in the car, the engine suddenly failed without warning, leaving us stranded in a dangerous situation with incoming traffic. The engine began smoking, shaking violently, and emitting a strong odor, making the vehicle undrivable. We also received a notification to have the engine checked, and the check engine light was blinking. The vehicle is currently at a dealership in Belvidere, IL. KIA informed us that our VIN is not included in any existing recalls or lawsuits. This situation has caused significant hardship, as we now have no car to drive for work or daily activities.

Filed May 7, 2024 · Engine · TN

Engine light came on while in route for an oil change. Walmart automotive changed the oil and checked the light. Read p0014. Engine light went away after oil change. Drove fine for 4 days then went haywire on the interstate. Oil light started flashing then engine light. Lost all power. Had it towed home. It started with a loud knocking noise. Towed to Kia and there are metal fragments in my oil. Engine blown.

Filed Mar 4, 2024 · Engine · 124,943 miles · CA

After driving 3 miles on 2/1, the engine fan ran after the engine was turned off- which never happens. We called Kia for service but nothing was available for 2 weeks; all Kia dealers were similar. No check engine light was illuminated. My husband popped the hood, saw the coolant cap was open and the coolant fluid level in the normal range (slightly above the minimum line). Closing the cap, he test drove the car. Although driving fine, he took the Sedona to a shop where the hood was again popped- the coolant level was showing now above the max fill line, no coolant had been added; as no fluid was seen by the mechanic and since no check engine light was lit, an appointment was made to bring the car back for a full diagnostic. On 2/2/24, after driving 3 miles and making a turn, I thought I saw smoke. But, it was a rainy day so I thought it was condensation from the concrete. After 1 mile, again while slowing to turn, I thought I saw smoke again; I pulled down the window and smelled burning. At this point I was near my home and the check engine light now turned on. Since there was nowhere to safely stop, I proceeded to the front of my home and summoned my husband. He opened the hood and noticed smoke and extreme heat from the engine, but fortunately no fire. After a couple of days, we decided to tow the car to a shop for diagnostics instead of waiting 2 weeks for Kia- we were told the engine had failed. Stunned by the rapidity of these events, we contacted Kia Customer Support and towed the car to our Kia dealer. I have been told the head bolt stripped causing coolant to mix with oil and the engine to fail; the engine itself will cost $8,148 and, and, with ancillary repairs, the total repair will be over $12000. The car has 125k miles and has been fully serviced at Kia over 9 years, lastly 4 months ago which included coolant service. No check engine light was triggered until smoke and extreme heat were emanating from a blown engine, despite progressing degradation.

Filed Mar 2, 2024 · Engine · FL

Vehicle is regularly maintenenced. Driving down a road it had random loss of power and lost power steering. Was able to restart and it drove fine no check engine lights nothing. Got closer to my destination and my engine light popped at the same time a horrible metal on metal sound came from my rather quiet engine. Immediately lost power and power steering again. Able to coast off the road to safety, upon expecting the vehicle we found a hole and oil leaking out. A rod randomly blew thru the side of the block and there was no indication there was any engine problem beforehand. Cause unknown. I was advised after that these 3.3 motors are becoming know for random disintegration.

Filed Aug 4, 2023 · Engine · CA

I was driving down the freeway at 65mph when the engine died. Had to pull over in side of freeway. No previous problems or check engine lights. Regular maintenance has been done on the van. The 3.3L engine died without warning.

Filed Nov 25, 2022 · Engine · NY

My car a kia sedona, 2015, 85000 miles, was inspected by Matthews Kia on 10/7. It was RECOMMENDED that I have spark plugs and coils replaced. I was NOT told of the consequences or the urgency of this repair if I declined this repair. The check engine light was not on and it was running fine! THEY LET ME DRIVE IT HOME WITHOUT ANY WARNINGS. I went to bring it to a mechanic on 11/8 to have a second opinion and have the work done if they agreed with the diagnosis. That is when I was told it was a blown head gasket and the mechanic said there was nothing I did to cause this, I was able to drive it home, but i drove it directly to the dealership. They are supposed to last the lifetime of the car. It is only when I drove it 1 MILE from that mechanic to kia when it started to overheat, and The check engine light came on. When Kia inspected it and confirmed it was a blown head gasket and quoted me for a new engine. My safety was at risk because I have 2 children and when the engine went that is when the engine light came on and we almost got into an accident because I lost power.