The contact owns a 2014 Kia Sedona. The contact stated that while inspecting the vehicle at the residence, the contact became aware that the driver’s side front lower control arm was severely rusted. The contact replaced the driver’s side front lower control arm due to the failure. The manufacturer was made aware of the failure by telephone. The failure mileage was approximately 130,000.
Kia Sedona ball joint problems
93 of the 2,417 owner complaints about the Kia Sedona describe ball joint or control arm failure, most of them for the 2006 model year.
- owner complaints
- 93
- worst model year
- 2006
- typical mileage
- 120,400
Is there a fix? There are 2 recalls for this area of the car. See below
By model year
Often reported together
Coil spring 4Jerking 3Engine failure 3Stalling 2Headlights 2Harsh shifting 2Knocking 2Grinding brakes 2
What owners say
My 2009 Kia Sedona is under Safety Recall SC133 (NHSTA 16V‑387) for front lower control arms that can corrode and break. The dealership has had the vehicle at ANDY MOHR KIA in [XXX] for two weeks and states the frame is too heavily rusted to safely mount the new control arms. They will not perfom the recall repair. The vehicle is currently undriveable due to the structural condition related to the salt-belt corrosion issue covered by the recall. I have an open Kia Consumer Affairs case (XXX) but have not received a resolution. The dealership escalated this, but there has been no timely response or resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving the vehicle and applying the brakes the vehicle shifted to one side of the road. There was an accident 03/2024 after having the brake control arm serviced. The braking system failed. There was a recall on the front control arm 2016. The vehicle was totaled and was salvaged due to damages to the vehicle. The brake inspection failed. Today the braking system has has no control even after the master cylinder was repaired. The vehicle is currently sitting at a service station without being serviced for at least 2 months. Kia needs to be responsible and refund for the arm control repair and other related part failures. The electrical system does not work for the windshield wipers or the air conditioner or sliding doors.
The contact owns a 2016 Kia Sedona. The contact stated that while driving at 50 MPH, there was an abnormal knocking sound coming from the vehicle. The vehicle lost motive power and drove forward about the length of the vehicle before the vehicle stalled. The contact and the occupants were stranded for an hour. There were no warning lights illuminated. The vehicle was towed to an independent mechanic who replaced the starter and informed the contact that the piston or tie rod was fractured. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 222,627.
The contact owns a 2008 Kia Sedona. The contact stated that while driving 20 MPH and attempting to stop the vehicle, there was an abnormal sound coming from the steering wheel. The vehicle was towed to a dealer where it was diagnosed and determined that the control arm was damaged and needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure and a case was opened. The failure mileage was 160,000.
I had no prior knowledge of this problem. When backing my van out of the garage my front driver side tire blew out. This was caused by the strut spring breaking and poking a hole through the sidewall of the tire. I also discovered that the bottom control arm needed immediate replacement as it has rusted so much that a failure was imminent. I also discovered that the sun-frame mount for mounting the control arm to the sub-frame so badly rusted that it was unsafe to attempt a repair, as it would break away in short order if I were to replace the control arm and drive the van. While deciding what to do with the van I was storing it in my barn. Within a few weeks, I discovered the front passenger tire was flat. It too was impaled when the strut spring broke and poked a hole in the sidewall. I was really lucky that I was driving on a road, as serious crash could have occurred. If this failed while driving, loss of control would have occurred. I consider this a major safety issue and may be present in other Sedonas without the owners' knowledge. I contacted the dealer that I purchased the vehicle from and was told they could do nothing.
Right lower control arm broke while I was driving
both control arms broke and the front tires were ruined. The tow truck driver said they are lucky , they didn't get hurt because if they were going faster , they would have lost control and rolled the van.
The contact owns a 2011 Kia Sedona. The contact stated that while her daughter was driving approximately 40 MPH, she heard a loud squealing sound coming from the front tires. The contact stated her daughter pulled off the road into a parking and heard a loud crack. The contact stated that her daughter had not been aware of any warning lights. The contact stated that her husband had the vehicle towed to the residence. The contact stated that the control arms on both sides of the vehicle were corroded and had fractured. The contact's husband made the repairs to the vehicle. The contact stated that she researched online and related the failure to the federal safety agency Campaign Number: 16V38700 (Suspension). The manufacturer had been informed of the failure. The failure mileage was approximately 195,000. The VIN is unavailable.
Vehicle was not drivable. Driver side front control arm was corroded and cracked/broken.
Related recalls
Suspension: front: control arm: lower arm
- What is wrong
- Kia Motors Corporation (Kia) is recalling certain model year 2006-2012 Kia Sedona vehicles manufactured from June 15, 2005, through August 14, 2012 and originally sold in, or currently registered in Alaska, Connecticut, Delaware, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may break due to corrosion from salt water exposure such as from road salt use.
- Risk
- A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
- Remedy
- Kia will notify owners and dealers will replace the front lower control arms on 2006-2007 models. 2008-2012 models will either have their front lower control arms replaced or additional anti-corrosion coating will be applied. These repairs will be performed free of charge. The recall began on July 27, 2016. Owners may contact Kia at 1‑800‑333‑4542. Kia's number for this recall is SC133.
Recall number 16V387000 · Recall details
Suspension: front: control arm: lower arm
- What is wrong
- Kia Motors Corporation (Kia) is recalling certain model year 2006-2012 Kia Sedona vehicles manufactured from June 15, 2005, through August 14, 2012 originally sold in, or currently registered in Massachusetts, Maryland, Michigan, New Hampshire, New York, Pennsylvania, Vermont, Wisconsin, Connecticut, Delaware, Iowa, Illinois, Indiana, Maine, Minnesota, Missouri, New Jersey, Ohio, Rhode Island, West Virginia or the District of Columbia. In the affected vehicles, the front lower control arms may break due to corrosion resulting from prolonged exposure to salty environments.
- Risk
- A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
- Remedy
- Kia will notify owners and dealers will inspect the degree of corrosion of the front lower control arms, and will either rustproof or replace them, free of charge. The recall began on December 20, 2013. Owners may contact Kia at 1‑800‑333‑4542. Kia's recall number is SC100.
Recall number 13V550000 · Recall details
Questions about the Kia Sedona ball joint
Which Kia Sedona years have ball joint or control arm failure problems?
The model years with the most reports are 2006 (62 complaints), 2007 (9 complaints) and 2008 (8 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used Kia Sedona?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history