10/2021 Drove to store (about 20 minutes). Shopped for about 1 hour. Started to leave parking area and enter ramp to highway when the engine stopped. Everything went off. No warning. No check engine light, no maintenance light, nothing. I was able to steer back into the parking area. Put car in park and waited about 4-5 minutes. Started the car (it started without a problem) and began driving in the parking lot. when it began hesitating and feeling as if it would stall again. there was a gas station next to the parking area. pulled in & filled tank (tank was 1/2 full) and just barely pulled into a parking spot in front of gas station convenience store. Got towed to our local garage. They changed the oil and checked external systems and thought it was working fine. When my husband picked the car up it was still hesitating and almost stalling on the way home. Next, took it to local Kia dealer. Same situation. Couldn't find anything, said it drove fine for them. Same thing happened to my husband on the way home. Stalling in traffic. Having to restart the car in an intersection. Very dangerous. Brought back to dealer and they said it would cost $600-1000 to diagnose. Then it might cost $5000 - $10,000 to fix (replace or rebuild the engine). I reached out to Kia Customer Service but they did not offer any solutions other than to talk to the dealership in question. We are at a stand-still and have not been able to drive the car since October 2021.
2015 Kia Sorento engine complaints
Page 7 of 13: complaints 161 to 190 of 367, newest first, as owners wrote them.
I was driving down the highway going about 75-80 MPH, and my car started acting funny. No lights came on or smoking or anything to indicate something was wrong other then it acting funny. Pulled off the highway and my car died, had it towed (after waiting for awhile) got it towed to a AAA service center where they told me my engine was blown. Towed it back to Kansas (I was traveling on vacation when this happened and was 2.5 hours from home) to a kia dealership where now my car will not "throw the code" for the engine to be covered by warranty
Kia dealer confirmed that the engine is seized, like a bearing. Has been approved for engine replacement under warranty and previous class action settlements through Kia. We were traveling down the highway at 80MPH in the process of passing another vehicle when the engine suddenly seized. No warning before hand; no noise, no overheating, nothing. Car was running normally. No warning lights came on. We lost all acceleration power. We were able to navigate traffic to the side of the highway where the cars engine quit and would no longer start. 2 hours stuck on the highway with traffic zipping by at 80 MPH, $300 tow bill.
This product continually needs oil. The engine smells all the time as though it may be burning. I have spent hundreds of dollars on oil. It is not able to have consistent oil changes due to there often times being no oil in the veh to change. The low oil indicator never shows. Also, The brake lights are constantly blowing out. On one occasion A bulb burned into its housing and had to be pried out in order to replace it. I have complained to Kia to no avail. It’s stopped twice. Yesterday most recently. It started shaking and making a clinking noise and shut off. It’s being towed to the dealership. Kia is aware of the fire potential and has sent written directives on where not to park.
On March 11, 2022 I was driving my 2015 Kia Sorento when the engine died. I was driving on a major road when all of a sudden my brakes locked up and all the warning lights and sounds went on and my car stopped. If it would have happened on the highway I could have been seriously injured. The problem has been confirmed by a dealer and an independent garage both saying that my vehicle needs a new engine. It has been meticulously maintained. Prior to the engine failing there were no warning lights indicating any low oil or service engine lights. The dealership stated that it was not my fault. I contacted the Kia manufacturer and they said there is nothing they can do because it is over the 100,000 mile warranty. It only has 110,000 miles on the car.
What component or system failed or malfunctioned, and is it available for inspection upon request? Engine, it is currently available How was your safety or the safety of others put at risk? Absolutely Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO Car began making very loud noises, passenger felt parts dropping, car quit, a piece of a control arm was found on the ground.
Car was sounding funny. Had recently did oil change about a week ago. I took car to kia and they said I had recalls that needed to be done. Kia did all the recalls on my car and installed knock system. They called me to pick up car and the car shut off of them. Called kia and they first approved the dealer to purchase the new engine. They then sent an email denying the purchase of a new engine. This has been going on for several weeks. They are saying engine had failed when car went to dealer but why would they perform work on a car's engine that already failed. They are refusing to fix car.
The contact owns a 2015 Kia Sorento. The contact received notification of the federal safety agency Campaign Number: 21V331000 (Service Brakes, Hydraulic). The contact stated that while driving at an undisclosed speed, the ABS and oil warning lights illuminated. The vehicle then lost motive power. Upon inspection, the contact noticed there was no oil in the oil reservoir. The vehicle was taken to an independent mechanic and diagnosed with camshaft position sensor failure. The mechanic replaced camshaft position sensor; however, the failure recurred with a rattling sound coming from the vehicle. The vehicle was then towed to the dealer and diagnosed with engine damage and connecting rod failure. The dealer performed a Product Improvement Campaign: PI1802 (Knock Sensor Detection System - ECU Logic Improvement) software update. The contact was informed that the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and directed the contact to take the vehicle to a dealer. The manufacturer declined the engine replacement since the contact did not have the product improvement campaign software update prior to the failure. The failure mileage was 99,702.
The motor is doing a clicking noice. And Kia will not cover the motor since it had another recall that wasnt done in a timely matter. The car stoped in the middle of the freeway and would not move.
-Cylinder walls excessive engine oil consumption. My engine was replaced in June 2019 For my 2015 Kia Sorento. My vehicle presently and right before my 2019 engine replacement would drain oil, but no visible leaks. Smokey exhaust, and loud knocking sounds. Sludgy oil that regularly needs to be replaced. No horsepower or pick up to drive at normal speeds -Due to the oil depletion I was fearful of my vehicle catching fire. It recently stalled on the interstate. -Yes the problem was confirmed 2/24/2022. -Vehicle was inspected at Ed Voyles Kia dealership by a service technician -My vehicle was losing momentum. Multiple lights aluminated, as well as wacky battery issues. check engine light, oil light, battery light, ABS, Electronic Stability, Malfunction indicator, lights illuminated during vehicle failure. My oil light started in August 2021. It came off and on, even with regular oil changes. I took it to another Kia Dealership in October 2021. They did a diagnostic and said my engine was the culprit but that they could not warranty any repairs. I wasn't able to get an appointment with the original dealership that did my previous engine repairs, until February 10, 2022. I called the Kia corporate office several times for help.
I was commuting to work and without any warning, no lights at all, the whole front of the car starts violently vibrating and making all sorts of metallic banging noise. I had it taken to the local KIA dealership where they diagnosed it was the Crankshaft and Connecting Rod Bearings.
Driving to Lexington KY motor began knocking and lost power. Towed home had mechanic look at it found metal in oil pan, towed to KIA dealer and informed it needs new motor. KIA denying warranty because product improved wasn’t done. Having to replace motor out of pocket.
I engine light keeps coming on after taking my car in to have a diagnostic to pin point the issue with Southern Kia in Chesapeake, Va, 1300 S Military Hwy Chesapeake, VA 23320 (757) 424-6380. The report came back with a code for engine tube that was preventing the evaporation of gas to/from the engine. Less than 4 hours later after the repair the engine light came back on. I took the care back to Southern Kia in Chesapeake, Va, 1300 S Military Hwy Chesapeake, VA 23320 (757) 424-6380 and now they are saying it's something else with the engine. My car has been with Southern Kia in Chesapeake, Va, 1300 S Military Hwy Chesapeake, VA 23320 for three weeks and they are saying they are waiting KIA to give them guidance on the issue.
Engine shut off without warning while driving. My wife was driving and Was able to roll off road thankfully. She was on a very busy road and was in serious risk of injury along with the cars behind her. Did not start back up. Battery had power. Found out ENGINE FAILED! Verified by mechanic. Called Kia Corporate Customer Service number and was told the engine will not be repaired. 125,000 miles. No warning lights came on. This is absolutely wrong of Kia! Shame on them!
December 28, 2021 On Hwy 85 right next to Auburn, Alabama, on my way to Houston, Texas, I began to notice that as I accelerated with my 2015 KIA Sorento there was a sound as if my muffler had a hole in it. Within just a couple of minutes, the car wouldn’t accelerate well. I then pulled off the highway onto a ramp and at the intersection the oil indicator light lit up and then the engine light and then there was a rattling noise and then the car quit. I checked the oil and it was a little bit low….not much though. A passerby took me in his car to an auto parts store where I purchased two quarts of oil. I put in the oil and started the car. The oil indicator light was now no longer on but there was a little bit of a rattling sound or knocking sound. The passerby said he knew a mechanic that was just a quarter mile down the road at a full auto service shop and that he would follow me if I wanted to take the car there. It was very close so I drove there. As I got closer the rattling/knocking sound got a little louder and then as I was about ready to pull in to the shop the car shut off and wouldn’t turn on. I had the car pushed the rest of the way into the auto shop. The mechanics looked at it and said it was “locked up” and would need a whole new engine. One mechanic said that KIA engines sometimes do this with little to no warning. I was shocked. I had never had any problems with my 2015 Kia Sorento before. It had now 96,000 miles on it and I only really had to do the oil changes every four months or so. A few hours later I had it towed to the KIA dealership in Auburn and they looked at it and determined it needed a whole new engine and new starter. The price would be $9,700 dollars. The KIA service people mentioned a Theta Engine Class Action Lawsuit that I might be eligible for. I filed a claim and the website showed that my VIN indicated I was eligible for this claim. I have been told KIA will make a determination on the claim in 60 days.
Kia is refusing to replace my engine related to a product improvement issued in 2018. I never received a notice about the required product improvement. The vehicle simply failed while I was driving. I was luckily able to get to safety. There were no warning lamps or messages or symptoms. The vehicle has been inspected by Kia and a Kia dealer.
The contact owns a 2015 Kia Sorento. The contact stated that while driving at 10 MPH, he heard knocking sounds coming from the engine. There were no warning lights illuminated. The contact continued to drive the vehicle. The contact stated that the failure reoccurred while driving at 50 MPH and the vehicle stalled. The contact veered to the side of the road. The contact was unable to restart the vehicle. The vehicle was towed to an independent mechanic who diagnosed that the engine seized and that the rod bearing might have failed. The dealer was notified of the failure and informed the contact that the VIN was not included in any recalls related to the failure. The vehicle was towed to the contact's residence. The contact stated that he was able to start the vehicle, but he would still hear abnormal sounds coming from the engine. The contact referenced the federal safety agency Campaign Number: 17V224000 (Engine and Engine Cooling). The manufacturer was notified of the failure and opened a case. The manufacturer also referred the contact to the dealer for diagnostic testing. The vehicle was not repaired. The failure mileage was approximately 130,062.
Car continually trying to over-heat. Had to keep pulling to shoulder every 1/4 mile or so, and letting car cool down again. Mechanic diagnosed as a head gasket problem, but upon further research it looks like it may have actually warped the engine block itself. When mechanic calls around to multiple junkyards, found many 2015 kia sorentos, but no engines available due to the same problem. Vehicle is at approx 133,000 miles, and Kia is stating that the vehicle is not in the extended engine warranties effected by this problem (apparently happens more so in another model of kia, I believe they said Optima, but I didn't pay that close of attention since my car is a Sorento.)
The contact owns a 2015 Kia Sorento. The contact stated while driving 30 MPH, the vehicle inadvertently stalled. The contact veered to the side of the road but was unable to restart the vehicle after several attempts. The check engine warning light illuminated. The vehicle was towed to an independent mechanic who diagnosed that the engine had failed and needed to be replaced. The dealer was notified of the failure and informed the contact that she would be responsible for the cost of the repair because the vehicle was out of warranty. Additionally, the VIN was not under recall. The contact referenced the federal safety agency Campaign Number: 17V224000 (Engine and Engine Cooling). The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 150,000.
On October 6, 2021, I was driving my 2015 Kia Sorento to deliver work. I was driving through a mountain region when I heard a slight "ticking" noise coming from the engine. There was no safe place to pull over on the busy highway. There were mountains on each side of the highway no pull offs. There were lots of Semi trucks and Coal trucks driving fast on this highway. I kept driving looking for safe place to pull over. The ticking noise kept getting louder. There were no warning lights on the dashboard indicating any problem. Suddenly, the engine stopped. There was no power and no lights. It was all I could do to hold the steering wheel and coast the vehicle to a safe place. Finally, I found a safe pulloff. I coasted into it and called AAA. I waited three hours for AAA to show up. The AAA mechanic tried the start the engine with no success. He towed the vehicle to my home. I contacted a mechanic. The Ki would start and make loud knocking noises and then shut down again. The mechanic gave me an estimate for a new engine for $6,900 and told me he has seen this problem with this engine in this model Kia before. He said the manufacturer failed to debur the engines when they put the vehicles together causing metal fragments to filter through the engine causing engine failure. The mileage was approximately 151,000. I never received any recalls for the (KSDS) Knock Sensor Detection System.
My vehicle had two safety recalls regarding the possibility of a sudden engine fire due to a defective Hydraulic Electronic Control Unit (HECU). Additionally, in Milwaukee, theft of Kias has increased exponentially. The number of Kia models stolen increased 25 times higher in the first six months of 2020 by a gang calling themselves the "Kia Boys." The thefts have risen because Kia models 2011 or newer do not have an immobilizer which could prevent thefts. As a senior, my safety is placed at risk because of a combustible engine fire that could start without warning. Moreover, my vehicle is at risk of being stolen at any time because it lacks an immobilizer to prevent easy access. I want KIA or CarMax to buy back and refund me for these two latent defects that I could not have been aware of upon purchasing. Even though I had the CarFax report, I could not have been aware that the HECU recalls could cause an engine fire until I read articles about the recall from car experts. Further, as a layperson and unwary consumer, I could not have been aware of the latent defect of the steering column defect that could make theft of the vehicle easier.
Vehicle was being driven when the engine blew-up and became inoperable. After taking it to a mechanic, they said that the oil had stopped flowing through the engine and caused it to malfunction. There were no lights that appeared on the dashboard warning us of a problem.
Three days after getting my regular oil change , my engine started getting this loud knocking noise and I was not able to speed , I was coming into the freeway when my car suddenly got a loss of power , I checked my vehicle diagnostics and it wasn’t showing anything about the engine no warning or anything when I took it to get seen by a mechanic they told me I had to get my engine replaced
The contact owns a 2015 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The failure occurred on three separate occasions. The vehicle was towed to an independent mechanic and diagnosed with engine failure. The engine needed to be replaced. The vehicle was not repaired and remained with the independent mechanic. The manufacturer was made aware of the failure and informed the contact that they had sent out a manufacturer's recall notification for the Knock Sensor Detection System (KSDS) software update; however, the contact had not received the recall notification. The failure mileage was approximately 76,000.
While operating my vehicle I experienced sluggishness and power failure. Sorento became disabled on main road while driving to work. Vehicle was towed to the closest Kia dealership where they performed a diagnostic test. Maintenance test and Parts Department revealed the that the power shortage was possibly from a Brake fluid leakage inside the Hydraulic Electronic Control Unit (HECU). This also caused the engine to seize and the only remedy was a new engine. He also stated that the repair was not covered under warranty due to the open recall that was not completed. I did explain to the repair center that I was never made aware of any on going recalls from the dealer where I purchased the vehicle either by mail, phone call or email as well as from Kia corporate. The parts department provided me with the contact information for Kia Headquarters to assist me. Kia Headquarters provided me with a case number 14188680 and that they would contact the dealer and get back to me. After a couple days with no response, I called back with the case number, however, I got a new customer service rep. who said that nothing has been completed yet. This went on for a couple weeks with me calling to try to get updates and contacting the dealership parts department who said that their headquarters has not contacted the dealership and that according to their policy with Kia corporate the replacement of the engine would be at my expense. The estimated cost was quoted at about $8,000.00 dollars. I told the parts department at the dealership that I did not understand, how could I be responsible if the engine was a defect and I received no word of a recall from Kia. The parts department response was that is Kia Headquarters policy that they recall had to be completed or Kia was not responsible.
Upon accelerating causes a lot of exhaust smoke and bogs down so I can’t get out of the way and others behind me cannot see a thing. Two Kia dealerships refused assistance. The first after I called 12/3 to report that my vehicle issue made additional hazard involving a semi (thank goodness no one wreaked) and it was still smoking and smelled as if something was burning. The other telling me it would be six months at least. The warning dashboard lights did not trigger during or after incidents. The only light that came on ever was the oil light the prior weekend. I had the oil changed, filters replaced as well as the headlights for the third time. Around 44k miles when issues started and escalated quickly. Other problems reported to Arapaho Kia a few years ago consisted of back passenger door not latching. Someone flagged me down on the highway as I had my daughter in her car seat on that side. No warning lights triggered, dealership unable to duplicate issue. Steering control keys controlling opposite functions or not working intermittently. Was told steering control harness needed replacement. Think that was at 18k miles but not sure. Did not have replaced at that time as it mainly affected radio functions hands free calling did stop working. I usually didn’t make calls in the car anyway. I was left with no other choice but to trade the vehicle in before something really bad happened or it self destructed leaving me without out a car still paying on. I could not be without a car for six months as Peak Kia quoted timeframe. Untimely fixing of recall on vehicle likely manifesting these other issues and causing additional damage to vehicle.
This 2015 KIA Sorrento was purchased new 8/14. It has been regularly serviced/maintained since.In Nov 2018 the AWD would not engage during a snowstorm, I was left stranded and had to be towed to the Dealership. The AWD coupler needed to be replaced. October 1, 2021, the car was inspected and passed with no major issues. November 6, 2021, the car would not start. It was jump started and brought to a local Auto Repair Facility where I was advised it needed a new battery. New battery installed and on November 8, 2021, the car would not start. I returned to the same facility & had them check the battery, alternator and starter. All was fine. They recommended I return to Healy KIA, Newburgh, NY, and have them check the computer board. December 1, 2021, Healy KIA informed me that the head gasket was shot and that I needed an engine rebuild. I questioned this as the car was only 5 years old, I only drive the car locally, and that I have done no extensive travel in over 2 years since Covid-19. Healy KIA never offered to replace the engine, only the rebuild for $11K. I contacted KIA Corporate on December 2, 2021 to file a concern (Case #14515621) and was advised by that Rep I was out of warrantee, admitted there had been engine recalls in the past, but a Manager would review my case and call me w/in 2-3 business days. To date, no return call. I began calling KIA(800)333-4542 for these past 3 days & the automated phone system either dropped the call or transferred me to Road Side Assistance. December 8, 2021, I finally got through to another KIA Rep, who confirmed my case number and stated my case was still under review awaiting verifying information from Healy Kia confirming the damage and the estimate. I advised the KIA Rep that I had a copy of that estimate so he instructed me to upload this information at www.KIA.com. Ironically, the case number KIA provided, my name/email is invalid according to the KIA website. I need your help and guidance. Please advise. Thank you!
The engine failed and is available for inspection. My daughters and my safety were put at risk when trying to accelerate onto the interstate on ramp and was slow to do so. The car never made it to the speed limit and actually started slowing down. When trying to speed up it started making a knocking sound which ended up leaving us stranded on the side of the interstate on Easter Sunday, so there was more than the normal traffic. The engine light or any other warning lights came on before this happened. The engine was inspected by a Kia service center. And as this was a mechanical issue, the insurance would not do anything.
Car is at 124,000 miles and well-maintained with all services done to date. However the Engine failed and will not run. No warning lights and suddenly stopped with loss of power and then will not start. Dealer says new engine will have to be put in and current engine is dead.
UNKNOWN. Excessive shaking, engine light started to blink and car shut off.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Kia Sorento?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history