Excessive oil consumption
2017 Kia Sedona engine complaints
Page 2 of 3: complaints 11 to 40 of 62, newest first, as owners wrote them.
Oil Control valve failed and oil leaking
Burning through oil faster than it should, needing to feel up oil every week, has been confirmed by an auto repair shop.⁸
On [XXX], while driving my 2017 Kia Sedona on a road trip through Killeen, Texas, the engine suddenly began making a loud knocking noise without any prior warning, leading to catastrophic engine failure and complete loss of motive power. The vehicle became inoperable and was towed to University Kia in Waco, Texas. The day prior, on [XXX], the vehicle underwent a thorough pre-trip inspection and full synthetic oil change at Sun Auto Tire & Service (5117 Golden Triangle Blvd., Keller, TX 76244), confirming it was roadworthy with no issues detected initially, though oil was found leaking afterward (maintenance records attached). University Kia confirmed the catastrophic engine failure, likely related to the 3.3L Lambda engine's known oil pressure switch (OPS) defects, as the OPS had been previously replaced under warranty. Kia Motors America (Case [XXX]) denied liability unless I pay $3,000 for a teardown inspection to prove the failure was due to the OPS, despite the vehicle's eligibility under the WTY026 extended warranty (15 years/150,000 miles). This failure aligns with similar complaints and the federal safety agency investigations into 3.3L Lambda engine issues, such as oil starvation and sudden seizures. Due to the failure, we missed a prepaid hotel stay in San Antonio, incurred additional hotel stay charges as our trip had to be extended, and incurred costs for a rental vehicle to complete the trip. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I was driving and my engine seized and my car is now undrivable. I immediately looked up recalls and see that there were several recalls and recalls surrounding the engine as well. I am told I now need a brand new engine and was referred to file a report as the issue experienced should not have been happening.
Engine stared clattering at the end of a 2 hour drive home. Engine died entering a round about 1-1/2 miles from home. It restarted and limped to my home. Arranged to have it towed to mechanic shop. They informed me there is issues with rod bearings and that Kia has a class action suite but Kia is telling me that my vin is not involved.
Without warning lights coming on my engine started knocking on May 15, 2025. Turns out the bearing between the top of the motor and the bottom of the motor is stripped. 5 months before this happened they replaced the 2 fuel pumps, cvvt, cam shaft sensor and assembly, timing chain and spark plugs. Again I had no warning about that work that the dealership said I needed. Now I need a new motor and they won’t do anything for me except charge over $10,000.
I heard a knocking sound in my car which I thought was coming from the engine towards the end of May. It was really bad on May 29, 2025, so I did not drive it again. I called my local dealership and scheduled an appointment for June 2, 2025. The vehicle had to be towed from my house to the dealership as it did not seem safe to drive. The battery had died when I tried to start it, so I called AAA for a tow. They were able to jump start the car, but I still did not feel safe driving it with the loud knocking noise. I had AAA tow my car to the dealership. This is what they found: LOWER ENGINE KNOCK, METAL IN THE OIL, LOWER ROD BEARING FAILURE. No lights were on at the time the severe knocking occurred. How and why was my VIN not included in the recall notice on the engines? This was clearly a safety hazard. This problem SHOULD BE COVERED by the engine recall. Now I have to get a new vehicle with extremely limited funds.
Catalytic converter system failure
On [XXX] my family and I were on our way to Oklahoma. Luckily we were on a highway instead of interstate when our Kia motor blew. There were no oil warning lights illuminated, nothing. My husband luckily was able to steer the van to the side of the road safely. My vehicle had to be towed and when codes were run on it by the oil changers, NO CODES POPPED UP and there were metal shaving in my oil filter. My husband contacted the dealer, they said the only issue they could find was not a recall, but an extended warranty for an oil pressure switch, but that with it not working it "would not make an engine blow." However, another mechanic said it absolutely would. This van does have the 3.3 engine that has been recalled in other models, but not the 2017. We had to rent a UHAUL to have my van pulled by another vehicle. In the picture you can see all the oil which was lost. How was our safety at risk? We had to pull on the side of the road on a main highway (not interstate), but there wasn't much room between the road side and our vehicle, not to mention the traffic right behind us who could have parked in our trunk when the failure occurred. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Using lots of oil
All maintenance performed at same manufacturer authorized dealership. My engine is currently full of sludge due the oil pressure switch under the recall not operating correctly before and after repair The was reported to dealer in October 2023 who engaged the manufacturer who authorized the repairs in May 2024 when vehicle would not hold oil at all.Car has not maintained oil level since repair .It has been in dealers since October 2024 seeking assistance from the manufacturer Recall MC-10210267-0001
I own a 2017 Kia Sedona with approximately 120,000. It has the 3.3L V6 engine. While driving, the vehicle lost power and would not run. The lights and the dashboard would come on, but it would not turn over to start. I took it to a mechanic, and they confirmed that the engine had seized up and would have to be replaced costing $11,000. I then had it towed to the dealership that I purchased the vehicle. They also confirmed that the engine had seized up and would have to be replaced at a significant cost. I had no warning that anything was wrong with my vehicle as the check engine light did not come on. I did hear a slight knocking the day before this happened. My husband checked the oil and added a quart of oil, which was unusual since we had not seen any oil on our driveway. I did have a warranty, but it lapsed due to being over the mileage cap by 2,000 miles.
The contact owns a 2017 Kia Sedona. The contact stated that the vehicle failed to immediately start and was experiencing rough driving with the check engine warning light illuminated. The vehicle was taken to the local mechanic who diagnosed the vehicle and informed the contact of the head gasket, head gasket bolts, fuel pump, and fuel injector failures. The vehicle was not yet repaired. Additionally, the passenger’s side electronic sliding door failed to properly latch due to a faulty electrical locking mechanism. The vehicle was not repaired. The manufacturer and local dealer were notified of the failures, but no assistance was provided. The manufacturer informed the contact that the vehicle was not included in an undisclosed Extend Warranty Coverage for the failure. The failure mileage was 50,000.
The Engine failed at 63,758 miles. Lancaster KIA in Lancaster, PA indicated the engine has metal shavings everywhere.
Motor has been consuming oil.all oil and maintence was done to this vehicle.on Monday the 18of November 2024 while driving too work the motor blew up putting oil everywhere.almost cause a major accident it had too be tow back to my house.
Engine seized. Purchased car on 9-16-24. One 9-17-24 I went to Valvoline and purchased a full synthetic oil change. Within 2000 miles driven since oil change mechanic advised that there was no oil and no leaks. Valvoline assisted my mechanic in the investigation and claimed the Sedona had a oil consumption issues. Manufacturing issues. Car shut off while driving. No light illuminated prior to the shut off and even with no oil there is no check engine light or oil pressure warning.
The contact owns a 2017 Kia Sedona. The contact noticed a green puddle underneath the vehicle with the low coolant message displayed. The vehicle was initially taken to an independent mechanic where the contact was informed that either the head gasket or the entire engine needed to be replaced. The contact was referred to the dealer for further assistance. The vehicle was towed to a dealer where the contact was informed that leak was caused by stripped bolts inside the engine which caused coolant to leak. The vehicle was diagnosed with engine failure. The engine was replaced by the dealer. The manufacturer was notified of the failure and the contact was informed that there were no recalls or warranties associated with the vehicle. In addition, the contact stated that the driver’s side sliding door intermittently failed to close as needed. The contact stated that while driving at various speeds, the door ajar warning light was illuminated. The vehicle was taken to a dealer where an estimate for the repair was provided; however, the dealer could not guarantee that the repair would fix the vehicle. The vehicle was not repaired. The failure mileage was 85,012.
My engine seized. When I took it to my mechanic they stated it was due to low compression and that Kia engines were known for this issue. He suggested I take it to a Kia dealer to have them replace the engine. I took it and I was denied the replacement. I did some research and found that this issue was in fact very popular among Kia owners. Some expressing their engines actually ignited. I also found there was a class-action lawsuit against Kia for this exact issue. I noticed all Kia models were included in the suit except for the Sedona. During my research I found a mass of Sedona owners who had the same compression issues. It baffles me why my car wasn't included when it has the exact isdues as the other models made by the same manufacturer. I would like to file a complaint in hopes that other Sedona owners have done the same, and we can bring light to this issue, and possibly a solution.
Engine had sudden unexplained loss of oil followed shortly after by Engine failure due to broken rod
my engine blew while driving on the highway April 2023. my connecting rod snapped. no check engine light or oil warning light ever came on prior to this happening. I had maintained oil changes every 2000 miles since purchase. oil levels were within normal range when this incident occurred. the car showed no symptoms of this happening prior to it happening. Kia has engine recalls but my vehicle was not listed in this recall.
We bought this van in September of 2023. No known issues… we’ve kept up on regular oil changes etc. Over a month ago a slight tap started happening when vehicle started up, took it three places and all 3 said we needed a new engine. We just hit 100k…. Within two days of those opinions, engine seized while I was driving. No injuries but a car this new with no known issues this is not ok. Zero lights came on the dashboard. No check engine light, nothing. It’s been in a shop for over a month while we wait for a new engine to come in. Would never ever buy another Kia. Dealership and two local places both told us they do not know what happened or why this happened.
The contact owns a 2017 Kia Sedona. The contact stated while driving 45 MPH, the connecting rod punctured the engine causing an engine oil leak. As a result of the failure, the vehicle stalled. There was no warning light illuminated. The vehicle was towed to a local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 117,000.
The contact owns a 2017 Kia Sedona. The contact stated while driving 70 MPH, the vehicle lost motive power. There was no warning light illuminated. The vehicle was able to be restarted; however, the failure recurred. The contact also stated that there was smoke coming from the engine. The vehicle was towed to the dealer where the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.
July 5, 2024 Engine started to make a noise, had inspected at a local repair shop July 9, 2024, they diagnosed it as "crack in the front valve cover due to what seems to be something internal to engine coming apart. This vehicle is going to need a new engine." No warning lights were on, no service needed lights. yes, available currently for inspection as long as I don't trade it off. safety could have been at risk if it seized up while on interstate Insurance said it wasn't covered and have not warranty insurance no symptoms, no warning lights, nothing. Driving home on Friday the 5th when 5 miles from home it felt like it was loosing power and didn't want to accelerate. then I noticed the noise. Still no lights on dash
The engine seized suddenly and put my family in danger. There are recalls on other kia engines and it is clearly an issue but KIA is not taking responsibility for it and has told us we must pay 13K for a new engine or they will give us $500 to "take it off our hands" --- this is wrong. We have kept the vehicle well-maintained and have all the records to prove this. It has just over 100,000 miles on it and we still owe money on it. KIA is putting families in danger but not acknowledging that there is a possibility of engine failure in the Sedona van. There have likely been deaths and injury as a result of this and yet, nothing is being done! Please hold KIA accountable and insist they do a nationwide recall for all engines that are affected by this defect.
My engine made a knocking noise and stopped working while I was driving down the road, without any warning. Then it would not start / work. It was towed to a Kia dealership, and I have been told I need a new engine, at the cost of $10, 750. The van has 135,000 miles on it. This van has the 3.3-liter V6 Gasoline Direct Injection (GDI) Lambda Engine. The repair report from Kia states that it "needs a long block due to engine has bottom end noise and is seize up".
I was driving my 2017 Sedona and without any indication or check engine light, the motor started to make a loud knock and it ultimately seized up. Leaving me stranded. I have the oil changed per guidelines. There was no warning, no indication that the engine was going to spontaneously seize up. I was on a busy highway and was barely able to get to shoulder. I started to research this issue and found that this is a well known defect in the 3.3L lambda 2. Why isn’t something being done about this? Completely unsafe!
Engine crankshaft failure suddenly
The contact owns a 2017 Kia Sedona. The contact stated that while his wife was driving at an undisclosed speed, the vehicle made an abnormal sound and shuddered before stalling. There were no warning lights illuminated. The vehicle was towed to the residence. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 137,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Kia Sedona?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history