Engine issue - unknown excessive oil consumption. I started the car to drive to work and immediately it had a very rough idle. I turned the car off and checked the oil level. The car was on a level surface and the oil level was below the acceptable range on the dipstick. It has been about 4000 miles since my last oil change (around 82000 miles) and I noticed the engine was consuming oil about 2500 miles after that oil change. I added a quart of oil to bring the level back within the dipstick’s acceptable range. Throughout all of this, there have been no puddles to indicate a leak, no smoke to indicate oil burning, and no “Low Oil” warning light. I took the car to a Kia dealership in August 2025 for a piston ring recall inspection, and I was told there was nothing wrong with my car. At the time, there was nothing noticeably wrong with my car. I now wonder if the inspection properly assessed the issue. After looking on the Internet, high oil consumption seems like a common issue with my engine that persists even after Kia’s recall inspection. There was no immediate threat to my safety this morning, but I am concerned that this excessive oil consumption could cause catastrophic engine failure before an owner has a reasonable expectation to check the oil level between service intervals.
2022 Kia Seltos engine complaints
Page 2 of 3: complaints 11 to 40 of 49, newest first, as owners wrote them.
Took my car in for oil piston recall. H&H KIA advised my oil level was low. I advised oil change just done 1/16/2026 and under the 6 month/7500 mile oil change recommendation. I provided screenshot that show it could indicate problem related to recall. Dealership did inspection and did advise no oil leak. When I asked about this they advised I had to pay for an engine clean and also an oil test. I questioned why should I have to pay if related to recall. They quickly said the recall was fixed by software update. When I asked again about low level of oil readings the answer was recommending the engine clean. Oil change totaling more than 300.00 . I fear my safety now driving my car due to this which in turn is causing a high amount of uneasiness and anxiety.
Car is throwing a P1327 error code which aligns with this recall: 25V099. However, my VIN is not included in the recall despite being a 2022 Kia Seltos.
Certified shop said my timing chain was going as well as other associated components. My car is always low on oil even when mileage has not been met. Found my car is part of piston ring recall. Dealership stated my car is not affected however the issues the shop found most certainly confirm my issue which is going to cost over $2k to fix is associated with this. Dealership not only says my car passed piston ring recall but wanted $175 to diagnose what has already been diagnosed and then another $175 on top of that to "dig into the engine". Check engine light came on and car began making noise and not running properly on 2/7/2026 on 2/9/2026 called independent service center and car was checked out and diagnosed on 2/11/2026. Found out this is likely recall related 2/12/2026. Car was looked at by dealership on 2/17/2026 and I was told the aforementioned. However magically the two other recalls on this vehicle were remedied but not this one.
Purchased my 2022 Kia Seltos new from my local dealership and stayed up to date with all scheduled service, as well as all manufacturer recalls and software updates. When driving it in January 2025, I experienced loss of power when accelerating and an engine stall. Took it to the dealer the same day and was told the vehicle was out of oil, and this caused engine damage that would not be covered by my warranty (I have approximately 44,000 miles on the car). Never had any kind of warning signs — no check engine light or any dashboard alerts. Also never had any issues with oil levels between regular oil changes at the dealership. Luckily, I’d not been driving in particularly heavy traffic when the issue emerged, or else could’ve caused an accident. And luckily I took it to the dealer when I did to prevent a more catastrophic engine failure. Seems to have burned through a ridiculous amount of oil in a relatively short period of time while giving no warning signs that it was doing so.
I purchased this 2022 Kia Seltos on [XXX] from Serra Nissan Volkswagen Inc, Birmingham. One week afterwards my vehicle cut off at the light while waiting for light to change....This incident has occurred more than 10 x since then. My vehicle have over a 100,000 miles on it which does not qualify for Kia yo check it out. I will be taking my vehicle to get a service check. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My Seltos transmission heats up to such an extent that I have to get out of the car and park it for 45 minutes to have it cooled down. Has only 25k miles in it. Took to the dealership and they say nothing is wrong. Numerous reported issues of the same kind on Kia message boards regarding the same issue. Something to do with the dual clutch system and start/stop function
My 2022 KIA Seltos with 52000 miles shut down on me completely in the middle of a road while I was going full speed limit causing the car behind me promptly to change lanes to avoid the collision. It happened 2 more times until I got to my destination l. After I googled what could cause the issue I saw the recall info which I didn’t get any notification about. I brought my car to a dealership and they told me that it passed the recall but I have to replace the whole engine because they found metal filings in the oil. They are refusing to do it under warranty or recall because I cannot produce oil change receipts since January of 2025. I was under the impression that recalls need to be fixed but they denying that it is a recall even though it is to a tee follows the description of a recall.
My vehicle was sent to the Kia dealership for service after a front-end collision there was minor body damage however the car wouldn't move so long story short a modular had to be replaced on the transmission there was multiple issues trying to program it I was told there was an issue with my computer they had to reach out to Kia manufacturer for help. I received my car back and while it was there for service I had them do an oil change I hadn't drove 300 to 400 miles and all of my oil was gone from my car when I called Kia they had me bring it back in couldn't find anything wrong with it and said they want to do a oil consumption after I had already documented oil that I had to put into the car three times in the week up until my appointment because every time I check the car it was empty of oil. Now Kia is telling me to drive a thousand miles on it so they can do an oil consumption however my check engine lights on my oil lights on and it is clearly burning extremely high amount of oil. So in caution of not blowing my engine I added oil to my car yesterday one quart and now my oil light is back on after maybe 20 miles of driving. Haven't gotten to 400 mi yet total out of the thousand Kia wants me to drive and my car has stalled at three red lights and cause me to miss out on two job opportunities. My car is a 2022 and has 62,000 miles on it. Everything I research shows there's piston recalls on the engines that are causing these exact problems that my car is having except there hasn't been a recall put into place for my specific year and make. The 2021 and the 2023 Seltos are listed, but my VIN number shows no recalls. The car has a horrible smell now it constantly smells like burning rubber or oil rather, exhaust stinks now. Car is not performing as you would expect a car would with that low of mileage in less than 3 years of ownership. And related to my accident the only issue was the modular on the transmission according to the mechanics everything else was ok
My 2022 Kia Seltos repeatedly stalls and shuts off while driving, including in traffic and at stop signs. The vehicle has also had multiple electrical failures and an emergency brake malfunction. A few weeks ago, October 26th, while going through a Starbucks drive-through, My car completely stopped. I got stuck in the Starbucks line and multiple people had to help me push my car out of the drive through. I can get the name of the lady at the Starbucks and maybe her co-workers to collaborate if need be plus I have text messages with my family because I didn't know what to do. The vehicle has now been at Covina Kia for three weeks, and the dealership has refused to provide a diagnosis, repair timeline, or loaner vehicle. I called today to get an update and was told to expect a response or diagnostics in approximately 10 days. They won't even give me a rental car and I'm stranded without transportation. This is a serious safety hazard that could cause a crash. I am requesting the federal safety agency investigation and documentation of this defect.”
This vehicle passed the piston oil ring recall in September 2025, by November 2025 the vehicle was burning through a quart of oil a week. Two different dealerships advised that this wouldn't be covered under the recall, stating the recall was for engine noise. The recall states that the issue in question can cause increased oil consumption that will then lead to noise. The vehicle was 5,000 miles out of warrenty
[XXX] [XXX] [XXX] [XXX] 2022 Kia Seltos [XXX] 54,000 mileage I am reporting two serious safety defects with my 2022 Kia Seltos: Engine Shut Off / “Push Engine to Start” Warning: Date(s) of occurrence:[XXX] Location: Throughout Portland, OR Description: While slowing down and stopping at intersections, the vehicle starts beeping very fast, then displays the “Push Engine to Start” warning, and then shuts off completely, creating a high risk of collision. Cruise Control Unintended Acceleration: Date(s) of occurrence: [XXX] Location: Throughout Charleston, SC and Charlotte, NC Description: While cruise control was engaged, the vehicle accelerated without any driver input. This happens infrequently. On two occasions, I was on straight open roads and watched to see how fast the speed would increase - 80 mph and 100 mph. I used the brakes to stop the increase in speed. This is a severe safety hazard. The transmission stutters at low speeds, causing the car to lurch: Ongoing issue - a few times a month since purchasing the car. Previous Claims / Service History: I have previously filed a warranty claim for other issues with this vehicle. The current issues have been reported to the dealership but have not yet been repaired or reproduced. Additional Information: No video evidence is available, as the events are intermittent and stop before a camera can capture them. I am concerned for my safety, the safety of passengers, and the safety of other drivers. Action Requested: I request that the federal safety agency review this complaint for potential safety investigation and recall consideration. [XXX] 11/17/2025 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My car was part of the piston ring recall. It burns over half a quart of oil per 1,000 miles. When I took the car in for the recall inspection, it was deemed that it needed a new engine. They then called me and told me that they “revised” the test, and it no longer would be getting a new engine. The car is still burning oil and makes a ticking sound. The recall issue was not resolved, and my car still has the symptoms relating to the piston rings being faulty. Kia did not fulfill their duty of the recall.
My engine failed while i was driving on a busy street almost causing cars to hit me there were no warning signs about the engine, my battery also died as well that is the only sign that appeared.
My car was part of the original Kia engine recall for 2021-2023 Seltos'. At the initial appointment I was told that my car had failed the test and would require a new engine. Then I was called and told that Kia had issued an update on the recall and that I would have to bring it in for a different test. I called Kia's corporate office and was told on the phone by them (the guy refused to give me his name) that even if my car did fail a second time that it was hard telling when it could be fixed because they didn't have the engines to replace them with and they were on back order. Then I was told that my car had magically passed the second test. I maintained that I disagreed with them because my car still has issues going uphill and when you pull out it feels like all the power drains. They informed me that they disagreed and the technician had test driven it and didn't have any issues. They tried to coerce me into saying that it was fixed. Kia even contacted me multiple times trying to get me to "agree" that my car was fixed and I refused to answer their calls anymore. I do not agree that my car is fixed and I feel that they are just trying to rip people off.
The contact owns a 2022 Kia Seltos. The contact received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling); however, the contact had scheduled a recall appointment and was advised by the dealer that the recall had been placed on hold. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the recall was on hold. The contact stated while driving approximately 45 MPH and ascending a hill, the vehicle hesitated while depressing the accelerator pedal, and failed to respond as needed. Additionally, the contact stated that vehicle was making abnormal knocking sounds while the vehicle was stopped and idling. The contact stated no warning light was illuminated. The vehicle had not been diagnosed by the dealer. The failure mileage was approximately 36,000. Parts distribution disconnect.
The contact owns a 2022 Kia Seltos. The contact stated while driving at various speeds, the vehicle shut off without warning. The contact was able to drive the vehicle to the dealer where an unknown sensor was replaced; however, the failure returned soon after the repair. The contact then received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling). The contact informed the dealer of the recall, and the dealer acknowledged the recall and that the piston oil rings had failed; however, the dealer informed the contact that the manufacturer had ordered the dealer not to perform the recall repair. The vehicle remained in the possession of the dealer. The contact was recently informed that the vehicle needed to be picked up from the dealer location because the part to do the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 50,000. Parts distribution disconnect.
Vehicle went into dealer for safety recall on 4/15. I was notified on 4/16 that my vehicle failed the test and would need a new engine. I was given a rental car. They were unsure of time frame. Later found out that recall had been placed on hold. 5/13 contacted that new test protocol had been released and my car passed under new testing. No engine would be needed. I asked for documentation of both tests the fail and the pass. I was told they are unable to print this out for me as it all goes into the Kia database. No reasonable explanation was given as to what changed that made my vehicle pass, when it previously failed. This feels incredibly suspicious. Now I am just driving around in this car that may or may not have a problem, and the value of the vehicle could be effected, should i wish to get rid of it. I do not feel this was handled appropriately.
The contact owns a 2022 Kia Seltos. The contact received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling); however, the dealer informed the contact that the manufacturer had ordered the dealer not to perform the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2022 Kia Seltos. The contact received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving 25 MPH, the vehicle stalled. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was able to restart. The contact stated that the failure had recurred while driving at various speeds, but mostly while driving at slow speeds. Additionally, the contact stated that the vehicle was experiencing excessive oil consumption, which required the contact to add a quart of oil to the vehicle every 2 to 3 days to reduce the frequency of the failure. The contact stated that upon taking the vehicle to the dealer for recall repair, the local dealer informed the contact that the manufacturer had put a hold on the recall repair. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 206,000. Parts distribution disconnect.
2022 KIA SELTOS S AWD [XXX]- ENGINE FAILED, PISTON SCORING, PISTON OIL RING FAILED, OIL BURNING, KNOCKING IN ENGINE. THIS KIA'S VIN NUMBER IS PART OF THE KIA RECALL THAT WAS PUBLISHED 2/17/25 AND ANNOUNCED TO CONSUMERS VIA MAIL ON 4/4/25. My [XXX] daughter & I purchased a used 2022 Kia Seltos on [XXX] Mileage at time of purchase was little bit under 60,000 miles. On [XXX], while on vacation in Florida, my daughter noticed sluggish acceleration, smoke coming from exhaust and some from hood, a knocking sound from engine and then engine then seized in the middle of the road. If they wouldn't have stopped, this engine would've started on FIRE! This event caused SIGNIFICANT DANGER to my young daughter and her 3 passengers! My daughter and her friends had to push the vehicle back to a safe location off the road so they didn't get hit by a car. We are from Wisconsin and these kids were stranded in Florida on vacation without a vehicle. We had to have the vehicle towed to a Kia dealership in Panama City, FL on 3/28/25. Inspected and RECALL testing done by Kia in Panama City, FL. It is now 5/2/25 and we are STILL WAITING FOR KIA TO APPROVE A NEW ENGINE FROM THIS RECALL. NO ONE WILL GIVE US ANY UPDATES. These 2022 Kia Seltos engines are a complete danger! Engine needs to be REPLACED ASAP INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I took my Kia to Moritz Kia Alliance, Keller TX on 4/24/25 for the current recall and letting them know that my vehicle has experienced issues outlined in the recall notice (almost all of the oil was burned and we had to add a quart to get it to the dealership, car has lost power while driving, car has stalled). They tested in 4/25/25 and called to let me know that it failed the test and would require a new engine. I called on 4/29 to inquire about a loaner vehicle and the dealership notified me that KIA halted the test due to software issues and I was required to pick up my vehicle. I messaged KIA customer service who advised that the new software would be available 5/1. I did not pick up my car due to the issues I had experienced and did not feel safe driving it. Today 5/2 the dealership said that the second test failed but KIA has halted testing for a second time stating software issues. The dealership has had no concern for the safety of my vehicle and KIA appears to be halting testing and requiring individuals to drive these vehicles exhibiting potential recall related issues with no concern for the general public.
The contact owns a 2022 Kia Seltos. The contact received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling); however, the dealer advised the contact that the manufacturer had placed the recall on hold. The contact stated that the engine was not replaced, and that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the recall had been stopped. The contact had not experienced a failure. Parts distribution disconnect.
The dealership is not honoring the recall or warranty. Car needed 3 quarts of oil and there is pressure from the oil fill cap when open while the engine is running. The dealership is Kia of Huntington - 1720 East Jerich Turnpike, Huntington, NY 11743; 631‑546‑0202
The contact owns a 2022 Kia Seltos. The contact received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling); however, the dealer informed the contact that the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Recieved a recall notice in the mail early april 2025, scheduled an appointment for the recall of my seltos at the westside kia dealership in katy tx on april 14th 2025 the vehicle was dropped off. April 16th they updated me stating that the enginge and piston rings at failed the inspection and a full engine replacement would be needed so they ordered it but said there was no eta on when it would be completed. Kia customer care said the same thing, both kia customer care and the dealrship said that the car could not be picked up because the recall could cause complete enginge failure, fire, or could cause you to crash. Today 5/1/25 I am being told the recall is on hold even though my vehicle has failed the inspection that they would not be replacing the engine right now and I am being told to pick it back up despite it not being fixed. I informed them again of what the recall states and the safety risk and kia customer care said I am not obligated to drive the vehicle but due to the recall being on hold I need to pick it up and I no longer qualify for rental reimbursement. Prior to me taking my vehicle in I was going through oil more frequently and my mpg dropped significantly.
What component or system failed or malfunctioned, and is it available for inspection upon request? The engine keeps stalling and there’s a recall on the engines and I had to wait a month for dealership to say the recall isn’t the problem! How was your safety or the safety of others put at risk? I drive on the highway and busy street and my car will just stop or make smoke for oil reserve. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes the number Ted that they hear the noises on my car. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? 2 months ago I started hearing a grinding noise, oil light came on irregular from oil consumption and metal shards in oil.
Engine seized while driving on vacation in florida. Put the driver and 3 passengers at major risk for an accident and/or fire! Had to push vehicle back to a safe spot. Had noticed sluggish acceleration on and off and some smoke coming from exhaust, engine knocking was very present, oil looked dirty and gritty. Noticed there was a recall for this kia- engine needs to be replaced due to this recall asap. We had to pay for plane tickets to get all 4 people back home to wisconsin, had to pay for transportation back and forth, lost out on days of vacation, had to have this vehicle towed to kia in panama city, fl and will now have to have it shipped back to wisconsin, we will have to pay for a rental vehicle while this is inspected and fixed. Kia should reimburse or pay for all of these things! My daughter and her friends were stranded in another state due to this bad engine at only 60,800 miles!
My Kia Seltos has a recall on the engine because the piston rings leak oil. My car is now losing massive amounts of oil and has damaged my engine. I brought car to dealership and they wanted me to go through my warranty and refused to honor the recall and kicked me out.
My 2022 Kia Seltos engine seized and Kia refused to fix the problem. This engine has a safety recall related to the engine and the manufacturer refuses to change the seized engine. We had to pay almost $6000 from our pocket to replace the engine as we need the car to go to work.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Kia Seltos?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history